Section 2 (Automatic HVAC Systems)
WARNING: This page is about a different car, the 2001 Dodge Grand Caravan and 2001 Chrysler Town & Country. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Description
- Operation
- Adjustments
- Programming
- Self-Diagnostic System
- Diagnostic Tests
- Notes
- Test A: DTC P0645 - A/C Clutch Relay Circuit
- Test B: DTC P1598 - A/C Pressure Sensor Volts Too High
- Test C: DTC P1599 - A/C Pressure Sensor Volts Too Low
- Test D: A/C Pressure Too High (Stored)
- Test E: Ambient Air Temperature Message Missing
- Test F: Body Status Message Missing
- Test G: Coolant Temperature Message Missing
- Test H: Cool Down Test Failed
- Test I: Driver Blend Door Not Responding
- Test J: Door Travel/Range Too Large
- Test K: Door Travel/Range Too Small
- Test L: EEPROM Checksum Error
- Test M: Engine Sensors Message Missing
- Test N: Evaporator Temperature Sensor Open
- Test O: Evaporator Temperature Sensor Shorted
- Test P: EVIC Message Missing
- Test Q: Front Infrared (Ir) Sensor Failure
- Test R: Front Ir Sensor Not Calibrated
- Test S: Front Keyboard Communication Fault
- Test T: Front Mode Door Not Responding
- Test U: Invalid Conditions For A/C Cool Down Test
- Test V: Passenger Blend Door Not Responding
- Test W: PCI Bus Shorted High (Or Low)
- Test X: Personality Message Missing
- Test Y: Rear Blend Door Not Responding
- Test Z: Rear Fan Potentiometer Open
- Test Aa: Rear Ir Sensor Not Calibrated
- Test Ab: Rear Keyboard Fault
- Test Ac: Rear Mode Door Not Responding
- Test Ad: RECIRCULATION Door Not Responding
- Test AE: Refrigerant Pressure Message Missing
- Test AF: Vehicle Odometer Message Missing
- Test Ag: Vehicle Speed/Rpm Message Missing
- Test Ah: Vacuum-Fluorescent (VF) Dimming Message Missing
- Test Ai: VIN Message Missing
- System Tests
- Component Tests
- Verification Tests
- Removal & Installation
- Notes
- A/C Pressure Transducer
- Compressor
- Condenser
- Evaporator Temperature Sensor
- Filter-Drier
- Floor Distribution Ducts
- Front A/C-Heater Control Panel
- Front Blend Door Actuator
- Front Blower Motor
- Front Blower Motor Resistor
- Front Expansion Valve
- Front Heater Core
- Front Heater Core Extension Tubes
- Front HVAC Unit Housing
- Front Mode Door Actuator
- Front Power Module
- Front RECIRCULATION Door Actuator
- Instrument Panel
- Rear Blend Door Actuator
- Rear Blower Motor
- Rear Blower Motor Resistor
- Rear Evaporator
- Rear Evaporator Line Extension
- Rear Expansion Valve
- Rear Heater Core
- Rear Heater Core Filling
- Rear HVAC Unit Housing
- Rear Mode Door Actuator
- Rear Power Module
- Underbody Lines
- Torque Specifications
- Wiring Diagrams