LEMON Manuals: Even more car manuals for everyone
Home >> Mazda >> 2017 >> 5 GS, Automatic Trans >> Repair and Diagnosis >> Body & Frame >> Sun Roof/T-Top/Convertible Top >> Sunroof System >> Front Drain Hose Installation

Front Drain Hose Installation

CAUTION:
  • If the front drain hose is pinched or bent at any point, the water in the hose may not drain and could leak inside the vehicle. During and after installation of the trims and headliner, always make sure there is no interference with the front drain hose. Correct any abnormality if found.
  1. Apply soapy water to the part of the sunroof frame where the front drain hose is inserted.
  2. Insert the front drain hose end into the sunroof frame.
  3. Install the front drain hose to the clips parallel to the pillar and free of looseness.
  4. Insert the front drain hose grommet into the hole of the inner hinge pillar.
  5. Install the following parts:
    1. Dashboard (See DASHBOARD REMOVAL/INSTALLATION .)
    2. Rear heat duct (See REAR HEAT DUCT REMOVAL/INSTALLATION .)
    3. Front heat duct (See FRONT HEAT DUCT REMOVAL/INSTALLATION .)
    4. Steering shaft (See STEERING WHEEL AND COLUMN REMOVAL/INSTALLATION .)
    5. Joint cover (See STEERING WHEEL AND COLUMN REMOVAL/INSTALLATION .)
    6. Heater case (See A/C UNIT REMOVAL/INSTALLATION .)
    7. Audio unit (See AUDIO UNIT REMOVAL/INSTALLATION .)
    8. Climate control unit (See CLIMATE CONTROL UNIT REMOVAL/INSTALLATION [FULL-AUTO AIR CONDITIONER] .)
    9. Information display (See INFORMATION DISPLAY REMOVAL/INSTALLATION .)
    10. Switch panel (See SWITCH PANEL REMOVAL/INSTALLATION .)
    11. Instrument cluster (See INSTRUMENT CLUSTER REMOVAL/INSTALLATION .)
    12. Combination switch (See COMBINATION SWITCH REMOVAL/INSTALLATION .)
    13. Column cover (See COLUMN COVER REMOVAL/INSTALLATION .)
    14. Steering wheel (See STEERING WHEEL AND COLUMN REMOVAL/INSTALLATION .)
    15. Driver-side air bag module (See DRIVER-SIDE AIR BAG MODULE REMOVAL/INSTALLATION [TWO-STEP DEPLOYMENT CONTROL SYSTEM] .)
    16. Driver-side lower panel (See LOWER PANEL REMOVAL/INSTALLATION .)
    17. Hood release lever (See HOOD REMOVAL/INSTALLATION .)
    18. Passenger-side lower panel (See LOWER PANEL REMOVAL/INSTALLATION .)
    19. Dashboard under cover (See DASHBOARD UNDER COVER REMOVAL/INSTALLATION .)
    20. Glove compartment (See GLOVE COMPARTMENT REMOVAL/INSTALLATION .)
    21. Side panel (See SIDE PANEL REMOVAL/INSTALLATION .)
    22. Selector lever component (ATX) (See AUTOMATIC TRANSAXLE SHIFT MECHANISM REMOVAL/INSTALLATION .)
    23. Shift lever component (MTX) (See MANUAL TRANSAXLE SHIFT MECHANISM REMOVAL/INSTALLATION .)
    24. Front console (See FRONT CONSOLE REMOVAL/INSTALLATION .)
    25. Side wall (See SIDE WALL REMOVAL/INSTALLATION .)
    26. Shift panel (See SHIFT PANEL REMOVAL/INSTALLATION .)
    27. Selector lever knob (ATX) (See AUTOMATIC TRANSAXLE SHIFT MECHANISM REMOVAL/INSTALLATION .)
    28. Shift lever knob (MTX) (See MANUAL TRANSAXLE SHIFT MECHANISM REMOVAL/INSTALLATION .)
    29. Center console (See CENTER CONSOLE REMOVAL/INSTALLATION .)
    30. Console panel (See CENTER CONSOLE REMOVAL/INSTALLATION .)
    31. Center console box (See CENTER CONSOLE BOX REMOVAL/INSTALLATION .)
    32. Front side trim (See FRONT SIDE TRIM REMOVAL/INSTALLATION .)
    33. Front scuff plate (See FRONT SCUFF PLATE REMOVAL/INSTALLATION .)
    34. Sail garnish (See SAIL GARNISH REMOVAL/INSTALLATION .)
    35. Front door (See FRONT DOOR REMOVAL/INSTALLATION .)
    36. Windshield wiper motor (See WINDSHIELD WIPER MOTOR REMOVAL/INSTALLATION .)
    37. Cowl panel (See COWL PANEL REMOVAL/INSTALLATION .)
    38. Center cowl grille (See CENTER COWL GRILLE REMOVAL/INSTALLATION .)
    39. Cowl grille (See COWL GRILLE REMOVAL/INSTALLATION .)
    40. Front fender molding (See COWL GRILLE REMOVAL/INSTALLATION .)
    41. Windshield wiper arm and blade (See WINDSHIELD WIPER ARM AND BLADE REMOVAL/INSTALLATION .)
    42. Headliner (See HEADLINER REMOVAL/INSTALLATION .)
    43. C-pillar trim (See C-PILLAR TRIM REMOVAL/INSTALLATION .)
    44. Rear header trim (See REAR HEADER TRIM REMOVAL/INSTALLATION .)
    45. Second-row seat belt upper anchor installation bolt (See SECOND-ROW SEAT BELT REMOVAL/INSTALLATION .)
    46. Trunk side trim (See TRUNK SIDE TRIM REMOVAL/INSTALLATION .)
    47. Cargo compartment light (See CARGO COMPARTMENT LIGHT REMOVAL/INSTALLATION .)
    48. Third-row seat belt lower anchor installation bolt (See THIRD-ROW SEAT BELT REMOVAL/INSTALLATION .)
    49. Third-row seat (See THIRD-ROW SEAT REMOVAL/INSTALLATION .)
    50. Trunk end trim (See TRUNK END TRIM REMOVAL/INSTALLATION .)
    51. Sub-trunk (See SUB-TRUNK REMOVAL/INSTALLATION .)
    52. B-pillar upper trim (See B-PILLAR UPPER TRIM REMOVAL/INSTALLATION .)
    53. Upper anchor of the front seat belt (See FRONT SEAT BELT REMOVAL/INSTALLATION .)
    54. Adjuster anchor cover (See FRONT SEAT BELT REMOVAL/INSTALLATION .)
    55. B-pillar lower trim (See B-PILLAR LOWER TRIM REMOVAL/INSTALLATION .)
    56. Rear scuff plate (See REAR SCUFF PLATE REMOVAL/INSTALLATION .)
    57. Front scuff plate (See FRONT SCUFF PLATE REMOVAL/INSTALLATION .)
    58. Assist handle (See ASSIST HANDLE REMOVAL/INSTALLATION .)
    59. Map light (See MAP LIGHT REMOVAL/INSTALLATION .)
    60. Sunvisor (See SUNVISOR REMOVAL/INSTALLATION .)
    61. A-pillar trim (See A-PILLAR TRIM REMOVAL/INSTALLATION .)
  6. Connect the negative battery cable.
scientia non olet · About LEMON Manuals