Automatic Transmission
- 4A/T
- Precautions
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- A/T System Check
- Notes
- Step 1. Customer Complaint Analysis
- Step 2. DTC/Freeze Frame Data Check, Record and Clearance
- Step 3 and Step 4. Visual Inspection
- Step 5. Trouble Symptom Confirmation
- Step 6 and Step 7. Recheck and Record of DTC / Freeze Frame Data
- Step 8. A/T Basic Check and A/T Trouble Diagnosis
- Step 9. Troubleshooting for DTC
- Step 10. Check for Intermittent Problem
- Step 11. Final Confirmation Test
- Malfunction Indicator Lamp (MIL) Check
- "O/D OFF" Lamp Operation Check
- "POWER" Lamp Operation Check
- DTC Table
- DTC Check
- DTC Clearance
- Fail Safe Table
- Scan Tool Data
- Visual Inspection
- A/T Basic Check
- A/T Symptom Diagnosis
- Line Pressure Test
- Stall Test
- Road Test
- Manual Road Test
- Time Lag Test
- Engine Brake Test
- "P" Range Test
- No TCC Lock-Up
- No Gear Shift to O/D
- "O/D OFF" Light Does Not Light at Ignition Switch ON but Engine Starts Up
- "O/D OFF" Light Comes ON Steadily
- "POWER" Light Does Not Light at Ignition Switch ON but Engine Starts Up
- "POWER" Light Comes ON Steadily
- DTC P0705/P0707: Transmission Range Sensor Circuit Malfunction (PRNDL input)/Low
- DTC P0717: Input/Turbine Speed Sensor Circuit No Signal
- DTC P0722: Output Speed Sensor Circuit No Signal
- DTC P0741/P0742: Torque Convert Clutch (TCC) Solenoid Valve Performance or Stuck OFF/Stuck ON
- DTC P2769/P2770: TCC (Lock-Up) Solenoid Electrical
- DTC P0751/P0752/P0756/P0757: Shift Solenoid Performance or Stuck OFF/Stuck ON
- DTC P0973/P0974/P0976/P0977: Shift Solenoid Electrical
- DTC P1740: Cruise Control Signal Circuit
- DTC P1875: "4WD LOW" Switch Circuit Malfunction (If Equipped)
- Inspection of PCM and Its Circuit
- Brake Interlock System Inspection
- Shift Lock (Solenoid) Manual Release System Inspection
- A/T System Check
- Repair Instructions
- A/T Fluid Level Check
- A/T Fluid Change
- A/T Throttle Cable Adjustment
- Manual Selector Assembly Components
- Manual Selector Assembly Removal and Installation
- Manual Selector Assembly Inspection
- Select Cable Components
- Select Cable Adjustment
- Key Interlock Cable Removal and Installation
- Transmission Range Switch (Sensor) Inspection
- O/D Cut Switch Inspection
- Power / Normal Change Switch Inspection
- VSS (Speedometer) Drive Gear and Sensor Rotor Removal and Installation (for 2WD Vehicle)
- A/T (Output) Speed Sensor Inspection
- "4WD LOW" Switch Inspection
- Oil Cooler Hose and Pipes Removal and Installation
- Extension Case Oil Seal Removal and Installation (for 2WD Vehicle)
- Extension Case Removal and Installation (for 2WD Vehicle)
- Solenoid Valves (Shift Solenoid Valves and TCC Solenoid Valve) On-Vehicle Inspection
- Solenoid Valves (Shift Solenoid Valves and TCC Solenoid Valve) Removal and Installation
- Solenoid Valves (Shift Solenoid Valves and TCC Solenoid Valve) Operation Check
- Automatic Transmission (with Transfer If Equipped) Dismounting and Remounting
- Automatic Transmission Unit Disassembly
- Oil Pump Components
- Oil Pump Disassembly and Assembly
- Oil Pump Inspection
- Overdrive (Planetary Gear Side) Components
- Overdrive (Planetary Gear Side) Disassembly and Assembly
- Overdrive (Planetary Gear Side) Inspection
- Overdrive (Case Side) Components
- Overdrive (Case Side) Disassembly and Assembly
- Overdrive (Case Side) Inspection
- Forward Clutch Components
- Forward Clutch Disassembly and Assembly
- Forward Clutch Inspection
- Direct Clutch Components
- Direct Clutch Disassembly and Assembly
- Direct Clutch Inspection
- Center Support Components
- Center Support Disassembly and Assembly
- Planetary Gears and Output Shaft Components
- Planetary Gears and Output Shaft Disassembly and Assembly
- Valve Body Assembly Components
- Valve Body Assembly Disassembly and Assembly
- Front Upper Valve Body Components
- Front Upper Valve Body Disassembly and Assembly
- Rear Upper Valve Body Components
- Rear Upper Valve Body Disassembly and Assembly
- Lower Valve Body Components
- Lower Valve Body Disassembly and Assembly
- Automatic Transmission Unit Assembly
- Specifications
- Special Tools and Equipment
- 5A/T
- Precautions
- General Description
- Automatic Transmission Description
- Clutch / Brake Functions of Automatic Transmission
- Table of A/T System Component Operation
- Electronic Shift Control System Description
- Electronic Shift Control System Wiring Diagram
- Brake Interlock System Description
- A/T Diagnosis General Description
- On-Board Diagnostic System Description
- Schematic and Routing Diagram
- Components Location
- Diagnostic Information and Procedures
- A/T System Check
- Notes
- Step 1. Customer Complaint Analysis
- Step 2. DTC/Freeze Frame Data Check, Record and Clearance
- Step 3 and Step 4. Visual Inspection
- Step 5. Trouble Symptom Confirmation
- Step 6 and Step 7. Recheck and Record of DTC / Freeze Frame Data
- Step 8. A/T Basic Check and A/T Trouble Diagnosis
- Step 9. Troubleshooting for DTC
- Step 10. Check for Intermittent Problem
- Step 11. Final Confirmation Test
- Malfunction Indicator Lamp (MIL) Check
- "O/D OFF" Lamp Operation Check
- "POWER" Lamp Operation Check
- DTC Table
- DTC Check
- DTC Clearance
- Fail Safe Table
- Scan Tool Data
- Visual Inspection
- A/T Basic Check
- Road Test
- Manual Road Test
- Stall Test
- Time Lag Test
- Line Pressure Test
- Engine Brake Test
- "P" Range Test
- ATT Symptom Diagnosis
- No Gear Shift to O/D
- No Lock-Up Occurs
- "O/D OFF" Light Does Not Light at Ignition Switch ON
- "O/D OFF" Light Comes ON Steadily
- "POWER" Light Does Not Light at Ignition Switch ON
- "POWER" Light Comes ON Steadily
- DTC P0705 (No. 34): Transmission Range Sensor Circuit Malfunction
- DTC P0707 (No. 34): Transmission Range Sensor Circuit Low
- DTC P0711 (No. 81): Transmission Fluid Temperature Sensor Range/Performance
- DTC P0712 (No. 38): Transmission Fluid Temperature Sensor "A" Circuit Low
- DTC P0713 (No. 36): Transmission Fluid Temperature Sensor "A" Circuit High
- DTC P0717 (No. 14): Input/Turbine Speed Sensor Circuit No Signal
- DTC P0722 (No. 31): Output Speed Sensor Circuit No Signal
- DTC P0741/P0742 (No. 78/No. 77): TCC Circuit Performance or Stuck OFF/TCC Circuit Stuck ON
- DTC P0751/P0752 (No. 62/No. 61): Shift Solenoid-A Performance or Stuck OFF/Shift Solenoid-A Stuck ON
- DTC P0756/P0757 (No. 65/No. 63): Shift Solenoid-B Performance or Stuck OFF/Shift Solenoid-B Stuck ON
- DTC P0771/P0772 (No. 67/No. 66): Shift Solenoid-E Performance or Stuck OFF/Shift Solenoid-E Stuck ON
- DTC P0781 (No. 68): 1-2 Shift
- DTC P0797 (No. 79): Pressure Control Solenoid "C" Stuck ON
- DTC P0962/P0966/P0970 (No. 41/No. 43/No. 45): Pressure Control Solenoid "A-C" Control Circuit Low
- DTC P0963/P0967/P0971 (No. 42 / No. 44 / No. 46): Pressure Control Solenoid "A-C" Control Circuit High
- DTC P0973/P0976/P0985 (No. 22 / No. 24 / No. 49): Shift Solenoid "A" Control Circuit Low/Shift Solenoid "B" Control Circuit Low/Shift Solenoid "E" Control Circuit Low
- DTC P0974/P0977/P0986 (No. 21 / No. 23 / No. 48): Shift Solenoid "A" Control Circuit High/Shift Solenoid "B" Control Circuit High/Shift Solenoid "E" Control Circuit High
- DTC P1701 (No. 76): CAN Communication Problem - TCM
- DTC P1702 (No. 83): Internal Control Module Memory Check Sum Error
- DTC P1703 (No. 86): CAN Invalid Data - TCM
- DTC P1740 (No. 75): Cruise Control Signal Malfunction
- DTC P1874 (No. 15): 4WD Low Switch Circuit Malfunction (Short)
- DTC P1875 (No. 15): 4WD Low Switch Circuit Malfunction (Open)
- DTC P2742 (No. 59): Transmission Fluid Temperature Sensor "B" Circuit Low
- DTC P2743 (No. 58): Transmission Fluid Temperature Sensor "B" Circuit High
- DTC P2763 (No. 26): Torque Converter Clutch (TCC) Circuit High
- DTC P2764 (No. 25): Torque Converter Clutch (TCC) Circuit Low
- Inspection of TCM and Its Circuits
- Brake Interlock System Inspection
- Shift Lock (Solenoid) Manual Release System Inspection
- A/T System Check
- Repair Instructions
- Learning Control Initialization
- A/T Fluid Level Check
- A/T Fluid Change
- Oil Cooler Hoses Replacement
- Manual Selector Assembly Components
- Manual Selector Assembly Removal and Installation
- Manual Selector Assembly Inspection
- Select Cable Component
- Select Cable Adjustment
- Transmission Range Sensor Removal and Installation
- Transmission Range Sensor Inspection and Adjustment
- O/D OFF Switch Inspection
- Power / Normal Change Switch Inspection
- Input Shaft Speed Sensor Removal and Installation
- Input Shaft Speed Sensor Inspection
- Output Shaft Speed Sensor Removal and Installation
- Output Shaft Speed Sensor Inspection
- Solenoid Valves (Shift Solenoid-A, Shift Solenoid-B, Shift Solenoid-E, TCC Solenoid, Pressure Control Solenoid-A, Pressure Control Solenoid-B, and Pressure Control Solenoid-C) Removal and Installation
- Solenoid Valves (Shift Solenoid-A, Shift Solenoid-B, Shift Solenoid-E, TCC Solenoid, Pressure Control Solenoid-A, Pressure Control Solenoid-B, and Pressure Control Solenoid-C) Inspection
- Transmission Fluid Temperature Sensor A and B Removal and Installation
- Transmission Fluid Temperature Sensor A and B Inspection
- Transmission Control Module (TCM) Removal and Installation
- 4WD LOW Switch Inspection
- Oil Cooler Pipes Removal and Installation
- Automatic Transmission Assembly (with Transfer) Dismounting and Remounting
- Automatic Transmission Unit Components
- Automatic Transmission Unit Disassembly
- Oil Pump Assembly Components
- Oil Pump Disassembly and Assembly
- Oil Pump Inspection
- Clutch Drum & Input Shaft Assembly Components
- Clutch Drum & Input Shaft Assembly Disassembly
- Clutch Drum & Input Shaft Assembly Reassembly
- Clutch Drum & Input Shaft Assembly Inspection
- Valve Body Assembly Components
- Automatic Transmission Unit Assembly
- Automatic Transmission Unit Assembly Inspection
- Specifications
- Special Tools and Equipment