Technical Service Bulletins: Other Variant
WARNING: This page is about the 6 i Grand Touring, 2.5 A, Automatic, which is a different variant/trim than selected.
- A/C Compressor
- Accessories & Equipment
- Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Electrical Concern And/Or Multiple DTC'S Due To Aftermarket Device (MT-017/17)
- Connectivity Master Unit/Hands-Free BLUETOOTH Module/Text Messaging Troubleshooting Procedure And Part Exchange Process (09-042/08)
- Blind Spot Monitoring (BSM) System Frequently Asked Questions (FAQ) (SA-055/17)
- Display Shows Inaccurate Ambient Temperature (09-023/14)
- Accessory Power Plug/Charger Stuck In Accessory Socket (09-013/10)
- DTCs STORED IN MEMORY DUE TO LOW BATTERY VOLTAGE (01-032/09)
- No Start Condition After Accessory Remote Start System Installation (09-011/09)
- Hazard Switch - Poor Alignment (6209)
- Module Replacement/Reprogramming Information (6635)
- MAZDA Service Program (MSP22) - Auto Wiper / Headlamps Inoperative - Accessory HOMELINK / Compass Mirror (09-039/08)
- Precautions For Module Reprogramming (01-030/08)
- Accessory Drive Belts
- Aerodynamic Devices
- Air Bag, SRS
- Anti-Theft Systems
- Keyless Entry Remote Transmitter (Key Fob) Battery Replacement Caution (09-041/10)
- Rear Door Locks Inoperative Due To Freezing (09-039/09)
- Burglar Alarm Malfunction (09-024/10)
- Keyless Entry System Transmitter Inoperative - (Retractable Type Key) (09-026/09)
- Advanced Key Does Not Operate (09-013/09)
- Engine Hard To Start - Keyless Control Module (09-014/09)
- Keyless Entry Transmitter Separation From Key (09-011/08)
- Fail-Safe Mode For Keyless Control Module And Steering Lock Unit (09-006/09)
- Interior Door Handle Inoperative (6205)
- Rear Door Locks INOP / Wrong Rear Door Harness (6477)
- Red Key Light On / No Start B10E6/U515_92 (6671)
- Retractable Key Transportation Cover (6498)
- Smart Key / Auxiliary Key (6115)
- Smart Key / Push Button Starting Procedure (6116)
- Smart Key / Unlock Options (6118)
- Special Ignition On Function (W/Push Button Start) (5955)
- Trunk Request Switch INOP (6532)
- Restoring Vehicle Personalization Features After Module Replacement (09-032/08)
- Automatic Trans
- Automatic Transmission/Transaxle Cooler And Lines Flushing Procedure (05-012/10)
- Correct Application For ATF M-V (Type M5), MERCON®V, MERCON®LV, And JWS3309 (T-IV) Automatic Transmission Fluids (05-005/08)
- Automatic Transmission Diagnostic Procedure (05-004/11)
- Diagnostic Procedure For Engine Noise Repair (01-053/09)
- ATF Leak From A/T Servo Cover (05-015/09)
- 2.5 L At Vibration Park To Reverse (6526)
- Transmission Dip Stick Color/Fluid Identification (6459)
- FS5A-El Transaxle Fluid Diagnosis (05-010/08)
- Auxiliary Emission Control Systems
- Multi-Model - Determining Evaporative System Leak Location For DTCS P0441/P0442/P0455/P0456 (01-023/10)
- Unusual Noise From Exhaust Pipe Seal Ring (01-052/08)
- MAZDA Service Program (MSP27) - Readiness Code For Evaporative Monitoring System (01-005/12)
- Collect Diagnostic Information Using M-MDS (01-032/11)
- Mil Illumination With DTC P0456:00 (01-024/09)
- Special Tool Shipment - July 2008 (ST-004/08)
- Axle Shafts
- Body Electrical
- Body Interior
- Connectivity Master Unit/Hands-Free BLUETOOTH Module/Text Messaging Troubleshooting Procedure And Part Exchange Process (09-042/08)
- As-Built Data Search On Ms3 (00-001/10)
- DTCs STORED IN MEMORY DUE TO LOW BATTERY VOLTAGE (01-032/09)
- Restoring Vehicle Personalization Features After Module Replacement (09-032/08)
- Brakes Control Systems
- Charging Systems
- Collision/Avoidance
- Communication Devices
- Connectivity Master Unit/Hands-Free BLUETOOTH Module/Text Messaging Troubleshooting Procedure And Part Exchange Process (09-042/08)
- BLUETOOTH Hands-Free Voice Performance Improvement At Far End (09-046/09)
- BLUETOOTH Hands-Free Pairing Does Not Work (09-006/10)
- BLUETOOTH New Features For 2009MY (5916)
- MAZDA Service Program (MSP22) - Auto Wiper / Headlamps Inoperative - Accessory HOMELINK / Compass Mirror (09-039/08)
- Cooling Fan
- Cooling System (Mechanical)
- Differentials & Drive Axles
- Engine Control Systems
- Multi-Model - Determining Evaporative System Leak Location For DTCS P0441/P0442/P0455/P0456 (01-023/10)
- Oxygen/Air Fuel Ratio Sensor Removal Caution (01-051/09)
- Collect Diagnostic Information Using M-MDS (01-032/11)
- Mil Illumination - DTC P0600 (01-051/10)
- As-Built Data Search On Ms3 (00-001/10)
- Mil Illumination - DTC P0111:00 (01-030/10)
- Mil Illumination With DTC P2100:00 (01-020/09)
- DTC P06B8 After KAM Reset Or Pcm Reprogramming (6860)
- Mil Illumination With DTC P0456:00 (01-024/09)
- Unstable Idling/Engine Stalls Just After Stopping (01-007/09)
- Module Replacement/Reprogramming Information (6635)
- Permanent DTC (PDTC) (6601)
- Precautions For Module Reprogramming (01-030/08)
- Entertainment Systems
- Audio/Infotainment System Service Information (09-074/09)
- SIRIUSXM Satellite Radio Registration Transfer After Unit Replacement (09-030/13)
- Audio Cd Text Does Not Always Display (09-020/08)
- Rattle Noise From Front Door (09-026/10)
- Models That Can Have "The Best Of XM" (6831)
- Updating Best Of XM Stations On SIRIUS 2.0 Systems (6608)
- Wrong Radio Install / Non BOSE System (6479)
- Water In Combination Light - Improper Satellite Radio Antenna Cable Routing (09-028/08)
- Blind Spot Monitoring SST - Application Update - August 2008 (ST-006/08)
- Exhaust
- Exterior Body Panels
- Hollow Sound When Closing Front Door(S) (09-003/09)
- Fuel Filler Door Spring (6475)
- Grille Improper Installation (6480)
- Manual Trunk Release / Access (6109)
- Rear Finisher Foam Exposed (6521)
- Trunk Request Switch INOP (6532)
- MAZDA Service Program (MSP19) - Wind Noise From Driver Side Door Sash / B-Pillar Area (09-037/08)
- Exterior Lights
- Condensation/Fog In Front And Rear Combination Lamps (Headlamp And TAILLAMP Assemblies) (09-049/14)
- Condensation/Fog In Front And Rear Combination Lights (09-057/10)
- Rear Combination Light Heat Deformation (09-034/10)
- Moisture, Fogging, Or Water Droplets Around Edge Of Rear Combination Light (09-049/09)
- Hazard Switch - Poor Alignment (6209)
- Unable To Configure The "LCM" (Error Message) (6507)
- Restoring Vehicle Personalization Features After Module Replacement (09-032/08)
- Water In Combination Light - Improper Satellite Radio Antenna Cable Routing (09-028/08)
- Frames, Subframes & Crossmembers
- Fuel System
- Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Collect Diagnostic Information Using M-MDS (01-032/11)
- Mil Illumination With DTC P2100:00 (01-020/09)
- Unstable Idling/Engine Stalls Just After Stopping (01-007/09)
- Engine Light Tick Noise On Cold Start (6563)
- Replacing Engine Check Intake And Exhaust Debris (6757)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Display Shows Inaccurate Ambient Temperature (09-023/14)
- Elimination Of Odometer Write For MAZDA Modular Diagnostic System (M-MDS) (01-031/10)
- Fuel Gauge Does Not Indicate Full Just After Refueling (09-044/09)
- DTCs STORED IN MEMORY DUE TO LOW BATTERY VOLTAGE (01-032/09)
- Hazard Switch - Poor Alignment (6209)
- Restoring Vehicle Personalization Features After Module Replacement (09-032/08)
- Odometer Data Configuration (09-034/06)
- Headlights
- Condensation/Fog In Front And Rear Combination Lamps (Headlamp And TAILLAMP Assemblies) (09-049/14)
- Headlight Plastic Lens Maintenance Caution (09-035/09)
- Condensation/Fog In Front And Rear Combination Lights (09-057/10)
- MAZDA Service Program (MSP22) - Auto Wiper / Headlamps Inoperative - Accessory HOMELINK / Compass Mirror (09-039/08)
- Horns
- HVAC Control Systems
- Identification
- Ignition Switch/Steering Lock
- Red Key Light On / No Start B10E6/U515_92 (6671)
- Retractable Key Transportation Cover (6498)
- Smart Key / Auxiliary Key (6115)
- Smart Key / Push Button Starting Procedure (6116)
- Special Ignition On Function (W/Push Button Start) (5955)
- Steering Lock Operation / Noise (6096)
- Advanced Keyless Entry And Push Button Start System (09-026/08)
- Infotainment
- Audio/Infotainment System Service Information (09-074/09)
- Navigation Display Standard For Failed Pixels (09-081/09)
- Navigation Changes For 2008 Model Year & Issues (5722)
- MAZDA Service Program (MSP22) - Auto Wiper / Headlamps Inoperative - Accessory HOMELINK / Compass Mirror (09-039/08)
- Blind Spot Monitoring SST - Application Update - August 2008 (ST-006/08)
- Interior/Exterior Trim
- Proper Usage Of Driver's Floor Mat (09-027/14)
- Exterior Trim Heat Damage (MT-038/16)
- Headlight Plastic Lens Maintenance Caution (09-035/09)
- Dashboard Upper Surface Poor Appearance (09-038/12)
- Overhead Console Sunglass Holder Does Not Close Properly (09-022/12)
- Front Windshield Protector - Cowl Removal Service Tip (7370)
- Front Facia Popped Out At Fender (09-029/10)
- Console Latch Breakage (09-067/09)
- Accessory Power Plug/Charger Stuck In Accessory Socket (09-013/10)
- Poor Appearance - Exposed Dashboard Foam (09-066/09)
- PVC Shifter Knob Gouged / Damaged (05-013/09)
- Front Seat-Back Trim Pulls Out At Lower Outer Edge (09-007/09)
- Accessory Spoiler Installation (6553)
- Console Cover-Dual Operation (6111)
- Exhaust Tip Bent (6482)
- Front Emblem - Retaining Clip Broken (6206)
- Glove Box Damper Sticking (6524)
- Glove Box Dash Interference (6652)
- Grille Improper Installation (6480)
- Incorrect Overhead Console (6470)
- Interior Door Handle Inoperative (6205)
- Rear Door Seaming Welt Installation (6423)
- Rear Finisher Foam Exposed (6521)
- Rear Mud Guard Rubbing Tire (6510)
- Vibration/Buzz Noise From Window Switch (6207)
- Windshield Molding Deformation (6426)
- MAZDA Service Program (MSP19) - Wind Noise From Driver Side Door Sash / B-Pillar Area (09-037/08)
- MAZDA Service Program (MSP20) - Glove Box Stopper Over-Travel (09-038/08)
- Interior/Illumination Lights
- Lubrication System
- Manual Trans
- Mechanical
- High Engine Oil Consumption (MT-012/15)
- Replacement Engine Assembly Failure (MT-014/16)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Diagnostic Procedure For Engine Noise Repair (01-053/09)
- Engine Compartment Shroud Panel Poor Appearance (09-034/09)
- L5 Engine Oil Pan Removal / Installation Procedure And (01-027/09)
- Engine Light Tick Noise On Cold Start (6563)
- Mechanical - Air
- Mechanical - Hydraulic
- Mirrors
- Passive Restraints
- Procedures
- Rear Suspension
- Restraints Control Systems
- Air Bag System Warning Light Flashing With DTC B1126:1B Or B1127:1B (08-001/25)
- Passenger Airbag Deactivation (Pad) Indicator Light Illumination (08-003/11)
- As-Built Data Search On Ms3 (00-001/10)
- DTCs STORED IN MEMORY DUE TO LOW BATTERY VOLTAGE (01-032/09)
- Module Replacement/Reprogramming Information (6635)
- Schedule
- Seats
- Seat Warmer Inoperative (09-024/11)
- Seat Trim Replacement Procedure (09-076/09)
- Squeaking Noise From Seat Back Due To Frame And Seat Back Pad Contact (09-069/09)
- Rattling Or Chattering Noise From Headrest (09-063/09)
- Squeaking Noise From Seat Back Due To Frame And Spring Contact (09-064/09)
- Squeaking Noise From Under Driver Seat Lifter Link (09-065/09)
- Clunk Noise From Seat When Braking (09-060/09)
- Seat Shakes Back And Forth/Makes Noise When Braking (09-061/09)
- Squeaking Noise From Leather Seats (09-062/09)
- Front Seat-Back Trim Pulls Out At Lower Outer Edge (09-007/09)
- Front Seatback Cover Loose At Bottom (6487)
- Head Rest Removal (6110)
- Lumbar Inoperative (6208)
- Starter
- 12 Volt Battery Test Procedure Requirements For Warranty (Using The COA-8000PM) (01-054/10)
- Battery Maintenance (01-029/06)
- Vehicle Key Or Remote Start Will Not Program (MT-014/15)
- All Models - Use Gr8 Battery Charger When Reprogramming Modules (MT-014/17)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
- Special Service Equipment Distribution - November 2010 (ST-002/10)
- Battery Condition Based On Battery Eye Indication (01-037/10)
- JIS/BCI Standard To CCA Conversion Chart (01-010/10)
- JIS/BCI Standard To CCA Conversion Chart (00-003/09)
- No Start Condition After Accessory Remote Start System Installation (09-011/09)
- Battery Charging / Jump Start Tips (6782)
- MAZDA5, MAZDA6 Perceived Long Crank Time (6656)
- Red Key Light On / No Start B10E6/U515_92 (6671)
- Steering Column
- Steering Control Systems
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Multi-Model - Determining Evaporative System Leak Location For DTCS P0441/P0442/P0455/P0456 (01-023/10)
- Oxygen/Air Fuel Ratio Sensor Removal Caution (01-051/09)
- Mass Air Flow (MAF) Sensor Inspection Procedure (01-009/12)
- Collect Diagnostic Information Using M-MDS (01-032/11)
- Mil Illumination - DTC P0600 (01-051/10)
- Mil Illumination - DTC P0111:00 (01-030/10)
- Mil Illumination With DTC P2100:00 (01-020/09)
- DTC P06B8 After KAM Reset Or Pcm Reprogramming (6860)
- Mil Illumination With DTC P0456:00 (01-024/09)
- Permanent DTC (PDTC) (6601)
- Mil On - P0442, P0455, P0456 Set - Revised Diagnostic Procedure / New SST (01-034/08)
- Transmission Control Systems
- Warning Systems
- Wheel Hubs
- Wheels & Tire System
- Window Motors & Regulators
- Wiper/Washer Systems