LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2009 >> FJ Cruiser 4WD, Part Time >> Repair and Diagnosis >> Body & Frame >> Door Locks >> Engine Immobilizer >> Transponder Key Ecu >> Installation

Transponder Key Ecu: Installation

  1. INSTALL TRANSPONDER KEY ECU 
    1. Install the transponder key ECU with the nut.

      Torque: 5.5 N*m (56 kgf*cm, 49 in.*lbf) 

      Fig 1: Identifying Transponder Key ECU Nut
      G05580404Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Connect the connector.
  2. INSTALL TRANSPONDER KEY BRACKET (w/ Bracket) 
    1. Install the transponder key bracket with the 2 nut.

      Torque: 5.5 N*m (56 kgf*cm, 49 in.*lbf) 

      Fig 2: Identifying Transponder Key Bracket Nuts And Clips
      G05580403Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Install the 2 clips.
  3. INSTALL INSTRUMENT PANEL SUB-ASSEMBLY  (See INSTALLATION )
  4. CONNECT PASSENGER AIRBAG CONNECTOR  (See INSTALLATION )
  5. REMOVE INSTRUMENT PANEL FINISH PANEL END LH  (See INSTALLATION )
  6. INSTALL ASSIST GRIP RETAINER RH  (See INSTALLATION )
  7. INSTALL ASSIST GRIP RETAINER LH  (See INSTALLATION )
  8. INSTALL FRONT NO. 2 SPEAKER ASSEMBLY  (See INSTALLATION )
  9. INSTALL NO. 2 INSTRUMENT PANEL SPEAKER PANEL SUB-ASSEMBLY  (See INSTALLATION )
  10. INSTALL NO. 1 INSTRUMENT PANEL SPEAKER PANEL SUB-ASSEMBLY  (See INSTALLATION )
  11. INSTALL NO. 2 INSTRUMENT PANEL REGISTER ASSEMBLY  (See INSTALLATION )
  12. INSTALL INSTRUMENT PANEL LOWER FINISH PANEL SUB-ASSEMBLY RH  (See INSTALLATION )
  13. INSTALL GLOVE COMPARTMENT DOOR ASSEMBLY  (See INSTALLATION )
  14. INSTALL COMBINATION METER ASSEMBLY  (See INSTALLATION )
  15. INSTALL INSTRUMENT CLUSTER LOWER FINISH PANEL  (See INSTALLATION )
  16. INSTALL LOWER INSTRUMENT PANEL LH  (See INSTALLATION )
  17. INSTALL LOWER INSTRUMENT PANEL FINISH PANEL SUB-ASSEMBLY LH  (See INSTALLATION )
  18. INSTALL INSTRUMENT PANEL FINISH PLATE  (See INSTALLATION  )
  19. CONNECT HOOD LOCK CONTROL LEVER SUBASSEMBLY  (See INSTALLATION )
  20. INSTALL NO. 1 INSTRUMENT PANEL REGISTER ASSEMBLY  (See INSTALLATION )
  21. INSTALL INSTRUMENT LOWER COVER SUBASSEMBLY  (See INSTALLATION )
  22. INSTALL CONSOLE UPPER PANEL NO. 1 GARNISH  (See INSTALLATION )
  23. INSTALL FRONT CONSOLE BOX ASSEMBLY  (See INSTALLATION )
  24. INSTALL BOX BOTTOM MAT  (See INSTALLATION )
  25. INSTALL CONSOLE UPPER REAR PANEL SUBASSEMBLY  (See INSTALLATION )
  26. INSTALL SHIFT LEVER KNOB SUB-ASSEMBLY (for 4WD)  (See INSTALLATION )
  27. INSTALL SHIFT LEVER KNOB SUB-ASSEMBLY (for Manual Transmission)  (See INSTALLATION )
  28. INSTALL PARKING BRAKE HOLE COVER SUBASSEMBLY  (See INSTALLATION )
  29. INSTALL RADIO RECEIVER ASSEMBLY  (See INSTALLATION )
  30. INSTALL INTEGRATION CONTROL AND PANEL ASSEMBLY  (See INSTALLATION )
  31. INSTALL INSTRUMENT PANEL GARNISH LH  (See INSTALLATION )
  32. INSTALL INSTRUMENT PANEL GARNISH RH  (See INSTALLATION )
  33. INSTALL FRONT PILLAR GARNISH RH  (See INSTALLATION )
  34. INSTALL FRONT PILLAR GARNISH LH  (See INSTALLATION )
  35. INSTALL ASSIST GRIP ASSEMBLY  (See INSTALLATION )
  36. INSTALL ASSIST GRIP PLUG  (See INSTALLATION )
  37. INSTALL FRONT DOOR OPENING TRIM WEATHERSTRIP LH  (See INSTALLATION )
  38. INSTALL FRONT DOOR OPENING TRIM WEATHERSTRIP RH  (See INSTALLATION )
  39. INSTALL COWL SIDE TRIM BOARD RH  (See INSTALLATION )
  40. INSTALL COWL SIDE TRIM BOARD LH  (See INSTALLATION )
  41. INSTALL FOOTREST CLIP  (See INSTALLATION )
  42. INSTALL FRONT FLOOR FOOTREST  (See INSTALLATION )
  43. INSTALL FRONT DOOR SCUFF PLATE RH  (See INSTALLATION )
  44. INSTALL FRONT DOOR SCUFF PLATE LH  (See INSTALLATION )
  45. CONNECT CABLE TO NEGATIVE BATTERY TERMINAL 

    Torque: 3.9 N*m (40 kgf*cm, 35 in.*lbf) 

  46. INSPECT SRS WARNING LIGHT 

    (See DIAGNOSIS SYSTEM )

scientia non olet · About LEMON Manuals