Section 3849 (Steering And Wheel Alignment - Repair)
WARNING: This page does not describe the selected car, but rather 21 other vehicles, including the 2017 BMW 550i GT xDrive, 2017 BMW 535i GT xDrive, 2017 BMW 535i GT, 2016 BMW 550i GT xDrive, and 2016 BMW 535i GT xDrive. However, it is still accessible from the selected car via links, so may be relevant.
- Safety Information
- 00 Danger of poisoning if oil is ingested/absorbed through the skin
- 00 Risk of injury if oil comes into contact with eyes and skin
- 00 Safety information for working on vehicles with automatic engine start-stop function (MSA)
- 00 Safety instructions for handling oil
- 72 00... Safety regulations for handling components with gas generators
- 72 12... Procedure after airbag deployment as result of an accident
- Electronic Chassis Alignment
- 32 00... Additional work for camber correction
- 32 00 620 Adjusting rear axle
- 32 00 601 Adjusting toe-in on front axle
- 61 31 996 Carrying out steering angle sensor adjustment
- 31 00... Front axle + steering: wheel/chassis alignment check must be carried out after the following work
- 32 00... General chassis and suspension definitions
- 32 00... General information and definitions
- 32 00... Identification of suspension without label
- 32 00 150 KDS chassis/wheel alignment check with vehicle load up to design position
- 32 00... KDS data statuses
- 32 00 155 KDS wheel alignment check with ride height measurement without vehicle load
- 31 33... Measuring vehicle ride height
- 32 00... Moving vehicle into design position
- 32 00... Moving vehicle into normal position
- 32 00... Notes on steering gear/steering column replacement following accident damage
- 32.... Overview of active steering
- 32..... Overview of steering
- 32.... Overview of steering (interior)
- 33 00... Rear axle: wheel/chassis alignment check must be carried out after the following work
- 34 52.. Start-up of ICM control unit
- 32 00... Test conditions for chassis/wheel alignment check
- Mechanical Steering Gear
- Steering Gear With Servo Unit
- 32 13 006 Bleeding power steering unit
- 32 13 006 Bleeding power steering (version with Dynamic Drive)
- 32 13 070 Removing and installing electric steering box (EPS)
- 32 13 071 Replace electrical steering box (EPS)
- 32 13 075 Removing and installing electrical steering box, vehicles with active steering (RWD vehicles)
- 32 13 060 Removing and installing hydraulic steering gear (RWD vehicles)
- 32 13 060 Removing and installing hydraulic steering gear (AWD vehicles)
- 32 13 065 Removing and installing hydraulic steering gear (with active front steering)
- 32 13 066 Replacing hydraulic steering gear (with active front steering)
- 32 13 650 Removing and installing/replacing EH converter for Servotronic (RWD vehicles)
- 32 13 650 Removing and installing/replacing EH converter for Servotronic (AWD vehicles)
- 32 13 076 Replacing electrical steering box active steering
- 32 13 061 Replacing hydraulic steering gear (RWD vehicles)
- 32 13 061 Replacing hydraulic steering gear (AWD vehicles)
- Steering Arms, Tie Rods, Steering Damper
- Steering Column
- 32 31... Electrical steering column adjustment normalization
- 32 31 102 Replacing steering shaft sleeve (RWD vehicles)
- 32 31 102 Replacing sleeve for steering shaft (AWD vehicles)
- 32 31 070 Removing and installing/replacing lower section of steering shaft (RWD vehicles)
- 32 31 003 Removing and installing/replacing upper section of steering column trim
- 32 31 020 Removing and installing/replacing lower section of steering column trim
- 32 31 082 Removing and installing/replacing steering angle sensor
- 32 31 090 Removing and installing/replacing steering column
- 32 31 211 Removing and installing/replacing universal joint with corrugated tubing (N55)
- 32 31 211 Removing and installing/replacing universal joint with corrugated tubing (N63)
- 32 31 102 Replacing bottom steering shaft (AWD vehicles)
- Steering Wheel
- 32 33 010 Removing and installing/replacing sport steering wheel (Version 1)
- 32 33 010 Removing and installing/replacing sport steering wheel (Version 2)
- 32 33 000 Removing and installing/replacing steering wheel
- 32 33 016 Replacing design cover for sport steering wheel (Version 1)
- 32 33... Replacing design cover for sport steering wheel (Version 2)
- 32 33... Replacing steering wheel design cover
- Steering Wheel For Airbag
- 72 00... Safety regulations for handling components with gas generators
- 72 12... Procedure after airbag deployment as result of an accident
- 32 34 020 Removing and installing/replacing airbag unit
- 32 34 030 Removing and installing/replacing airbag unit (sport steering wheel) (Version 1)
- 32 34 030 Removing and installing/replacing airbag unit (sport steering wheel) (Version 2)
- Pump And Oil Supply
- 32 41... Notes on hydraulic line with quick-connect coupling
- 32 41... Instructions for removing and installing ear clips
- 32 41 033 Removing and installing/replacing power steering pump for hydraulic steering box with active steering (N55)
- 32 41 037 Removing and installing/replacing power steering pump for hydraulic steering gear with Dynamic Drive (N55)
- 32 41 037 Removing and installing/replacing power steering pump for hydraulic steering gear with Dynamic Drive (N63)
- 32 41 060 Removing and installing (replacing) vane pump for hydraulic steering gear (N55)
- 32 41 060 Removing and installing vane pump for power steering unit (RWD with N63 engine)
- 32 41 060 Removing and refitting (replacing) vane pump for hydraulic steering gear (AWD with N63 engine)
- 32 41 090 Removing and installing (replacing) hydraulic pump for Dynamic Drive (N55)
- 32 41 090 Removing and installing (replacing) hydraulic pump for Dynamic Drive (N63)
- 32 41 100 Removing and installing/replacing belt pulley for hydraulic pump (N55)
- 32 41 105 Removing and installing/replacing belt pulley for hydraulic pump (N63)
- 32 41 280 Removing and installing/replacing oil reservoir (RWD with N55 engine)
- 32 41 280 Removing and installing/replacing oil reservoir (RWD with N63 engine)
- 32 41 250 Removing and installing/replacing fluid reservoir for hydraulic steering (AWD with N55 engine)
- 32 41 250 Removing and installing/replacing oil reservoir for hydraulic steering (AWD with N63 engine)
- 32 41 311 Replacing intake pipe for hydraulic steering (N55)
- 32 41 314 Replacing suction line for power steering, from fluid reservoir to connecting piece (RWD with N63 engine)
- 32 41 314 Replace intake pipe for hydraulic steering, from the oil reservoir to the connecting piece (AWD with N63 engine)
- 32 41 315 Replacing suction line for power steering, from connecting piece to vane pump (RWD with N63 engine)
- 32 41 315 Replace intake pipe for hydraulic steering, from the connecting piece to the vane pump (AWD with N63 engine)
- 32 41 316 Intake pipe to hydraulic pump, from oil reservoir to connecting piece (AWD with N63 engine)
- 32 41 317 Replace intake pipe for hydraulic pump, from connecting piece to hydraulic pump (N63)
- 32 41 431 Removing and installing/replacing ARS expandable hose part 2, in front wheel arch (RWD vehicles)
- 32 41 431 Removing and installing/renewing Dynamic Drive expandable hose part 2, in front wheel arch (AWD vehicles)
- 32 41 431 Removing and installing/renewing Dynamic Drive expansion hose part 2, in front wheel arch (RWD with N55 engine)
- 32 41 431 Removing and installing/renewing Dynamic Drive expandable hose part 2, in front wheel arch (RWD with N63 engine)
- 32 41 431 Removing and installing/replacing ARS expansion hose part 2 (AWD with N63 engine)
- 32 41 432 Removing and installing/replacing ARS expansion hose part 3 (RWD with N63 engine)
- 32 41 433 Removing and installing/replacing ARS expansion hose part 4 (RWD with N63 engine)
- 32 41 435 Removing and installing/replacing ARS return line in wheel arch (RWD vehicles)
- 32 41 435 Removing and installing/replacing ARS return line in wheel arch (AWD vehicles)
- 32 41 437 Removing and installing/replacing Dynamic Drive return from separation point to cooling loop (RWD vehicles)
- 32 41 436 Removing and installing/replacing return line for power steering with ARS (RWD with N55 engine)
- 32 41 436 Removing and installing/replacing return line for power steering with ARS (RWD with N63 engine)
- 32 41 436 Removing and installing/replacing return line for hydraulic steering with ARS (AWD with N55 engine)
- 32 41 436 Removing and installing/replacing return line for hydraulic steering with ARS (AWD with N63 engine)
- 32 41 430 Replacing ARS expandable hose part 1, from vane pump to expandable hose (RWD with N55 engine)
- 32 41 430 Replacing ARS expandable hose section 1, from hydraulic pump to expandable hose (RWD with N55 engine)
- 32 41 430 Replacing ARS expansion hose part 1, from vane pump to expansion hose (RWD with N55 engine)
- 32 41 430 Replacing ARS expandable hose part 1, from vane pump to expandable hose (AWD with N55 engine)
- 32 41 430 Replacing ARS expandable hose part 1, from vane pump to expandable hose (RWD with N63 engine)
- 32 41 430 Replacing ARS expandable hose section 1, from hydraulic pump to expandable hose (RWD with N63 engine)
- 32 41 430 Replacing ARS expansion hose part 1, from vane pump to expansion hose (RWD with N63 engine)
- 32 41 430 Replacing ARS expandable hose part 1, from vane pump to expandable hose (AWD with N63 engine)
- 32 41 341 Replacing cooler return line for power steering, from cooler to fluid reservoir (N55)
- 32 41 341 Replace radiator return hose for hydraulic steering, from radiator to the oil reservoir (RWD with N63 engine)
- 32 41 341 Replacing radiator return hose for hydraulic steering, from cooler to oil container (AWD with N63 engine)
- 32 41 420 Replacing expansion hose part 1 (with ARS), from vane pump
- 32 41 421 Replacing expansion hose part 2 (with ARS), from T-piece to power steering gear (RWD with N63 engine)
- 32 41 421 Replacing expansion hose part 2 (with ARS), to the hydraulic steering gear (AWD with N63 engine)
- 32 41 285 Replacing level switch for Dynamic Drive fluid reservoir
- 32 41 285 Replacing the oil level sensor for oil reservoir (AWD with N63 engine)
- 32 41 333 Replacing pressure line for hydraulic steering, from junction to vane pump (RWD with N55 engine)
- 32 41 333 Replacing pressure line for hydraulic steering, from junction to vane pump (AWD with N55 engine)
- 32 41 333 Replacing pressure line for hydraulic steering, from junction to vane pump (N63)
- 32 41 331 Replacing pressure line for power steering, from steering gear to junction (RWD with N55 engine)
- 32 41 331 Replacing pressure line for power steering, from steering gear to junction (AWD with N55 engine)
- 32 41 331 Replacing pressure line for power steering, from steering gear to junction (N63)
- 32 41 351 Replacing return line for hydraulic steering, from cooler to steering gear (N55)
- 32 41 351 Replacing return line for hydraulic steering, from cooler to steering gear (N63)
- 32 41 440 Replacing suction line from oil reservoir to hydraulic pump (RWD with N55 engine)
- 32 41 445 Replacing the radiator return hose, from radiator to oil reservoir (RWD with N63 engine)
- Electronic Power Steering