Section 6 (Fuel, Ignition & Engine Control Systems - Removal, Installation & Specifications)
WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2007 Volvo V70, 2006 Volvo V70, 2005 Volvo V70, 2004 Volvo V70, and 2003 Volvo V70. However, it is still accessible from the selected car via links, so may be relevant.
- Ignition and control systems
- Accelerator pedal (AP), replacing
- Adapter wiring switch, replacing
- Air leakage in the intake system, checking
- Air leaks in the intake system, checking
- Camshaft position sensor (CMP), replacing
- Camshaft seal / variable valve timing (VVT) unit, replacing (B6xx4T -1999)
- Camshaft seal/variable valve timing (VVT) unit, replacing (B5244T5; B5254T2; B5254T4; 2005-2007)
- Camshaft seal/variable valve timing (VVT) unit, replacing (B5244S; B5244S6; 2005-2007)
- Camshaft seal/variable valve timing (VVT) unit, replacing (B6xx4S; -1999; B5234T3; B5244T3; 2001)
- CAN network
- Carbon filter container, replacing (B5234T3; 2002-2004; B5244T5; B5254T2; B5254T4; 2005-2007)
- Checking engine control module (ECM) power supply and ground terminal
- Checking for air leakage in the exhaust system (B5244T5; B5254T2; B5254T4; 2005-2006)
- Checking fuel and residual pressures
- Checking fuel pressure and residual pressure in the workshop
- Component specifications (5 cylinder turbocharged engines -2002)
- Bosch ME 7 engine control module (ECM)
- Throttle unit
- Accelerator pedal (AP) position sensor
- Pressure regulator
- The mass air flow (MAF) sensor
- Fuel pump
- Injector
- Boost pressure sensor
- Turbocharger (TC) control valve
- Camshaft reset valve
- Intake air temperature (IAT) sensor
- Engine coolant temperature (ECT) sensor
- Knock sensor (KS)
- Camshaft position (CMP) sensor
- Engine speed (RPM) sensor
- Front heated oxygen sensor (HO2S)
- Preheating, front heated oxygen sensor (HO2S)
- Rear heated oxygen sensor (HO2S)
- Preheating, rear heated oxygen sensor (HO2S)
- Ignition coil
- Spark plugs
- Outside temperature sensor
- A/C pressure sensor
- Air conditioning (A/C) pressure switch (Pressostat)
- Canister purge (CP) valve
- EVAP canister shut-off valve
- Fuel tank pressure sensor
- Fuel pump (FP) relay
- Air conditioning (A/C) relay
- Engine cooling fan (FC) relay
- System relay (1)
- Clutch pedal sensor
- Brake pedal sensor
- Stop (brake) lamp switch
- Engine coolant level switch
- Oil pressure switch
- Component specifications (B5234T3; B5244T3; B5244T5; B5254T2; B5254T4; 2001-2007)
- Compression test
- Construction of the network
- Control modules in the Control area network (CAN)
- Crankcase ventilation and electronic throttle module (ETM), cleaning
- Checking spark plugs
- Description of diagnostic trouble code (DTC) status
- Description of frozen values Me7
- Description of parameters, quick test of the fuel tank system
- Draining fuel injection system
- Draining the fuel tank AWD and 2WD/ORVR
- Draining/vacuum pumping/filling with coolant and leak-finding
- Engine control module (ECM), replacing
- Engine coolant temperature (ECT) sensor, replacing (B5234T3; 2001-2004)
- Engine coolant temperature (ECT) sensor, replacing (B5244S; 2001-2007)
- Engine cooling fan (FC), replacing
- Engine speed (RPM) sensor, replacing (B5244T5; B5254T2; B5254T4; 2003-2007)
- Engine temperature sensor, replacing
- Error management in the Controller area network (CAN)
- Frozen values DENSO, description
- Diagnostic Trouble Code (DTC)
- Read off fault type
- Previous fault type
- Time before the data was frozen
- Time after engine start
- Outside temperature
- Atmospheric pressure
- Vehicle speed
- Engine speed
- Mass air flow g/stroke
- Intake pressure
- Engine coolant temperature (ECT)
- Lambda compensation
- Long term fuel trim
- Accelerator pedal (AP) affected
- Probe control
- Fuel shut-off system
- Operating cycle
- Warm-up cycle
- Gear selected
- Engine cooling fan (FC)
- A/C requested
- Air conditioning (A/C) compressor active
- Brake pedal switch
- EVAP canister purge valve active
- Cruise control active
- EVAP canister shut-off valve
- State, fuel trim
- Battery voltage
- Passenger compartment temperature
- Odometer setting
- Frozen values dependent on diagnostic trouble codes (DTCs)
- Fuel pressure gauge
- Fuel pressure sensor