Automatic Transmission Diagnostic Procedures

• Introduction
  • Notes
  • System Coverage
  • Six-Step Troubleshooting Procedure
• Identification Of System
• System Description And Functional Operation
  • General Description
  • Functional Operation
    • Notes
    • AUTOSTICK Feature (If Applicable)
    • Transmission Operation And Shift Scheduling At Various Oil Temperatures
  • Diagnostic Trouble Codes
    • Notes
    • Hard Code
    • One Trip Failures
    • Intermittent Code
    • Starts Since Set Counter
    • Trouble Code Erasure
    • EATX DTC Event Data
    • List Of Diagnostic Trouble Codes (Detailed Descriptions Follow List)
    • DTC Descriptions
      • Notes
      • When Monitored:
      • Set Condition:
      • Schematic
      • Theory Of Operation
      • Pressure Switch States
        • Notes
        • When Monitored:
        • Set Condition:
        • Set Conditions
      • Shift Lever Error Codes Reported By The DRBIII®
        • Notes
        • When Monitored:
        • Set Condition:
      • Solenoid Application Chart
        • Notes
        • When Monitored:
        • Set Condition:
        • Theory Of Operation
    • Quick Learn
    • Clutch Volumes
    • Electronic Pinion Factor (If Applicable)
  • Using The DRBIII®
  • DRBIII® Error Messages
    • Notes
    • DRBIII® Does Not Power Up (Blank Screen)
    • Display Is Not Visible
  • Transmission Simulator (Miller Tool # 8333) And Electronic Transmission Adapter Kit (Miller Tool #8333-1A)
• Disclaimers, Safety, And Warnings
  • Disclaimers
  • Safety
    • Technician Safety Information
    • Vehicle Preparation For Testing
    • Servicing Sub-Assemblies
    • DRBIII® Safety Information
  • Warnings
    • Vehicle Damage Warnings
    • Road Testing A Complaint Vehicle
    • Electronic Pinion Factor Warnings (If Applicable)
    • Bulletins And Recalls
• Required Tools And Equipment
• Glossary Of Terms
  • Acronyms
  • Definitions
• Diagnostic Information And Procedures
  • Communication
    • Symptom: *NO RESPONSE FROM TRANSMISSION CONTROL MODULE
      • Possible Causes
      • Testing
  • Transmission - 42RLE
    • P0122-Throttle Position Sensor/Apps Low
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0123-Throttle Position Sensor/Apps High
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0124- Throttle Position Sensor/Apps Intermittent
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0218-High Temperature Operation Activated
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0562-Low Battery Voltage
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0604-Internal TCM
      • When Monitored and Set Condition:
        • Monitor Conditions
      • Possible Causes
      • Testing
    • P0605-Internal TCM
      • When Monitored and Set Condition:
        • Monitor Conditions
      • Possible Causes
      • Testing
    • P0613-Internal TCM
      • When Monitored and Set Condition:
        • Monitor Conditions
      • Possible Causes
      • Testing
    • P0706-Check Shifter Signal
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0711-Transmission Temperature Sensor Performance
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0712-Transmission Temperature Sensor Low
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0713-Transmission Temperature Sensor High
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0714-Transmission Temperature Sensor Intermittent
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0715-Input Speed Sensor Error
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0720-Output Speed Sensor Error
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0725-Engine Speed Sensor Circuit
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0731-Gear Ratio Error In 1ST
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0732-Gear Ratio Error In 2ND
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0733-Gear Ratio Error In 3RD
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0734-Gear Ratio Error In 4TH
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0736-Gear Ratio Error In Reverse
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0740-Torque Converter Clutch Control Circuit
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0750-LR Solenoid Circuit
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0755-2/4 Solenoid Circuit
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0760-Od Solenoid Circuit
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0765-UD Solenoid Circuit
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0841-LR Pressure Switch Sense Circuit
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0845-2/4 Hydraulic Pressure Test Failure
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0846-2/4 Pressure Switch Sense Circuit
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0870-Od Hydraulic Pressure Test Failure
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0871-Od Pressure Switch Sense Circuit
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0884-Power Up At Speed
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0888-Relay Output Always Off
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0890-Switched Battery
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0891-Transmission Relay Always On
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0897-Worn Out/Burnt Transaxle Fluid
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0944-Loss Of Prime
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P0992- 2-4/Od Hydraulic Pressure Test Failure
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P1652-Serial Communication Link Malfunction
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P1684-Battery Was Disconnected
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P1687-No Communication With The Mic
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P1694-Bus Communication With Engine Module
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P1775-Solenoid Switch Valve Latched In TCC Position
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P1776-Solenoid Switch Valve Latched In LR Position
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P1790-Fault Immediately After Shift
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P1793-TRD Link Communication Error
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P1794-Speed Sensor Ground Error
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • P1797-Manual Shift Overheat
      • When Monitored and Set Condition:
      • Possible Causes
      • Testing
    • Symptom: *BACKUP LAMPS COME ON WHILE SHIFTER IS NOT IN REVERSE POSITION
      • Possible Causes
      • Testing
    • Symptom: *BACKUP LAMPS INOPERATIVE
      • Possible Causes
      • Testing
    • Symptom: *CHECKING PARK/NEUTRAL SWITCH OPERATION
      • Possible Causes
      • Testing
    • Symptom: *INCORRECT TRANSMISSION FLUID LEVEL
      • Possible Causes
      • Testing
    • Symptom: *NO SPEEDOMETER OPERATION
      • Possible Causes
      • Testing
    • Symptom: *TRANSMISSION NOISY WITH NO DTC'S PRESENT
      • Possible Causes
      • Testing
    • Symptom: *TRANSMISSION SHIFTS EARLY WITH NO DTC'S
      • Possible Causes
      • Testing
    • Symptom: *TRANSMISSION SIMULATOR 8333 WILL NOT POWER UP
      • Testing
    • Verification Tests
      • 42RLE Transmission Verification Test - VER 1
      • Powertrain Verification Test VER - 2
      • Transmission No Trouble Code Verification Test
• Component Locations
  • Powertrain Control Module
  • Input/Output Speed Sensors/TRS Component Location
  • Transmission Control Module
  • Transmission Solenoid/Pressure Switch Assembly
• Connector PINOUTS
  • Crankshaft Position Sensor (2.4/4.0L A/T) - Black 3 Way
  • Data Link Connector - Black 16 Way
  • Input Speed Sensor - 2 Way
  • Output Speed Sensor - 2 Way
  • Overdrive Off Switch - 4 Way
  • Transmission Control Relay (In PDC)
  • Powertrain Control Module C1 - Black 32 Way
  • Powertrain Control Module C2 - White 32 Way
  • Powertrain Control Module C3 - Gray 32 Way
  • Throttle Position Sensor (2.4L) - White/Blue 3 Way
  • Throttle Position Sensor (4.0L) - 3 Way
  • Transfer Case Switch (Except Off-Road Package) - Black 2 Way
  • Transfer Case Switch (Off-Road Package) - Black 2 Way
  • Transmission Control Module - 60 Way
  • Transmission Range Sensor - 10 Way
  • Transmission Solenoid/Pressure Switch Assembly - 10 Way
• Schematic Diagrams
  • Circuit Schematic
• Charts And Graphs
  • Pressure Switch States
  • Solenoid Application Chart
  • Shift Lever Error Codes
  • Transmission Temperature Sensor
    • Transmission Temperature Sensor (Dual Range)