Transfer Case
- Preparation
- Precautions
- All-Mode 4WD System
- On Board Diagnostic System Description
- Trouble Diagnosis - Introduction
- Trouble Diagnosis - Basic Inspection
- Trouble Diagnosis - General Description
- DTC U1000, U1001 Can Communication Line
- 4WD Solenoid Valve
- 2-4WD Shift Solenoid Valve And 4WD Shift Switch
- Transfer Motor And Transfer Motor Relay
- Transfer Fluid Temperature Sensor
- ATP Switch, Wait Detection Switch And Neutral-4LO Switch
- Clutch Pressure Switch
- Line Pressure Switch
- Data Erase/Display
- Shift Actuator
- Shift Actuator Position Switch
- Shift Actuator Circuit
- Diagnostic Procedure
- 1. Shift Actuator Circuit
- 2. Check Power Source Of Transfer Shift (Hi & Low) Relay
- 3. Check Power Source Of Transfer Control Device
- 4. Check Input Signal
- 5. Check Input Signal
- 6. Check Input Signal
- 7. Check Harness Continuity Between Transfer Control Unit And Transfer Shift High And Low Relays
- 8. Perform Self-Diagnosis Again
- Diagnostic Procedure
- Trouble Diagnoses For Symptoms
- Symptom 1: 4WD Shift Indicator Lamp Does Not Turn On (Although The Ignition Switch Is Turned "On", All The 4WD Indicator Lamps Do Not Turn On For 1 Second)
- Symptom 2: 4WD Warning Lamp Does Not Turn On (Although The Ignition Switch Is Turned "On", The 4WD Warning Lamp Does Not Turn On)
- Symptom 3: 4WD Shift Indicator Lamp Does Not Turn Off (When 4WD Shift Switch Is Set From "4H" To "4LO", All The 4WD Shift Indicator Lamps Do Not Turn Off)
- Symptom 4: ATP Warning Lamp Does Not Turn On (When 4WD Shift Switch Is Set From "4H" To "4LO" With The A/T Selector Lever In "P" Position, The ATP Warning Lamp Does Not Turn On)
- Symptom 5: 4LO Indicator Lamp Does Not Turn On (When 4WD Shift Switch Is Set From "4H" To "4LO" Position, 4LO Indicator Lamp Does Not Turn On)
- Symptom 6: 4WD Shift Indicator Lamp Does Not Indicate "Lock" (When 4WD Shift Switch Is Set To "4H", 4WD Shift Indicator Lamp Does Not Indicate "Lock")
- Symptom 7: 4WD Shift Indicator Lamp Repeats Flickering (4WD Shift Indicator Lamp Keeps Flickering)
- Symptom 8: Tight Corner Braking Symptom (Tight Corner Braking Symptom Occurs) (Hydraulic System Failure)
- Symptom 9: 4WD System Does Not Operate (The Vehicle Cannot Be Put Into 4WD Mode) (Hydraulic System Failure)
- Component Inspection
- 4WD Shift Switch
- 2-4WD Shift Solenoid Valve And Transfer Fluid Temperature Sensor
- 4WD Solenoid Valve, Clutch Pressure Switch And Line Pressure Switch
- Transfer Dropping Resistor
- ATP Switch, Neutral-4LO Switch And Wait Detection Switch
- Transfer Motor
- Transfer Motor Relay
- Transfer Shift Relay (High & Low)
- Actuator & Actuator Position Switch
- Front Oil Seal
- Side Oil Seal
- Rear Oil Seal
- Transfer Motor
- Transfer Oil Filter
- Removal And Installation
- Overhaul
- Rear Case - Disassembly
- Center Case - Disassembly
- Front Case - Disassembly
- Front Case - Inspection
- Center Case - Inspection
- Front Case - Assembly
- Center Case - Assembly
- Final Assembly
- Service Data And Specifications (SDS)