Section 1 (Engine Control System (Introduction) - 2.2L (L61))
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Powertrain Control Module (PCM) Replacement
- CKP System Variation Learn Procedure
- Engine Coolant Temperature (ECT) Sensor Replacement
- Mass Air Flow (MAF) Sensor Replacement
- Manifold Absolute Pressure (MAP) Sensor Replacement
- Heated Oxygen Sensor (HO2S) Replacement (Pre-Catalyst)
- Heated Oxygen Sensor (HO2S) Replacement (Post-Catalyst)
- Accelerator Controls Pedal Replacement
- Throttle Body Assembly Replacement
- Fuel Pressure Relief Procedure
- Fuel Pressure Gage Installation and Removal
- Quick Connect Fitting(s) Service (Metal Collar)
- Quick Connect Fitting(s) Service (Plastic Collar)
- Fuel Tank Draining Procedure
- Fuel Tank Replacement (Malibu Sedan)
- Fuel Tank Replacement (Malibu MAXX)
- Fuel Tank Pressure Sensor Replacement (Malibu Sedan)
- Fuel Tank Pressure Sensor Replacement (Malibu MAXX)
- Fuel Level Sensor & Fuel Pump Module Replacement (Malibu Sedan)
- Fuel Level Sensor & Fuel Pump Module Replacement (Malibu MAXX)
- Fuel Sender Assembly Replacement (Malibu Sedan)
- Fuel Sender Assembly Replacement (Malibu MAXX)
- Filler Tube Replacement (Malibu Sedan)
- Filler Tube Replacement (Malibu MAXX)
- Fuel Hose/Pipes Replacement - Engine Compartment
- Fuel Hose/Pipes Replacement - Chassis
- Fuel System Cleaning
- Fuel Rail Assembly Replacement
- Fuel Injector Cleaning Procedure
- Fuel Injector Replacement
- Evaporative Emission (EVAP) Canister Purge Solenoid Valve Replacement
- Evaporative Emission (EVAP) Canister Vent Solenoid Valve Replacement (Malibu Sedan)
- Evaporative Emission (EVAP) Canister Vent Solenoid Valve Replacement (Malibu MAXX)
- Evaporative Emission (EVAP) Hoses/Pipes Replacement - Engine
- Evaporative Emission (EVAP) Hoses/Pipes Replacement - Engine/Chassis
- Evaporative Emission (EVAP) Canister Replacement (Malibu Sedan)
- Evaporative Emission (EVAP) Canister Replacement (Malibu MAXX)
- Ignition Coil Housing Replacement
- Ignition Control Module Replacement
- Spark Plug Inspection
- Spark Plug Replacement
- Crankshaft Position (CKP) Sensor Replacement
- Knock Sensor (KS) Replacement
- Air Cleaner Element Replacement
- Air Cleaner Assembly Replacement
- Air Cleaner Outlet Resonator Replacement
- Air Cleaner Intake Duct Replacement
- Description and Operation
- Powertrain Control Module (PCM) Description
- Fuel System Description
- Fuel System Overview
- Fuel Tank
- Fuel Fill Pipe
- Fuel Filler Cap
- Fuel Sender Assembly
- Fuel Level Sensor
- Fuel Pump
- Fuel Strainer
- Fuel Filter
- Fuel Pressure Regulator
- Fuel Feed Pipes
- Nylon Fuel Pipes
- Quick-Connect Fittings
- Fuel Pipe O-Rings
- Fuel Rail Assembly
- Fuel Injectors
- Fuel Pulse Dampener
- Fuel Metering Modes of Operation
- Starting Mode
- Clear Flood Mode
- Run Mode
- Acceleration Mode
- Deceleration Mode
- Battery Voltage Correction Mode
- Fuel Cutoff Mode
- Fuel Trim
- Evaporative Emission (EVAP) Control System Description
- Electronic Ignition (EI) System Description
- Throttle Actuator Control (TAC) System Description
- Knock Sensor (KS) System Description
- Air Intake System Description
- Special Tools and Equipment