Technical Service Bulletins

A/C Compressor
- A/C End Cover/Valve Plate Leak - Revised Rebuild Kit (24-01-89)
- A/C Clutch Failure - Diagnosis/Repair (24-02-86)
- A/C Clutch Replacement - Blower Motor Resistor Check (24-01-85)
- A/C Clutch Slip/Blower Operates All Speeds But Low (24-02-85)
- Idle Flare/Rapid A/C Cycling - Ambient Temp Switch (18-25-85)
Anti-Theft Systems
- Broken Rear Console Armrest Striker/Latch Assembly (23-07-85)
- Rear Seat Back Latch Replacement Info (23-17-85)
Automatic Trans
- Erratic Shifts/Power Loss - Fuel Pump Filter Plugged (14-17-94)
- Coolant Recycling: Information On Recycled Coolant (07-03-90)
- A/T Failure - ATF Cooler Flushing Procedure (21-10-89)
- AURO Trans High Pullout Effort From Park (21-14-87)
- Increased Shifting Effort - Reroute Speedo Cable (21-14-86)
- Leaky Speedo Cable - Replace Cable ADAPTOR & O-Ring (21-04-86)
- A413/A470 Trans Drive Gear Whine - New Damper WIEGHT (21-20-85)
- Quick Adjust Throttle Pressure Cable (21-18-85)
- Torque Converter Shudder - ATF Type (21-04-85)
- A/T Gear Shift Indicator Misaligned - Readjustment (19-02-85)
- Torque Converter Replacement Trans Repair Caution (21-11-85)
- 2.2L Turbo - Hard Start/Rough Idle - Clean Injectors (01-63-84)
Auxiliary Emission Control Systems
- Rough Cold Idle/DRIVEAWAY Die Out - Map Sensor Kit (18-03-86 REV. A)
- 2.2L Turbo Fuel Vapor Odor - Remove Purge Orifice (14-02-86)
- EFI/Turbo No Cold Start/Code 13 - Time Delay Relay (18-18-86)
- 2.2L EFI Turbo Hard/No Cold Start - New Logic Module (18-44-85)
- 2.2T Warm Idle Stall - Logic Module/Airflow Adjust (18-40-85)
- Power Loss/Limit Light/Erratic Idle/Sag - TPS Repair (18-22-85 REV. A)
- Idle Flare/Rapid A/C Cycling - Ambient Temp Switch (18-25-85)
- 2.2L EFI Eng Sag/Hesitation On Light Tip In High Alt (18-21-85)
- Oil In Air Filter Box - New High Flow PCV Valve (14-11-85)
Body Interior
- A/C Clutch Slip/Blower Operates All Speeds But Low (24-02-85)
Charging Systems
- Charging System Diagnosis For All CHRYSLER Vehicles (08-03-86)
Clutch
- Clutch Growl At Medium/High Speed - Release Lever (06-02-89 REV. A)
- Reverse Clash/Clutch Won't Release - Pressure Plate (06-01-86 REV. A)
- 2.2L Turbo & 2.5L Engine Rattle In Neutral: Clutch (06-06-85)
- A413/A470 Trans Drive Gear Whine - New Damper WIEGHT (21-20-85)
Cooling System (Mechanical)
- Coolant Recycling: Information On Recycled Coolant (07-03-90)
- 1.5/1.6/2.0/2.2/2.3/2.6L Eng Overheat - REPL Reserve (07-01-85)
- EFI Throttle Body Components Service (14-24-85)
- Liquid Fuel Enters Fuel Canister - Hose Reroute (14-05-85)
- Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
Differentials & Drive Axles
- Coolant Recycling: Information On Recycled Coolant (07-03-90)
- 2.2L Turbo - Hard Start/Rough Idle - Clean Injectors (01-63-84)
Engine Control Systems
- Rough Cold Idle/DRIVEAWAY Die Out - Map Sensor Kit (18-03-86 REV. A)
- EFI/Turbo No Cold Start/Code 13 - Time Delay Relay (18-18-86)
- 2.2L EFI Turbo Hard/No Cold Start - New Logic Module (18-44-85)
- 2.2T Warm Idle Stall - Logic Module/Airflow Adjust (18-40-85)
- Power Loss/Limit Light/Erratic Idle/Sag - TPS Repair (18-22-85 REV. A)
- Idle Flare/Rapid A/C Cycling - Ambient Temp Switch (18-25-85)
- 2.2L EFI Eng Sag/Hesitation On Light Tip In High Alt (18-21-85)
Entertainment Systems
- Poor Radio Reception - Capacitor At Logic Module (08-02-87)
- Poor Radio Reception - Install Suppression Module (08-07-85)
Exterior Body Panels
- Incomplete/Hard Fuel Filling - Modify Vent Tube (14-21-85)
Front Suspension
- Front Shock Towers Sheet Metal Screws Installation (02-08-92)
- Sway Bar Squawk Below 32 Degrees F - Replace Bushings (02-09-85)
- Camber Adjustment Procedure (02-01-85)
Fuel System
- Erratic Shifts/Power Loss - Fuel Pump Filter Plugged (14-17-94)
- Flooded Engine - Check And Replace Oil And Filter (18-11-90)
- Rough Cold Idle/DRIVEAWAY Die Out - Map Sensor Kit (18-03-86 REV. A)
- 2.2L Turbo Fuel Vapor Odor - Remove Purge Orifice (14-02-86)
- EFI/Turbo No Cold Start/Code 13 - Time Delay Relay (18-18-86)
- 2.2L EFI & Turbo Intermittent Erratic Idle Code 24 (18-22-85)
- Hard Start/Rough Idle/Poor PERF - Injector Cleaner (14-63-84)
- Propane Or Co Idle Mixture Adjustment Applications (14-46-84)
Gauges & Instrument Panels
- Instrument Panel Squeak/Rattle Diagnosis (23-04-85)
- Incomplete/Hard Fuel Filling - Modify Vent Tube (14-21-85)
- A/T Gear Shift Indicator Misaligned - Readjustment (19-02-85)
- Inaccurate Fuel Gauge Reading - Replace Cluster (08-10-85)
- Fuel Gauge Inoperative - New Gauge/Fuel Sending Unit (08-04-85)
- SEATBELT Lamp Constant Dim Glow - New Bulb Type (08-05-85)
HVAC Control Systems
- Poor Radio Reception - Capacitor At Logic Module (08-02-87)
- A/C-Heater System Controls Diagnosis (24-03-85)
- Poor A/C Cooling - Blend Air Door Cable Adjustment (24-11-85)
- A/C Clutch Slip/Blower Operates All Speeds But Low (24-02-85)
- Inadequate Side Window Demisting - Spacer Block (24-07-85)
Ignition System
- Flooded Engine - Check And Replace Oil And Filter (18-11-90)
- No Start - Distributor Coil Wire Disengaging Warning (18-06-88)
- 2.2L Carb Cold Stall/Sag On ACCEL - DRIVEABILITY Kit (18-33-86)
- 2.2L 2V Rich Loading/Carburetor Icing - Delay Valve (18-10-86)
- 1.6/2.2L Carb Choke Blades Stuck - Air Horn Assembly (14-27-85)
- EFI Throttle Body Components Service (14-24-85)
- Liquid Fuel Enters Fuel Canister - Hose Reroute (14-05-85)
- Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
Infotainment
- Poor Radio Reception - Install Suppression Module (08-07-85)
Interior/Exterior Trim
- Broken Rear Console Armrest Striker/Latch Assembly (23-07-85)
- Inadequate Side Window Demisting - Spacer Block (24-07-85)
Lubrication System
- Coolant Recycling: Information On Recycled Coolant (07-03-90)
- New "SG" Quality Engine Oil (10-51-89)
- EFI Throttle Body Components Service (14-24-85)
- 2.2L Non Turbo Eng Standard Oil Filter Info (09-16-85)
- Engine Oil Viscosity Recommendation From CHRYSLER (09-17-85)
- Liquid Fuel Enters Fuel Canister - Hose Reroute (14-05-85)
- 2.2L Turbo - Hard Start/Rough Idle - Clean Injectors (01-63-84)
- Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
Manual Steering
- Sway Bar Squawk Below 32 Degrees F - Replace Bushings (02-09-85)
Manual Trans
- Hard Shifting Into/Out Of 5TH - Strut Retainer Plate (21-07-86 REV. A)
- Increased Shifting Effort - Reroute Speedo Cable (21-12-86)
- Leaky Speedo Cable - Replace Cable ADAPTOR & O-Ring (21-04-86)
- Shift Linkage Ball Socket Disengagement - Retainers (21-05-86)
- A413/A470 Trans Drive Gear Whine - New Damper WIEGHT (21-20-85)
Mechanical
- New "SG" Quality Engine Oil (10-51-89)
- 2.2/2.5L Timing Belt Skips/No Cold Start - Sealing (09-07-86)
- 2.2L Carb Cold Stall/Sag On ACCEL - DRIVEABILITY Kit (18-33-86)
- 2.2L Turbo Timing Belt Skips - Drain Tray Deflector (09-05-86)
- 2.2L 2V Rich Loading/Carburetor Icing - Delay Valve (18-10-86)
- 1.6/2.2L Carb Choke Blades Stuck - Air Horn Assembly (14-27-85)
- EFI Throttle Body Components Service (14-24-85)
- 2.2L Eng New Cylinder Head Bolts (09-13-85)
- 2.2L Eng New Connecting Rod (09-12-85)
- Liquid Fuel Enters Fuel Canister - Hose Reroute (14-05-85)
- Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
Mechanical - Hydraulic
- Coolant Recycling: Information On Recycled Coolant (07-03-90)
- 2.2L Turbo - Hard Start/Rough Idle - Clean Injectors (01-63-84)
Mirrors
- Inoperative Rear Electric Window - Replace Regulator (23-01-86)
- Flex Rack Replacement On Door Window Regulator (23-22-85)
Paint & Coatings
- Off Color Paint - Color Variance Chart Program (23-02-91)
Rear Suspension
- Front Shock Towers Sheet Metal Screws Installation (02-08-92)
- Sway Bar Squawk Below 32 Degrees F - Replace Bushings (02-09-85)
- Camber Adjustment Procedure (02-01-85)
Seats
- Power Seat Looseness/Shake - REPL Frame Add Bracket (23-04-87)
- Inoperative Rear Electric Window - Replace Regulator (23-01-86)
- Instrument Panel Squeak/Rattle Diagnosis (23-04-85)
- Flex Rack Replacement On Door Window Regulator (23-22-85)
- Rear Seat Back Latch Replacement Info (23-17-85)
Starter
- 2.2L Carb Cold Stall/Sag On ACCEL - DRIVEABILITY Kit (18-33-86)
- Charging System Diagnosis For All CHRYSLER Vehicles (08-03-86)
- 2.2L 2V Rich Loading/Carburetor Icing - Delay Valve (18-10-86)
- EFI Throttle Body Components Service (14-24-85)
- Liquid Fuel Enters Fuel Canister - Hose Reroute (14-05-85)
- Dual Ball Battery State Of Charge Indicator (08-31-84)
- Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
Steering Gear
- Steering Gear Retaining Bolt Replacement (13-01-90)
- Sway Bar Squawk Below 32 Degrees F - Replace Bushings (02-09-85)
Steering Linkage
- Steering Gear Retaining Bolt Replacement (13-01-90)
- Sway Bar Squawk Below 32 Degrees F - Replace Bushings (02-09-85)
- Front Suspension Alignment Revised Toe-In Specs (02-11-84)
Sun Roof/T-Top/Convertible Top
- Instrument Panel Squeak/Rattle Diagnosis (23-04-85)
- Broken Rear Console Armrest Striker/Latch Assembly (23-07-85)
System
- Erratic Shifts/Power Loss - Fuel Pump Filter Plugged (14-17-94)
- Flooded Engine - Check And Replace Oil And Filter (18-11-90)
- No Start - Distributor Coil Wire Disengaging Warning (18-06-88)
- Rough Cold Idle/DRIVEAWAY Die Out - Map Sensor Kit (18-03-86 REV. A)
- 2.2L Carb Cold Stall/Sag On ACCEL - DRIVEABILITY Kit (18-33-86)
- 2.2L Turbo Fuel Vapor Odor - Remove Purge Orifice (14-02-86)
- 2.2L 2V Rich Loading/Carburetor Icing - Delay Valve (18-10-86)
- EFI/Turbo No Cold Start/Code 13 - Time Delay Relay (18-18-86)
- 1.6/2.2L Carb Choke Blades Stuck - Air Horn Assembly (14-27-85)
- 2.2L EFI Turbo Hard/No Cold Start - New Logic Module (18-44-85)
- 2.2T Warm Idle Stall - Logic Module/Airflow Adjust (18-40-85)
- Power Loss/Limit Light/Erratic Idle/Sag - TPS Repair (18-22-85 REV. A)
- EFI Throttle Body Components Service (14-24-85)
- Idle Flare/Rapid A/C Cycling - Ambient Temp Switch (18-25-85)
- 2.2L EFI & Turbo Intermittent Erratic Idle Code 24 (18-22-85)
- 2.2L EFI Eng Sag/Hesitation On Light Tip In High Alt (18-21-85)
- Liquid Fuel Enters Fuel Canister - Hose Reroute (14-05-85)
- Oil In Air Filter Box - New High Flow PCV Valve (14-11-85)
- Hard Start/Rough Idle/Poor PERF - Injector Cleaner (14-63-84)
- Alcohol Blend Fuels Recommendations/Warnings (14-52-84)
- Propane Or Co Idle Mixture Adjustment Applications (14-46-84)
Wheels & Tire System
- Tire Thump/Vibration - Flat-Spotting Diagnosis (22-52-89)
- Wheel Alignment Specifications Revision (02-04-86)
- Tires Rub During Severe Turns/Braking - Normal (22-02-86)
- Fwd & RWD Tire Rotation Patterns (22-01-86)
- Front Suspension Alignment Revised Toe-In Specs (02-11-84)
Window Motors & Regulators
- Inoperative Rear Electric Window - Replace Regulator (23-01-86)
- Instrument Panel Squeak/Rattle Diagnosis (23-04-85)
- Flex Rack Replacement On Door Window Regulator (23-22-85)
- Broken Rear Console Armrest Striker/Latch Assembly (23-07-85)
Wiper/Washer Systems
- Rear Washer System Disconnected At Liftgate - Nipple (08-12-85)