Technical Service Bulletins
- A/C Compressor
- Accessories Control Systems
- Change In SPS Programming (365-2466)
- Updated And New Fault Diagnosis In WIS (248-2435)
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- Soft Top Cannot Be Operated (811-2236)
- Not Possible To Program TRIONIC T7 (248-2243)
- Replacing Tab On Electrically Heated Rear Window (811-1950)
- Special Tool - Service Programming SYS. Hardware Key (101-9039)
- TIS 2000 (Technical Information System) (101-9040)
- Battery Maintenance Program (311-2009)
- Dice Activates The Hazard Flashers (98-12-365)
- Tech 2 Software 29.000 And Earlier (98-11-248)
- Incorrect Indication Of Tyre Size On Tech2 (98-09)
- SID Message "Time For Service" (381-1934)
- Aerodynamic Devices
- Air Bag, SRS
- Anti-Theft Systems
- Rattle From First Bow & Latch Difficult To Operate (811-2091)
- Remote Control Labels (00-11-100)
- Rear Doors, Difficult To Open From Outside (831-2107 ED. 2)
- Rear Doors, Difficult To Open From Outside (831-2107 UTG. 2)
- Rear Doors Difficult To Open From Outside (831-2107)
- Battery Maintenance Program (311-2009)
- Door Weather Seal Fits Poorly At Top Of B-Pillar (831-2109 ED. 2)
- Self-Locking/Unlocking - Car Fails To Start (98-11-834)
- Automatic Trans
- Common Faults On Automatic Transmissions (210-2554)
- Common Faults On Automatic Transmissions (100-2512)
- Common Faults On Automatic Transmissions (100-2500)
- Common Faults On Automatic Transmissions (381-2495)
- Common Faults On Automatic Transmissions (890-2263)
- Common Faults On Automatic Transmissions (248-2391)
- Common Automatic Transmission Faults (440-2220)
- Common Faults On Automatic Transmissions (440-2181)
- New Essential Special Tools (101-2142)
- Auxiliary Emission Control Systems
- New Failed Object 190 70 Fault Diagnosis, Engine Electronics (371-2551 ED2)
- New Failed Object 190 70 Fault Diagnosis, Engine Electronics (371-2586 ED2)
- New Failed Object 190 70 Fault Diagnosis, Engine Electronics (371-2576 ED2)
- Supplementary Fault Diagnosis, Catalytic Converter, T7 And T8 (248-2493)
- Supplementary Fault Diagnosis, Catalytic Converter, T7 And T8 (248-2506)
- Reduced Performance And Diagnostic Trouble Code For EGR Valve (248-2492)
- Change In SPS Programming (365-2466)
- Updated And New Fault Diagnosis In WIS (248-2435)
- Oil Leakage From Engine (210-2418)
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- Not Possible To Program TRIONIC T7 (248-2243)
- Complaint Of Sulfur Smell From Exhaust (100-0587)
- Special Tool - Service Programming SYS. Hardware Key (101-9039)
- TIS 2000 (Technical Information System) (101-9040)
- Tech 2 Software 29.000 And Earlier (98-11-248)
- Test Cable Assembly (98-11-248)
- SID Message "Time For Service" (381-1934)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Electrical
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Wiring Harness Repair Kit (371-1703 UTG. 4)
- Spurious DTCS In Airbag System (SRS) (850-2076)
- Wiring Harness Repair Kit (371-1703 UTG. 3)
- Body Interior
- Change In SPS Programming (365-2466)
- Updated And New Fault Diagnosis In WIS (248-2435)
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- Soft Top Cannot Be Operated (811-2236)
- Not Possible To Program TRIONIC T7 (248-2243)
- Special Tool - Service Programming SYS. Hardware Key (101-9039)
- TIS 2000 (Technical Information System) (101-9040)
- Dice Activates The Hazard Flashers (98-12-365)
- Tech 2 Software 29.000 And Earlier (98-11-248)
- Incorrect Indication Of Tyre Size On Tech2 (98-09)
- SID Message "Time For Service" (381-1934)
- Brakes Control Systems
- Change In SPS Programming (365-2466)
- Updated And New Fault Diagnosis In WIS (248-2435)
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- Not Possible To Program TRIONIC T7 (248-2243)
- Special Tool - Service Programming SYS. Hardware Key (101-9039)
- TIS 2000 (Technical Information System) (101-9040)
- Leaking Brake Fluid Reservoir (522-2017)
- Proper Brake Fluid Cap Fit (522-2043)
- Charging Systems
- Communication Devices
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Engine Control Systems
- New Failed Object 190 70 Fault Diagnosis, Engine Electronics (371-2551 ED2)
- New Failed Object 190 70 Fault Diagnosis, Engine Electronics (371-2586 ED2)
- New Failed Object 190 70 Fault Diagnosis, Engine Electronics (371-2576 ED2)
- Updating The Software In The Engine Control Module T8 (248-2689 UTG. 2)
- Updating The Software In The Engine Control Module T8 (248-2690 UTG. 2)
- Change In SPS Programming (365-2466)
- Updated And New Fault Diagnosis In WIS (248-2435)
- Tech2 (03-09-248)
- Extra Diagnosis/Information Ref: P2135 Fa - Pedal Position Sensor Circuit (TA248-0321)
- SPS And Tech2 (02-11-248)
- Fault Diagnosis In Connection With Long Start Time, Diesel (210-2148 ED. 3)
- Improved Fault Diagnosis P0314 (248-2306)
- Important Information Concerning Mi, Starting Problems TRIONIC T7 (248-X107)
- Air Leak Testing Of Intake System, TRIONIC T7 4 CYL. (248-2241)
- Not Possible To Program TRIONIC T7 (248-2243)
- Special Tool - Service Programming SYS. Hardware Key (101-9039)
- TIS 2000 (Technical Information System) (101-9040)
- Self-Locking/Unlocking - Car Fails To Start (98-11-834)
- Tech 2 Software 29.000 And Earlier (98-11-248)
- Test Cable Assembly (98-11-248)
- SID Message "Time For Service" (381-1934)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Checking/Replacement Of Injectors (234-2655)
- Extra Diagnosis/Information Ref: P2135 Fa - Pedal Position Sensor Circuit (TA248-0321)
- Fault Diagnosis In Connection With Long Start Time, Diesel (210-2148 ED. 3)
- Improved Fault Diagnosis P0314 (248-2306)
- Air Leak Testing Of Intake System, TRIONIC T7 4 CYL. (248-2241)
- Complaint Of Sulfur Smell From Exhaust (100-0587)
- Fuses & Circuit Breakers
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Wiring Harness Repair Kit (371-1703 UTG. 4)
- Replacing Tab On Electrically Heated Rear Window (811-1950)
- False Diagnostic Trouble Codes In Airbag System (850-2076)
- Battery Maintenance Program (311-2009)
- Spurious DTCS In Airbag System (SRS) (850-2076)
- Wiring Harness Repair Kit (371-1703 UTG. 3)
- Gauges & Instrument Panels
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Identification
- Ignition System
- Infotainment
- Interior/Exterior Trim
- New Essential Special Tools (101-2142)
- Cracks In Soft-Top Cover Foil Strip (811-2094 ED. 2)
- Access Flap Ribs Chafing Against Roof Seal (811-2162)
- Door Weather Seal Fits Poorly At Top Of B-Pillar (831-2109)
- Door Weather Seal Fits Poorly At Top Of B-Pillar (831-2109 ED. 2)
- Change Of Upholstery Of Backrest With Integrated Child Seat (852-1573 UTG. 2)
- Interior/Illumination Lights
- Lubrication System
- Manual Steering
- Manual Trans
- Mechanical
- Timing System Failure Due To Improper Servicing (PA001-14)
- Updating The Owner's Manual (100-2659)
- Noise From The Timing Chain And Oil Sludge In The Engine (210-2561)
- Service Interval Is Determined By Both Distance And Time (100-2490)
- Oil Leakage From Engine (210-2418)
- Recommended Oil Grade (02-10-210)
- Procedure To Remedy Coolant/Oil Leakage From Cylinder Head Without Gasket Replacement (210-2401)
- Air Leak Testing Of Intake System, TRIONIC T7 4 CYL. (248-2241)
- Mechanical - Hydraulic
- Memory Modules
- Mirrors
- Paint & Coatings
- Passive Restraints
- Procedures
- Service Interval Is Determined By Both Distance And Time (100-2490)
- Additional Service Point - Inspection Of Front Right Wheel Housing For Cracks (108-2286)
- Additional Service Point - Inspection Of Front Right Wheel Housing For Cracks (108-2274)
- Maintenance Program For Starting Battery (311-2145)
- SID Message "Time For Service" (381-1934)
- Rear Suspension
- Restraints Control Systems
- Change In SPS Programming (365-2466)
- Updated And New Fault Diagnosis In WIS (248-2435)
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- Soft Top Cannot Be Operated (811-2236)
- Not Possible To Program TRIONIC T7 (248-2243)
- Airbag System Warning Lamp (99-08-850)
- Special Tool - Service Programming SYS. Hardware Key (101-9039)
- New Special Tool - Test Cable For Airbag System (101-9038)
- TIS 2000 (Technical Information System) (101-9040)
- Spurious DTCS In Airbag System (SRS) (850-2076)
- Schedule
- Annual Service (101-2648)
- Service Interval Is Determined By Both Distance And Time (100-2490)
- Additional Service Point - Inspection Of Front Right Wheel Housing For Cracks (108-2286)
- Additional Service Point - Inspection Of Front Right Wheel Housing For Cracks (108-2274)
- SID Message "Time For Service" (381-1934)
- Seats
- Used Pyrotechnic Components (850-2528)
- Soft Top Cannot Be Operated (811-2236)
- Soft Top (Tonneau) Cover Does Not Open (811-1989)
- Noise From Front Seat (852-2133)
- Recall 710 - Change Of Easy Entry Cable (852-2152)
- Air In Soft Top Hydraulic System (811-2155)
- New Memory Contact For Front Seats (99-02-852A)
- Change Of Upholstery Of Backrest With Integrated Child Seat (852-1573 UTG. 2)
- Starter
- Steering Control Systems
- Steering Gear
- Sun Roof/T-Top/Convertible Top
- Rattle From First Bow & Latch Difficult To Operate (811-2091)
- Soft Top Cannot Be Operated (811-2236)
- Soft Top Cover Doesn't Open Or First Bow Hits Cover (811-2160)
- Soft Top (Tonneau) Cover Does Not Open (811-1989)
- Cracks In Soft-Top Cover Foil Strip (811-2094 ED. 2)
- Soft Top Cover Latch Jams Due To Deformed Hinge (811-2101)
- Access Flap Ribs Chafing Against Roof Seal (811-2162)
- Air In Soft Top Hydraulic System (811-2155)
- Noise From Fifth Bow Lock Mechanism (811-2092)
- The Soft Top Does Not Open (811-1989)
- Suspension Control Systems
- System
- New Failed Object 190 70 Fault Diagnosis, Engine Electronics (371-2586 ED2)
- New Failed Object 190 70 Fault Diagnosis, Engine Electronics (371-2576 ED2)
- New Software For Z19 (248-2651)
- Unnecessary Replacement Of The EHPS Control Module With Diagnostic Trouble Code C1550 37 (645-2660)
- Reduced Performance And Diagnostic Trouble Codes For The Turbo Control Valve (291-2494)
- Supplementary Fault Diagnosis, Catalytic Converter, T7 And T8 (248-2493)
- Supplementary Fault Diagnosis, Catalytic Converter, T7 And T8 (248-2506)
- Reduced Performance And Diagnostic Trouble Code For EGR Valve (248-2492)
- Change In SPS Programming (365-2466)
- Updated And New Fault Diagnosis In WIS (248-2435)
- Oil Leakage From Engine (210-2418)
- Tech2 (03-09-248)
- Extra Diagnosis/Information Ref: P2135 Fa - Pedal Position Sensor Circuit (TA248-0321)
- SPS And Tech2 (02-11-248)
- Fault Diagnosis In Connection With Long Start Time, Diesel (210-2148 ED. 3)
- Low Output And Rattling From Turbocharger (291-2338)
- Low Output And Rattling From Turbocharger (291-2327)
- Improved Fault Diagnosis P0314 (248-2306)
- Important Information Concerning Mi, Starting Problems TRIONIC T7 (248-X107)
- Air Leak Testing Of Intake System, TRIONIC T7 4 CYL. (248-2241)
- Not Possible To Program TRIONIC T7 (248-2243)
- Complaint Of Sulfur Smell From Exhaust (100-0587)
- Special Tool - Service Programming SYS. Hardware Key (101-9039)
- TIS 2000 (Technical Information System) (101-9040)
- Self-Locking/Unlocking - Car Fails To Start (98-11-834)
- Tech 2 Software 29.000 And Earlier (98-11-248)
- Test Cable Assembly (98-11-248)
- Amendment To Pre-Delivery Service For Cars With 2.0 Liter Engines Fitted With Tuning Kit (111-1990)
- SID Message "Time For Service" (381-1934)
- Towing
- Transmission Control Systems
- Common Faults On Automatic Transmissions (210-2554)
- Common Faults On Automatic Transmissions (100-2512)
- Common Faults On Automatic Transmissions (100-2500)
- Common Faults On Automatic Transmissions (381-2495)
- Change In SPS Programming (365-2466)
- Updated And New Fault Diagnosis In WIS (248-2435)
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- Common Faults On Automatic Transmissions (890-2263)
- Not Possible To Program TRIONIC T7 (248-2243)
- Common Faults On Automatic Transmissions (248-2391)
- Common Automatic Transmission Faults (440-2220)
- Common Faults On Automatic Transmissions (440-2181)
- Special Tool - Service Programming SYS. Hardware Key (101-9039)
- Special Tool - Test Cable For Trans Control Module (101-9037)
- TIS 2000 (Technical Information System) (101-9040)
- Wheels & Tire System
- Window Motors & Regulators
- Adjustment Of Door And Side Windows, CV (03-01-8113)
- Improvements For Door Windows, CV (03-01-8112)
- Soft Top Cannot Be Operated (811-2236)
- Noise From Upper Part Of Windshield (841-1577 ED. 2)
- Soft Top (Tonneau) Cover Does Not Open (811-1989)
- Air In Soft Top Hydraulic System (811-2155)
- Noise From Door Window Sliding Rollers (811-2100)
- Door Weather Seal Fits Poorly At Top Of B-Pillar (831-2109 ED. 2)
- New Lift Mechanism For Rear Side Windows (98-12-811)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)