Section 1969 (Steering And Wheel Alignment - Repair)
WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2010 BMW 535xi, 2010 BMW 528xi, 2009 BMW 535xi, 2009 BMW 528xi, and 2008 BMW 535xi. However, it is still accessible from the selected car via links, so may be relevant.
- 00 Electronic Chassis Alignment
- 00 Danger of poisoning if oil is ingested/absorbed through the skin
- 00 Risk of injury if oil comes into contact with eyes and skin
- 00 Safety instructions for handling oil
- 00... ... Raising vehicle with trolley jack
- 31 00 ... Front axle + steering (AWD): wheel/chassis alignment check must be carried out after the following work
- 31 00 ... Instructions (damage to suspension)
- 32 .... Overview of steering (AWD)
- 32 .... Overview of steering wheel / casing components / lock cylinder
- 32 00 ... Chassis/wheel alignment check procedure
- 32 00 ... General chassis and suspension definitions
- 32 00 ... General information and definitions
- 32 00 ... Identification of suspension without label
- 32 00 ... Identifying suspension from label on front axle
- 32 00 ... Information on replacing steering gear after accident damage
- 32 00 ... Moving vehicle into design position
- 32 00 ... Moving vehicle into normal position
- 32 00 ... Performing rim runout compensation
- 32 00 ... Test conditions for chassis/wheel alignment check
- 32 00 ... Troubleshooting after wheel/chassis alignment check on front axle
- 32 00 ... Troubleshooting after wheel/chassis alignment check on rear axle
- 32 00 150 KDS chassis/wheel alignment check with load up to design position
- 32 00 155 KDS chassis/wheel alignment check with ride-height measurement without load
- 32 00 610 Adjusting toe-in and camber on front axle (AWD)
- 32 00 620 Adjusting rear axle
- 11 Mechanical Steering Gear
- 13 Steering Gear With Servo Unit
- 21 Steering Arms, Tie Rods, Steering Damper
- 31 Steering Column
- 32 31 004 Removing and installing / replacing upper section of steering column trim
- 32 31 010 Removing and installing/replacing front section of steering column cover
- 32 31 020 Removing and installing / replacing lower section of steering column trim
- 32 31 070 Removing and installing / replacing steering spindle lower section (AWD)
- 32 31 082 Removing and installing/replacing steering angle sensor
- 32 31 087 Removing and installing/replacing steering column lock
- 32 31 090 Removing and installing/replacing steering column
- 32 31 102 Replacing sleeve for steering spindle (4WD)
- 32 31 102 Replacing steering spindle sleeve
- 32 31 241 Replacing adjusting lever for steering column (steering column with Nacam clamp)
- 33 Steering Wheel
- 32 33 ... Replacing decorative strip for sport steering wheel
- 32 33 ... Replacing decorative strips for steering wheel (up to 03/2007)
- 32 33 001 Removing and installing (replacing) steering wheel (up to 03/2007)
- 32 33 001 Removing and installing/replacing steering wheel (from 03/2007)
- 32 33 010 Removing and installing/replacing sport steering wheel
- 34 Steering Wheel For Airbag
- 41 Pump And Oil Supply
- 32 41 ... Instructions for removing and installing ear clips
- 32 41 ... Instructions for using special tool 32 4 000
- 32 41 ... Notes on hydraulic line with quick-connect coupling
- 32 41 001 Servotronic troubleshooting
- 32 41 009 Checking function of power steering vane pump
- 32 41 060 Removing and installing/replacing vane pump for power steering (N54)
- 32 41 037 Removing and installing power steering pump for power steering gear with Dynamic Drive (N52, N53)
- 32 41 060 Removing and installing (replacing) power steering vane pump (N52, N53)
- 32 41 311 Replacing suction line for power steering (N52, N53)
- 32 41 332 Replacing pressure line for power steering (N52, N53)
- 32 41 351 Replacing return line for power steering (N52, N53)
- 32 41 061 Replacing power steering vane pump
- 32 41 100 Removing and installing/replacing belt pulley on vane pump for power steering
- 32 41 250 Removing and installing/replacing fluid reservoir for power steering
- 32 41 311 Replacing suction line for power steering (N54 AWD)
- 32 41 332 Replacing pressure line for power steering (N54 AWD)
- 32 41 341 Replacing cooler return line for power steering
- 32 41 351 Replacing return line for power steering (N54 AWD)
- 90 Troubleshooting