Technical Service Bulletins: Other Variant
WARNING: This page is about the XC60 T-6, which is a different variant/trim than selected.
- A/C Compressor
- Accessories & Equipment
- Accessories Control Systems
- Initial Quality Survey (IQS) PDS + (SMB17-026-2022-10-17)
- Parking Assistance System (Pas) Enhanced Troubleshooting (TJ26753.4.0)
- Control Module Swapping (TJ 31946.1.2)
- Parking Assist Camera (PAC), Flickering Video Signal In Display (TJ27989)
- RDAR Replacement (Satellite Radio Tuner), Battery Drain (TJ26188.1.12)
- BLIS Fault Tracing (TJ25788.1.3)
- Newsletter 75: Mandatory Tools (ST-222)
- SENSUS Downloading Problems. IAM 2.1 System (TJ26525.3.0)
- Replacing CEM Or RECOMMUNICATING With A 'SLEEPING' Vehicle (TJ32564.1.1)
- "BLIS Service Required" Message In Dim Without DTC (TJ25252.7.0)
- Noise Front Wheel Hub And/Or DTC In BCM (TJ25329)
- Acc Disabled During Queue Assist (TJ27229)
- Newsletter 59: Mandatory Tools (ST-205)
- Ambient Temp Is Not Accurate (TJ25253)
- SENSUS Connected Touch (SCT) Unstable Or No GPS (TJ28137)
- SENSUS, BLUETOOTH Audio Disturbances (TJ28465)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- Seat Memory Position 3 Lost Or Changed, Power Seat Module, PSM (TJ23715)
- SENSUS Connected Touch (SCT) ACU Upgrade Procedure (TJ28184)
- SENSUS Connected Touch (SCT); Firmware Upgrade Information And Time Zone Error (TJ28299)
- SENSUS Connected Touch (SCT); Activating IGO Navigation And "Scratch Code" (TJ28266)
- Improved 12 Volt Socket (TJ27466)
- SENSUS, IPHONE & Android Phones Do Not Connect To BLUETOOTH (TJ26145)
- DTC Bpm-U300044 Set With Latest Bpm SW (TJ26973)
- SENSUS Connected Touch; No/Poor Touch Functionality (TJ28076)
- SENSUS, Unable To Pair Any Phones/Devices Using BLUETOOTH (TJ28056)
- Most Software Error Message "CEM Does Not Respond To The Programming Command" (TJ18740)
- SENSUS Connected Touch (SCT), "GPS Updating" Message (TJ 28019)
- SENSUS Connected Touch May Not Work (TJ28007)
- New Logic On Seat Belt Reminder After Software Upgrade (TJ26361)
- Parking Assist Camera (PAC) Does Not Work - Deformed Or Blank Picture (TJ25170)
- SENSUS, Lost Sound From IPOD Function, IOS 5 And Newer (TJ25478)
- Distance Alert Does Not Keep Settings After Ignition Cycle (TJ27013)
- FSM DTC C1A6754 And C1A6768, Acc (TJ26288)
- Restoring CUSTOMERS' Preferred Settings (SMB39-009)
- Audible Lock Confirmation Function Missing (TJ25940)
- VOLVO Accessory Rear Seat Entertainment (SMB39-008)
- Interrupted ICM Upgrade (TJ25318)
- Software Package Content When Ordering SENSUS SW (TJ25359)
- Bpm And Bad Sound After Bpm Upgrade 9/20/2011 - 10/10/2011 (TJ25351)
- TRM: Caravan And Trailer With Led Light (RTJ 21297)
- Fuel Gauge/Tank Fault Tracing Guide And Prior Approval (TJ20532)
- VOLVO Service For Life: Complimentary SW Updates (RTJ 23940)
- SENSUS ICM Display May Be Black At Start-Up (RTJ 24912)
- New SW Upgrade Disc For RTI: Quick Guide (Mmm, Mmm+, Mmm2) (TJ 16514)
- SENSUS System, No Response When Selecting A Function. (RTJ 24842)
- Reduced Alternator Performance Due To Incorrect Installation Of Accessories (RTJ 24495)
- SENSUS Infotainment System, Power Button Press May Not Give Any Response. (RTJ 24427)
- SENSUS; New Method Of Adding RTI As Accessory/Voice Control SP Added (RTJ 24244)
- XC60 My2011, New Method For Changing Language In Dim And ICM (RTJ 23442)
- Keyless / Passive Entry / Locking / Unlocking, Blocked By Mobile Phone (RTJ 24016)
- SENSUS Infotainment System Fault Tracing Preparation (RTJ 24069)
- Accessory RSE DVD/LCD Electronics Module Replacement (TJ 21368)
- Updated Instruction, Park Assistance, Rear/Front, Interim Solution During Tests (TJ23188)
- Front Park Assist, False Warning (Too Sensitive) (TJ20966)
- CEM: New Generation CEM And Wiring Configuration Introduced Structure Week 09W46 (RTJ 22186)
- Air Bag, SRS
- R10058/R10125/R10136 Driver Airbag Returns - Shipping Instruction (SMB88-010)
- R10058 Driver Airbag Returns - Shipping Instruction (PB88-010)
- Used Airbag Return/Disposal Pilot Program (SMB88-026)
- Airbag Unit/Steering Wheel, Creaking Noise (TJ 27799)
- Noise From CLOCKSPRING Area (TJ27905)
- "Airbag System Service Required" Message In Dim, DTC SRS-B00021A (TJ22855)
- "Airbag System Service Required" Message In Dim, DTC SRS-B00021A (RTJ 22855)
- Anti-Lock Brakes
- Anti-Theft Systems
- Remote Control Does Not Work (TJ 28752)
- Alarm System, Service Required Displayed In Dim (TJ25669)
- Audible Lock Confirmation Function Missing (TJ25940)
- Sticking Outer Door Handle (TJ20904)
- Keyless / Passive Entry / Locking / Unlocking, Blocked By Mobile Phone (RTJ 24016)
- Message "Child Lock Service Required" In Dim (RTJ 23906)
- Feature Operation, Demonstration And Customer Satisfaction (SMB17-015)
- Door Locks, Unstable Function In Cold Weather Conditions (TJ17645)
- Automatic Trans
- VOLVO Lifetime Replacement Parts & Labor Warranty (SMB00-342)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Rough 2-1 Downshifts, TF80SC (TJ 31210)
- Prior Approval No Longer Needed For TF80 Automatic Gearbox (TJ23342)
- VOLVO Service 2.0 (SMB39-013)
- Aw TF80SC: Rough Shifts, 5-4 Downshift, Neutral Control, N-D And/Or DTC P089500 (TJ26840)
- Aw TF80 SC - Hard 6-5 And/Or 2-1 Downshift Or No Upshift (TJ29050)
- Newsletter 59: Mandatory Tools (ST-205)
- Acc Disabled During Queue Assist (TJ27229)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Harsh 1-2 Up Shift TF80SC (TJ28959)
- Transmission And All Wheel Drive (AWD) Lubricants (TJ16773)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- Differential Electronic Module (DEM) Software (SW) (TJ20756)
- Propeller (Prop) Shaft Removal And Installation Method (TJ27295)
- New Generation Automatic Transmission TF80, Policy For Transmission Repairs (SMB40-001)
- Transmission Control Module (TCM) Software (SW) (TJ16761)
- Gear Whine At 80-110 Kph, 50-70 Mph (TJ25918)
- No All Wheel Drive And DEM DTCS (RTJ 24396)
- CEM Recovery- Interrupt Of SW Download. (RTJ 14902)
- Transmission Serial Number Records When Replacing Transmission Components (RTJ 22900)
- Automatic Transmission Cooler/Lines Flushing (RTJ 19495)
- CANBUS Network Information (RTJ 16386)
- Auxiliary Emission Control Systems
- Auxiliary Power Unit
- Axle Shafts
- VOLVO Lifetime Replacement Parts & Labor Warranty (SMB00-342)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Unusual Noise While Driving From Sealing Ring (TJ 33524.2.0)
- Grease Leaking From Outside Drive Shaft Bellows (Boots) (TJ26943)
- Hub Bearing Splash Shields (TJ25167)
- Rattle Noise From Drive Shaft Bearing (RTJ 23162)
- Body Electrical
- Body Interior
- Control Module Swapping (TJ 31946.1.2)
- SENSUS ICM Display Black And DTC CEM-U015600 Set (TJ25872.11.1)
- Replacing CEM Or RECOMMUNICATING With A 'SLEEPING' Vehicle (TJ32564.1.1)
- "BLIS Service Required" Message In Dim Without DTC (TJ25252.7.0)
- Noise Front Wheel Hub And/Or DTC In BCM (TJ25329)
- Pot Tailgate Closing Attributes (TJ30536)
- VOLVO Service 2.0 (SMB39-013)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- Most Software Error Message "CEM Does Not Respond To The Programming Command" (TJ18740)
- Lost Initialization Door Windows (TJ26054)
- VOLVO Service For Life: Complimentary SW Updates (RTJ 23940)
- Keyless / Passive Entry / Locking / Unlocking, Blocked By Mobile Phone (RTJ 24016)
- Message "Child Lock Service Required" In Dim (RTJ 23906)
- CEM Recovery- Interrupt Of SW Download. (RTJ 14902)
- Dim Message "Key Error - Try Again" Due To New Steering Column Lock (RTJ 23086)
- CANBUS Network Information (RTJ 16386)
- Brakes Control Systems
- VOLVO Lifetime Replacement Parts & Labor Warranty (SMB00-342)
- Pulsation/Vibration While Braking (New Repair Method) (TJ 35833.1.1)
- High Mounted Stop Lamp (TJ 29523.3.0)
- VOLVO Service 2.0 (SMB39-013)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- Front Wheel Speed Sensor Cable Repair Method (Re-Posted) (TJ16784V2)
- Unexpected City Safety Interventions (RTJ 24155)
- CEM Recovery- Interrupt Of SW Download. (RTJ 14902)
- Unnecessary Brake Control Module (BCM) Replacements (RTJ 16701)
- VIDA Upcoming Technology (SMB00-290)
- CANBUS Network Information (RTJ 16386)
- Charging Systems
- Voltage Regulator Replacement Recommended Instead Of Alternator Replacement (TJ26897.3.0)
- MIDTRONICS PSC-550S And PSC-700 Vehicle Power Supply (ST-111A)
- Importance Of Vehicle In Stock Battery Maintenance (SMB17-2013)
- Engine Compartment Central Electrical Unit Fuse Pf1 (TJ25417)
- Reduced Alternator Performance Due To Incorrect Installation Of Accessories (RTJ 24495)
- Collision/Avoidance
- Parking Assistance System (Pas) Enhanced Troubleshooting (TJ26753.4.0)
- Parking Assist Camera (PAC), Flickering Video Signal In Display (TJ27989)
- BLIS Fault Tracing (TJ25788.1.3)
- "BLIS Service Required" Message In Dim Without DTC (TJ25252.7.0)
- Acc Disabled During Queue Assist (TJ27229)
- Mandatory Tool - 9997483 Hole Punch (ST-204)
- No Image From PAC Camera When Engaging Reverse Gear (TJ28309)
- Parking Assist Camera (PAC) Does Not Work - Deformed Or Blank Picture (TJ25170)
- Dim Speaker Does Not Work (TJ25164)
- Distance Alert Does Not Keep Settings After Ignition Cycle (TJ27013)
- FSM DTC C1A6754 And C1A6768, Acc (TJ26288)
- Pedestrian Detection With Full Auto Brake Demonstration (SMB17-014)
- DTCS CVM-U300000, SRS-U043300 And CEM-U043300 (TJ25146)
- Unexpected City Safety Interventions (RTJ 24155)
- Updated Instruction, Park Assistance, Rear/Front, Interim Solution During Tests (TJ23188)
- Front Park Assist, False Warning (Too Sensitive) (TJ20966)
- Retailer Technical Journal 22470 Adaptive Cruise Control: "Radar Blocked" Message On Desolate Roads (TJ22470)
- Communication Devices
- Remote Connection, BOMGAR Application (TJ 8501.13.0)
- Vehicle/Connectivity Report Checklist (TJ 37175.1.1)
- Control Module Swapping (TJ 31946.1.2)
- SENSUS ICM Display Black And DTC CEM-U015600 Set (TJ25872.11.1)
- Acc Disabled During Queue Assist (TJ27229)
- SENSUS, BLUETOOTH Audio Disturbances (TJ28465)
- DTC Bpm-U300044 Set With Latest Bpm SW (TJ26973)
- SENSUS Connected Touch; No/Poor Touch Functionality (TJ28076)
- SENSUS, Unable To Pair Any Phones/Devices Using BLUETOOTH (TJ28056)
- SENSUS, Lost Sound From IPOD Function, IOS 5 And Newer (TJ25478)
- SENSUS ICM Display Functionality SW Improvements And Quick Guide (SMB39-011)
- SENSUS ICM Display & Functionality Improvements (TJ24915)
- Restoring CUSTOMERS' Preferred Settings (SMB39-009)
- Bpm And Mobile Phone Compatibility. (TJ13753)
- SENSUS, No Sound From IPHONE Media After Start Up (TJ25640)
- SENSUS, Radio Does Not Work After Start Up, DTC Set (TJ25576)
- Bpm And Bad Sound After Bpm Upgrade 9/20/2011 - 10/10/2011 (TJ25351)
- Bpm BLUETOOTH Communication May Be Unsteady With HTC Mobile Phones (TJ21747)
- Handling Of BLUETOOTH Phone Module (Bpm) Compatibility Questions (RTJ 23691)
- Bpm BLUETOOTH Communication May Be Interrupted (TJ20962)
- Bpm BLUETOOTH Communication May Be Interrupted. (TJ20962)
- SENSUS System, No Response When Selecting A Function. (RTJ 24842)
- BLUETOOTH Phone Module (Bpm) And Mobile Phone Compatibility (TJ 13753)
- XC60 My2011, New Method For Changing Language In Dim And ICM (RTJ 23442)
- Intermittently No Sound From Infotainment System After Start-Up (TJ 20560)
- BLUETOOTH Phone Module (Bpm) Incomplete PHONEBOOK Synchronize (RTJ 18954)
- Bpm BLUETOOTH Communication May Be Unsteady With HTC Mobile Phones. (RTJ 21747)
- ICM Display May Become Black At Start-Up Or During Driving. (RTJ 22956)
- Accessory RSE Headrest Harness Replacement (RTJ 24111)
- VOLVO On Call® New IPHONE® App - Now Available (SMB00-301)
- Feature Operation, Demonstration And Customer Satisfaction (SMB17-015)
- Handling Of BLUETOOTH (SMB39-006)
- Cooling System (Mechanical)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Engine Control Systems
- SW Part Numbers For Total Upgrade And PDS (TJ 27536.21.1)
- Control Module Swapping (TJ 31946.1.2)
- VOLVO Service 2.0 (SMB39-013)
- Anti-Tamper Device, Communication Lost (TJ27910)
- Content Of EUPDATES Associated With VIDA 2014D (SPJ28541)
- Vantage Pro Oscilloscope Update - 14.4 Software Release Supersedes The June 10, 2014 Edition (150A)
- Polestar Calibration Identification (TJ29552)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Check Engine Light Due To Purge Valve Leakage (TJ28228)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- SENSUS Connected Touch (SCT) ACU Upgrade Procedure (TJ28184)
- Hesitation Upon Acceleration (TJ26091)
- Leakage Diagnostic Function Improvements (TNN 28-74)
- VOLVO Service For Life: Complimentary SW Updates (RTJ 23940)
- HS Can Faults, Water In EHPAS Unit (PSCM) (RTJ 24849)
- Dim Message "Engine Oil Level Low" (RTJ 24382)
- CCM U040168 Posted For Incorrect Reason (RTJ 24545)
- CEM Recovery- Interrupt Of SW Download. (RTJ 14902)
- Too High Quiescent Current May Drain The Battery (RTJ 23515)
- Usage Of Reload Software (TJ23502)
- Total Upgrade Most For All New S60 And XC60 Blocked (TJ23106)
- Service Action 223 Dim Message "Soot Filter Full" Shown On Petrol Cars (TJ22151)
- VIDA Upcoming Technology (SMB00-290)
- CEM: New Generation CEM And Wiring Configuration Introduced Structure Week 09W46 (RTJ 22186)
- CANBUS Network Information (RTJ 16386)
- Entertainment Systems
- Control Module Swapping (TJ 31946.1.2)
- Parking Assist Camera (PAC), Flickering Video Signal In Display (TJ27989)
- SIRIUSXM Tuner Replacement Process (TJ 31535.1.3)
- SIRIUSXM Radio INOP Or No Sound On Sat Source (TJ 34021.1.1)
- SENSUS ICM Display Black And DTC CEM-U015600 Set (TJ25872.11.1)
- RDAR Replacement (Satellite Radio Tuner), Battery Drain (TJ26188.1.12)
- SENSUS Downloading Problems. IAM 2.1 System (TJ26525.3.0)
- SENSUS Navigation; Obtaining Map Activation Codes And Converting Maps (TJ 27419)
- SENSUS; Audio Mute Logic (TJ29025)
- SENSUS Connected Touch (SCT), No Media Menu (TJ28580)
- SENSUS, BLUETOOTH Audio Disturbances (TJ28465)
- SENSUS, IPHONE & Android Phones Do Not Connect To BLUETOOTH (TJ26145)
- SENSUS Connected Touch; No/Poor Touch Functionality (TJ28076)
- SENSUS, Unable To Pair Any Phones/Devices Using BLUETOOTH (TJ28056)
- Most Software Error Message "CEM Does Not Respond To The Programming Command" (TJ18740)
- SENSUS Connected Touch (SCT), "GPS Updating" Message (TJ 28019)
- SENSUS Connected Touch May Not Work (TJ28007)
- SENSUS NAV: Speed Limit Incorrect - Reads Higher Than Posted Speed In CANADA (TJ26785)
- SENSUS - Map Update Failures During Upgrade (TJ26411)
- SENSUS, Lost Sound From IPOD Function, IOS 5 And Newer (TJ25478)
- RSE Opening Mechanism - Modification (TJ25377)
- SENSUS ICM Display Functionality SW Improvements And Quick Guide (SMB39-011)
- CCM Knobs Stiff To Operate In Cold Condition (TJ26605)
- SENSUS ICM Display & Functionality Improvements (TJ24915)
- Satellite Radio Tuner & General Fault Tracing For Reception Problems (SIRIUS) (TJ25130)
- SENSUS RTI Map Version Information (TJ26256)
- Prior Approval For RDAR Replacement (SMB39-001)
- Stuck CDS In Audio Units (SMB39-004)
- Restoring CUSTOMERS' Preferred Settings (SMB39-009)
- Sat1 And Sat2 Audio Source Not Available Or "Greyed Out" (TJ25950)
- SENSUS System, No Sound Or Button Function Etc. (TJ25549)
- SENSUS, No Sound From IPHONE Media After Start Up (TJ25640)
- SENSUS, Radio Does Not Work After Start Up, DTC Set (TJ25576)
- Battery Current Consumption And RDAR (TJ25590)
- VOLVO Accessory Rear Seat Entertainment (SMB39-008)
- Interrupted ICM Upgrade (TJ25318)
- Software Package Content When Ordering SENSUS SW (TJ25359)
- SENSUS ICM Display May Be Black At Start-Up (RTJ 24912)
- Specific Aux Jack Required For Accessory Installed RSE With SENSUS (RTJ 24897)
- SENSUS System, No Response When Selecting A Function. (RTJ 24842)
- USB And IPOD Music Interface With IPOD Battery Charging Symptom. (TJ 20185)
- External Media Support (Aux, Cd, IPOD And USB) In IAM (TJ 22530)
- IAM With Stuck Cd In Cd-Player Or Cd-Changer. (TJ 22249)
- SENSUS Infotainment System, Power Button Press May Not Give Any Response. (RTJ 24427)
- SENSUS; New Method Of Adding RTI As Accessory/Voice Control SP Added (RTJ 24244)
- XC60 My2011, New Method For Changing Language In Dim And ICM (RTJ 23442)
- SENSUS System With DVD Player, RTI Map Or Video Not Displayed In The ICM (TJ23490)
- Pre Delivery Service (PDS) Checklist, Temporary Addition (RTJ 24409)
- Intermittently No Sound From Infotainment System After Start-Up (TJ 20560)
- VOLVO Service For Life: Complimentary SW Updates (RTJ 23940)
- XC60: Accessory RTI Installation Extra Co-Ax Cable Required (RTJ 24197)
- ICM Display May Become Black At Start-Up Or During Driving. (RTJ 22956)
- Accessory RSE (HEADRESTRAINT DVD) Warranty Coverage And Claim Procedure (SMB39-005)
- Accessory RSE Headrest Harness Replacement (RTJ 24111)
- SENSUS Infotainment System Fault Tracing Preparation (RTJ 24069)
- Accessory RSE DVD/LCD Electronics Module Replacement (TJ 21368)
- SENSUS ICM Display May Be Black While Vehicle Is In Transport Mode (RTJ 23932)
- Feature Operation, Demonstration And Customer Satisfaction (SMB17-015)
- All New S60: Incorrect Power Supply Connection Causing SWDL Problems (RTJ 23623)
- Audio Service Form (RTJ 5722)
- Retailer Technical Journal 21735 Volume/Power And Tuning/Sound Button In CCM Panel As Spare Part. (TJ21735)
- Exhaust
- Exterior Body Panels
- Pot Tailgate Closing Attributes (TJ30536)
- Rescue Information - My15 (27691)
- Tailgate, Booming/Rattling Noise (TJ25751)
- Creaking Noise From Door Striker Area (TJ26867)
- WINDOWLIFT Noises (TJ26607)
- Tailgate Creaking Noise (TJ18838)
- Squeaking Or Creaking Noise From Side Doors (TJ16308)
- Sticking Outer Door Handle (TJ20904)
- Fuel Cap, Broken Strap (TJ24879)
- Corroded License Plate Fasteners (TJ25142)
- Tailgate Water Entrance (TJ23040)
- Replacement Of Structural Parts On VOLVO Vehicles (SMB00-310)
- Water Management For Doors. (RTJ 20745)
- Sticking Fuel Filler Door Actuator S80, V70/XC70, XC60 (RTJ 20772)
- Retailer Technical Journal 21854 Wind Noise, Fault Tracing Guide (TJ21854)
- XC60 Fuel Filler Door Adjustment (SMB83-209)
- Exterior Lights
- Left Front Led Flickers After Turning Car Off - Check Outer Position Bulbs (TJ 36584.1.1)
- High Mounted Stop Lamp (TJ 29523.3.0)
- Headlight Restoration (TJ24584)
- Headlamp LENSE, Micro Cracks Caused By Washer Fluid With High PH (TJ28380)
- TRM: Caravan And Trailer With Led Light (RTJ 21297)
- Incorrect Bulb Replacement-Front Side Marker Indicator Bulb. (RTJ 24949)
- VOLVO Service For Life: Complimentary SW Updates (RTJ 23940)
- Front Position Lights, Different Colors (RTJ 24152)
- Exterior Incandescent Bulb Replacement (SMB35-015)
- Frames, Subframes & Crossmembers
- Front Suspension
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Noise Front Wheel Hub And/Or DTC In BCM (TJ25329)
- Front Anti-Roll Bar, Squeaking Noise From Bushings (TJ23109)
- Parts Return: 31340127, 31340128 Link Arm (PB61-021)
- Front Control Arm Rear Hydro Bushing, Squeaking Noise (TJ14507)
- Front Strut Damper Rod, Diameter Change (TJ20524)
- Harsh Ride And Popping Noise, Front Bump Stop Too Hard (RTJ 22510)
- Fuel System
- Fuel Pump Unit Updated Method (TJ 32739.1.0)
- Fuel Gauge/Tank Fault Tracing Guide (TJ20532.1.8)
- Parts Return: 31201433 Vacuum Hose (PB52-032)
- Check Engine Light Due To Purge Valve Leakage (TJ28228)
- Long Cranking Time. Fuel Pump Triple Valve (TJ27217)
- Fuel Tank And/Or Fuel Pump Prior Approval Process (SMB23-038)
- Leakage Diagnostic Function Improvements (TNN 28-74)
- Fuel Cap, Broken Strap (TJ24879)
- Fuel Gauge/Tank Fault Tracing Guide And Prior Approval (TJ20532)
- E10 Petrol Fuel Requirements (SMB23-035)
- E10 Petrol Fuel Requirements (RTJ 24461)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Fuel Gauge/Tank Fault Tracing Guide (TJ20532.1.8)
- Ambient Temp Is Not Accurate (TJ25253)
- Fuel Gauge/Tank Fault Tracing Guide And Prior Approval (TJ20532)
- Dim Message "Engine Oil Level Low" (RTJ 24382)
- Service Campaign 236 - Washer Reservoir Level Sensor INOP (RTJ 24659)
- P3 TPMS, DTCS For All Four Missing Sensors (RTJ 24648)
- Wind Noise In Lower A Pillar Area (RTJ 20862)
- Fuel Gauge/Tank Fault Tracing Guide (TJ 20532)
- All New S60: Incorrect Power Supply Connection Causing SWDL Problems (RTJ 23623)
- General Servicing
- Headlights
- Left Front Led Flickers After Turning Car Off - Check Outer Position Bulbs (TJ 36584.1.1)
- Digital Head Light Instrument For L.E.D., Halogen, Xenon Vehicles (32242.3.0)
- Moisture In Headlamp, Leak Test (TJ17076.11.0)
- Headlight Restoration (TJ24584)
- Headlamp LENSE, Micro Cracks Caused By Washer Fluid With High PH (TJ28380)
- Headlamp, Vibration (TJ27277)
- Service Campaign 236: Washer Reservoir Level Sensor (SMB36-236)
- HVAC Control Systems
- Animation: Evaporator Climate Unit, Cleaning (SPJ32811.2.0)
- Air Vents, Blisters/Bubbles (TJ19967)
- Climate Unit, Odor Or Bad Smell (TJ17817)
- Climate Unit Fan Motor, Noise Or Does Not Work (TJ27558)
- Ac Cleaning Fluid P/N 1161837 Discontinued (TJ28340)
- Temperature Dropping During Driving, Climate/Heater Unit (TJ18674)
- Cooling Unit, Fault Tracing Guideline (TJ26262)
- Temperature Dropping During Driving, Climate/Heater Unit (RTJ 18674)
- Feature Operation, Demonstration And Customer Satisfaction (SMB17-015)
- Identification
- Vehicle Type And Platform Identification (TJ19245.1.19)
- Expendable Items Parts List (SMB00-108D)
- New Shipping Address And Label (SMB00-012)
- VIN Plate And VIN Specific Labeling Ordering Procedure (SMB89-005)
- Rescue Information - My15 (27691)
- Transmission Serial Number Records When Replacing Transmission Components (RTJ 22900)
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- SENSUS/SENSUS Connect Navigation Base Map Versions (TJ 35058.1.4)
- Control Module Swapping (TJ 31946.1.2)
- SENSUS ICM Display Black And DTC CEM-U015600 Set (TJ25872.11.1)
- BLIS Fault Tracing (TJ25788.1.3)
- Map Upgrade Warranty Policy (SMB00-427)
- SENSUS Downloading Problems. IAM 2.1 System (TJ26525.3.0)
- SENSUS, Navigation Map Versions (TJ27567)
- Lifetime MAPCARE (TJ 29181)
- SENSUS Navigation; Obtaining Map Activation Codes And Converting Maps (TJ 27419)
- Acc Disabled During Queue Assist (TJ27229)
- SENSUS MAPCARE 2014 Update: Information And Map Loading Instructions (TJ26064)
- Mandatory Tool - 9997483 Hole Punch (ST-204)
- SENSUS Connected Touch (SCT) Unstable Or No GPS (TJ28137)
- SENSUS Connected Touch (SCT); Firmware Upgrade Information And Time Zone Error (TJ28299)
- SENSUS Connected Touch (SCT); Activating IGO Navigation And "Scratch Code" (TJ28266)
- SENSUS Connected Touch; No/Poor Touch Functionality (TJ28076)
- SENSUS Connected Touch (SCT), "GPS Updating" Message (TJ 28019)
- SENSUS Connected Touch May Not Work (TJ28007)
- Parking Assist Camera (PAC) Does Not Work - Deformed Or Blank Picture (TJ25170)
- SENSUS, Navigation Displays "Navigation Please Wait..." Message At Startup (TJ 27568)
- SENSUS NAV: Speed Limit Incorrect - Reads Higher Than Posted Speed In CANADA (TJ26785)
- SENSUS - Map Update Failures During Upgrade (TJ26411)
- RTI Navigation Screen May Become Black At Start-Up (TJ22393)
- SENSUS ICM Display Functionality SW Improvements And Quick Guide (SMB39-011)
- CCM Knobs Stiff To Operate In Cold Condition (TJ26605)
- HOMELINK, No Function (TJ25609)
- SENSUS ICM Display & Functionality Improvements (TJ24915)
- SENSUS RTI Map Version Information (TJ26256)
- SENSUS: Map Care 2012 Update (SMB39-010)
- Restoring CUSTOMERS' Preferred Settings (SMB39-009)
- SENSUS System, No Sound Or Button Function Etc. (TJ25549)
- RTI System Identification Guide (TJ17424)
- SENSUS, Radio Does Not Work After Start Up, DTC Set (TJ25576)
- RTI, Voice Guidance Suddenly Stops During Driving. (TJ23153)
- TRM: Caravan And Trailer With Led Light (RTJ 21297)
- New SW Upgrade Disc For RTI: Quick Guide (Mmm, Mmm+, Mmm2) (TJ 16514)
- SENSUS System, No Response When Selecting A Function. (RTJ 24842)
- XC60 My2011, New Method For Changing Language In Dim And ICM (RTJ 23442)
- SENSUS System With DVD Player, RTI Map Or Video Not Displayed In The ICM (TJ23490)
- Pre Delivery Service (PDS) Checklist, Temporary Addition (RTJ 24409)
- XC60: Accessory RTI Installation Extra Co-Ax Cable Required (RTJ 24197)
- ICM Display May Become Black At Start-Up Or During Driving. (RTJ 22956)
- Accessory RSE Headrest Harness Replacement (RTJ 24111)
- New SW Upgrade Disc For RTI, Mmm, Mmm+ And Mmm2 Available (TJ15493)
- Feature Operation, Demonstration And Customer Satisfaction (SMB17-015)
- Front Park Assist, False Warning (Too Sensitive) (TJ20966)
- Retailer Technical Journal 22470 Adaptive Cruise Control: "Radar Blocked" Message On Desolate Roads (TJ22470)
- Interior/Exterior Trim
- Trim Moulding Side Door Windows And Roof Rails, Discoloured Appearance (TJ30967.2.1)
- Service Action S89833 Replace Headliner Clip (S89833)
- Extended Warranty P89405, VOLVO Emblem On Radiator Grille Iron Mark Logo (TJ25957.3.6)
- Tailgate Panel, Inner Support Loose (TJ 31578.1.0)
- Air Vents, Blisters/Bubbles (TJ19967)
- Center Console, Creaking Noise (TJ 29264)
- Extended Warranty P89405: VOLVO Emblem On Radiator Grille Iron Mark Logo Model Year 2010 - 2013 S80, S60, V70, XC70, XC60, XC90, S40, V50, C30, C70 (P89405)
- Sun Roof Cover Moulding Falling Off (TJ29588)
- HOMELINK, No Function (TJ25609)
- Seat Upholstery, Vinyl Parts May Crack (TJ26206)
- Corroded License Plate Fasteners (TJ25142)
- Grocery Bag Holder Repair (TJ22015)
- Water Management For Doors. (RTJ 20745)
- Leather Upholstery Care (RTJ 24661)
- Luggage Compartment Floor Hatch Handle Loose (RTJ 23597)
- Wind Noise In Lower A Pillar Area (RTJ 20862)
- Fuel Gauge/Tank Fault Tracing Guide (TJ 20532)
- Retailer Technical Journal 22395 High Pitch Wind Noise Near Outer Rear View Mirror. (TJ22395)
- Interior/Illumination Lights
- Lubrication System
- Expendable Items Parts List (SMB00-108D)
- Engine Oil Consumption Test FAQ (SMB22-006)
- 4 Cylinder VEP Engine: CASTROL Edge Professional V 0W-20 Synthetic Oil (TJ 34740.1.4)
- Expendable Items Reimbursement - Oil (SMB22-206)
- Prior Approval: Oil Consumption, "Low Oil Level" Or "Oil Level Low" In Dim (TJ24643)
- Prior Approval: Si6/Si6T ULEV/T Engine Code 95/90 Excessive Oil Consumption (TJ30021)
- Engine Oil Leak From Oil Duct Plug (TJ17714)
- Required Engine Oils (12,000 Km Intervals) (SMB22-003C)
- Required Engine Oils (7,500 Miles/12,000 Km Intervals) (SMB22-003)
- Oil Consumption, Low Or Uneven Idle, "Low Oil Level" Or "Oil Level Low" In Dim (RTJ 24643)
- Dim Message "Engine Oil Level Low" (RTJ 24382)
- Hesitation Upon Acceleration (TJ24516)
- High Oil Consumption / Low Oil Level / Poor Or Uneven Idle (TJ 19302)
- Manual Steering
- VOLVO Lifetime Replacement Parts & Labor Warranty (SMB00-342)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Service Campaign 252, Power Steering Pump Cover (TJ26218)
- Squeaking Noise From Standard Steering Gear While Turning Steering Wheel (TJ22117)
- Steering Gear Extended Warranty (SMB64-230)
- Updated Procedure, Steering Gear (Rack) Replacement (TJ23271)
- Standard Steering Gear, Squeaking Noise (RTJ 18943)
- Retailer Technical Journal 21474 Power Steering System Layout, Numbering Of Connection Points (TJ21474)
- Manual Trans
- Mechanical
- VOLVO Lifetime Replacement Parts & Labor Warranty (SMB00-342)
- Newsletter 112: Mandatory Tools (ST-255)
- VOLVO Engine Oil Consumption (SMB22-007)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Prior Approval: Oil Consumption, "Low Oil Level" Or "Oil Level Low" In Dim (TJ24643)
- Prior Approval: Si6/Si6T ULEV/T Engine Code 95/90 Excessive Oil Consumption (TJ30021)
- Prior Approval Process For Oil Consumption Claim On Si6 Engine (SMB21-005)
- Engine Oil Leak From Oil Duct Plug (TJ17714)
- Timing Belt Replacement Interval For Model Years 1999 And Up (SMB21-14)
- Cam Cover (Valve Cover) Reseal Procedure, Additional Information (TJ28312)
- Si6-Turbo: Updated Cylinder Head Replacement Procedure (Install Check Valve) (TJ27575)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Required Engine Oils (12,000 Km Intervals) (SMB22-003C)
- Required Engine Oils (7,500 Miles/12,000 Km Intervals) (SMB22-003)
- Oil Consumption, Low Or Uneven Idle, "Low Oil Level" Or "Oil Level Low" In Dim (RTJ 24643)
- Hesitation Upon Acceleration (TJ24516)
- High Oil Consumption / Low Oil Level / Poor Or Uneven Idle (TJ 19302)
- High Oil Consumption/Low Oil Level/Bad Or Uneven Idle (RTJ 19302)
- Mechanical - Hydraulic
- Pulsation/Vibration While Braking (New Repair Method) (TJ 35833.1.1)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Front Brake Caliper - Noise (TJ30393)
- Specification Change, Rear Ventilated Brake Disc Thickness (TJ29045)
- Scraping Noise, Front Wheel Hub Conflict With Brake Disk, BCM-C003307 C003007 (TJ25329)
- 17 Inch Front Brake, Knocking Noise When Braking And Turning (TJ22751)
- Front Brakes 16" (FN3) Squealing Noise While Reversing In Low Speed (TJ26889)
- The VOLVO Safe + Secure Coverage Plan 555FSMW, 555WTY, 555PFMW, 555PWTY, 336FSMW & 448FSMW My2009 - My2011 Vehicles (SMB00-278)
- Memory Modules
- Mirrors
- Wind Noise, Outer Rear View Mirror Area (TJ23801)
- Outside Mirrors, Do Not Stop To Or At Driving Position (TJ26989)
- Tilted Mirror Incorrect Position In Reverse Gear (TJ25431)
- Wind Noise, Outer Rear View Mirror Area (RTJ 23801)
- Squeaking Noise When Folding The Outer Mirror (RTJ 22546)
- Retailer Technical Journal 22395 High Pitch Wind Noise Near Outer Rear View Mirror. (TJ22395)
- Paint & Coatings
- Parking Brake System
- Passive Restraints
- Procedures
- Vehicle/Connectivity Report Checklist (TJ 37175.1.1)
- Data Requests From Lea (Police) And/Or Customers (TJ 28941.5.0)
- Newsletter 112: Mandatory Tools (ST-255)
- VOLVO Wheel Repair Guidelines (SMB77-008)
- High Voltage (HV) Module Balancer Cart (ST-251)
- VIDA Updated Graphical Plotter Functionality Applications - VIDA (SJ1000785)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Method For Interior Cleaning (Information Only) (TJ 35475.1.2)
- Newsletter 105: Mandatory Tools (ST-237)
- Recall Compliance Clearance Letter Requests (SMB00-440)
- GDPR - Information Notice (SPJ34864.2.0)
- Not Possible To Left Click Ecus In The Network Image For Non-Spa Cars (US34753.1.0 EN-US)
- Software Installation Policy (SMB00-006C)
- Configuration Test Software (TJ 33057.1.1)
- P3 Software Download Guide (TJ32688.1.1)
- Rear Suspension
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Knocking Noise From Rear Suspension, Loose Spring Aid In Upper Spring Seat (TJ23844.6.0)
- Knocking/Rumbling Noise From Rear Suspension, Upper Spring Seat To Body (TJ20251)
- XC60 Rear Shock Absorber, Loose Top-Mount Causing Knocking Noise (TJ27201)
- Knocking Noise From Rear Suspension, Loose Spring Aid In Upper Spring Seat (RTJ 23844)
- Restraints Control Systems
- Control Module Swapping (TJ 31946.1.2)
- VOLVO Service 2.0 (SMB39-013)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- Noise From CLOCKSPRING Area (TJ27905)
- New Logic On Seat Belt Reminder After Software Upgrade (TJ26361)
- Dim Speaker Does Not Work (TJ25164)
- DTCS CVM-U300000, SRS-U043300 And CEM-U043300 (TJ25146)
- CEM Recovery- Interrupt Of SW Download. (RTJ 14902)
- "Airbag System Service Required" Message In Dim, DTC SRS-B00021A (TJ22855)
- "Airbag System Service Required" Message In Dim, DTC SRS-B00021A (RTJ 22855)
- VIDA Upcoming Technology (SMB00-290)
- CANBUS Network Information (RTJ 16386)
- Schedule
- Seats
- Interior Seat Protection Kit (SMB85-002)
- Seat Belt Catch, Foreign Objects (TJ19383.8.0)
- Allocation For Seat Belt Recall (PB88-R10029)
- P3 Front Seat Backrest, Too Much Play (TJ 32509.1.0)
- Knocking/Rumbling Noise From Rear Suspension, Upper Spring Seat To Body (TJ20251)
- Seat Memory Position 3 Lost Or Changed, Power Seat Module, PSM (TJ23715)
- Seat Upholstery, Vinyl Parts May Crack (TJ26206)
- VOLVO Accessory Rear Seat Entertainment (SMB39-008)
- IBC (Integrated Booster Cushion) Upholstery May Crack (RTJ 22448)
- Leather Upholstery Care (RTJ 24661)
- Accessory RSE (HEADRESTRAINT DVD) Warranty Coverage And Claim Procedure (SMB39-005)
- Feature Operation, Demonstration And Customer Satisfaction (SMB17-015)
- Starter
- RDAR Replacement (Satellite Radio Tuner), Battery Drain (TJ26188.1.12)
- Modification When Replacing Start/Stop Button (TJ27113)
- Importance Of Vehicle In Stock Battery Maintenance (SMB17-2013)
- Prior Approval For RDAR Replacement (SMB39-001)
- Spare Part Battery Date Codes (SMB31-003)
- Spare Part Battery Date Codes (TJ25935)
- Battery Current Consumption And RDAR (TJ25590)
- Reduced Alternator Performance Due To Incorrect Installation Of Accessories (RTJ 24495)
- Pre Delivery Service (PDS) Checklist, Temporary Addition (RTJ 24409)
- Safety Precautions When Working With Lead Acid Batteries (RTJ 24188)
- Too High Quiescent Current May Drain The Battery (RTJ 23515)
- All New S60: Incorrect Power Supply Connection Causing SWDL Problems (RTJ 23623)
- Steering Column
- Interior Seat Protection Kit (SMB85-002)
- Steering Wheel, Clicking Noise (TJ 36170.1.0)
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- VOLVO Logo On Steering Wheel, Replacement (TJ31750.3.0)
- Airbag Unit/Steering Wheel, Creaking Noise (TJ 27799)
- Noise From CLOCKSPRING Area (TJ27905)
- Steering Control Systems
- Steering Gear
- Mandatory VOLVO Special Tool List (ST-001-2020)
- Mandatory VOLVO Special Tool List (ST-001-2021)
- Oil Leakage Into The Bellows, Standard Steering Gear (TJ15636)
- O-Rings Available As Spare Parts; Steering Gear (TJ30813)
- Squeaking Noise From Standard Steering Gear While Turning Steering Wheel (TJ22117)
- Steering Gear Extended Warranty (SMB64-230)
- Updated Procedure, Steering Gear (Rack) Replacement (TJ23271)
- Standard Steering Gear, Squeaking Noise (RTJ 18943)
- Retailer Technical Journal 21474 Power Steering System Layout, Numbering Of Connection Points (TJ21474)
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- SW Part Numbers For Total Upgrade And PDS (TJ 27536.21.1)
- Control Module Swapping (TJ 31946.1.2)
- VOLVO Service 2.0 (SMB39-013)
- Anti-Tamper Device, Communication Lost (TJ27910)
- Content Of EUPDATES Associated With VIDA 2014D (SPJ28541)
- Polestar Calibration Identification (TJ29552)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Check Engine Light Due To Purge Valve Leakage (TJ28228)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- Long Cranking Time. Fuel Pump Triple Valve (TJ27217)
- VOLVO Service For Life: Complimentary SW Updates (RTJ 23940)
- HS Can Faults, Water In EHPAS Unit (PSCM) (RTJ 24849)
- E10 Petrol Fuel Requirements (RTJ 24461)
- CCM U040168 Posted For Incorrect Reason (RTJ 24545)
- CEM Recovery- Interrupt Of SW Download. (RTJ 14902)
- Usage Of Reload Software (TJ23502)
- Total Upgrade Most For All New S60 And XC60 Blocked (TJ23106)
- Service Action 223 Dim Message "Soot Filter Full" Shown On Petrol Cars (TJ22151)
- CANBUS Network Information (RTJ 16386)
- Towing
- Towing Systems
- Transfer Case
- Transmission Control Systems
- Control Module Swapping (TJ 31946.1.2)
- TF80/Rough Shift N-D And/Or 5-4 (TJ32169.9.0)
- VOLVO Service 2.0 (SMB39-013)
- Aw TF80SC: Rough Shifts, 5-4 Downshift, Neutral Control, N-D And/Or DTC P089500 (TJ26840)
- Aw TF80 SC - Hard 6-5 And/Or 2-1 Downshift Or No Upshift (TJ29050)
- Newsletter 59: Mandatory Tools (ST-205)
- Acc Disabled During Queue Assist (TJ27229)
- VIDA License Agreement And Unauthorized Software (SMB00-332)
- Harsh 1-2 Up Shift TF80SC (TJ28959)
- Vantage Pro Oscilloscope Update - 13.4 Software Release Supersedes The March 21, 2013 Edition (ST-150A)
- SENSUS Connected Touch (SCT) ACU Upgrade Procedure (TJ28184)
- Differential Electronic Module (DEM) Software (SW) (TJ20756)
- New Generation Automatic Transmission TF80, Policy For Transmission Repairs (SMB40-001)
- Transmission Control Module (TCM) Software (SW) (TJ16761)
- VOLVO Service For Life: Complimentary SW Updates (RTJ 23940)
- CEM Recovery- Interrupt Of SW Download. (RTJ 14902)
- Usage Of Reload Software (TJ23502)
- VIDA Upcoming Technology (SMB00-290)
- CANBUS Network Information (RTJ 16386)
- Warning Systems
- Parking Assist Camera (PAC), Flickering Video Signal In Display (TJ27989)
- No Image From PAC Camera When Engaging Reverse Gear (TJ28309)
- New Logic On Seat Belt Reminder After Software Upgrade (TJ26361)
- Parking Assist Camera (PAC) Does Not Work - Deformed Or Blank Picture (TJ25170)
- Dim Speaker Does Not Work (TJ25164)
- Pedestrian Detection With Full Auto Brake Demonstration (SMB17-014)
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Center Wheel Caps, Removal Instruction (TJ 28739.3.0)
- VOLVO Wheel Repair Guidelines (SMB77-008)
- Winter Wheel Applications (PB77-006)
- Noise Front Wheel Hub And/Or DTC In BCM (TJ25329)
- Wheel Cross Reference (PB77-017)
- VOLVO Recommended Winter Tires (77-013)
- Tire Rotation (SMB77-007)
- TPMS Sensor Nut Corrosion (TJ24767)
- P3 TPMS, DTCS For All Four Missing Sensors (RTJ 24648)
- Window Motors & Regulators
- Wiper/Washer Systems
- Washer System Layout For Identifying Leakage Points (TJ25153.7.3)
- VOLVO Wiper Blade Warranty Replacement Policy (SMB00-425)
- Windscreen Washer Nozzle - Poor/No Performance In Cold Weather (TJ29261)
- Service Position Windscreen Wipers, Functionality Not According To Owners Manual (TJ23918)
- The VOLVO Safe + Secure Coverage Plan 555FSMW, 555WTY, 555PFMW, 555PWTY, 336FSMW & 448FSMW My2009 - My2011 Vehicles (SMB00-278)
- Service Campaign 236: Washer Reservoir Level Sensor (SMB36-236)
- Service Campaign 236 - Washer Reservoir Level Sensor INOP (RTJ 24659)
- Wiring Diagrams
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)