LEMON Manuals: Even more car manuals for everyone
Home >> Volkswagen >> 2012 >> Golf TDI, 2D Hatchback, Standard Trans >> Repair and Diagnosis >> Quick Lookups >> Common Specs & Procedures >> Specifications Index

Specifications Index

SPECIFICATIONS INDEX

System Specification/Procedure
Air Conditioning
Service CAPACITIES
Torque FASTENER TIGHTENING SPECIFICATIONS
Axle Nut/Hub Nut
Front 70 Nm + 90° turn
Rear 180 Nm + 180° turn
Battery GENERAL INFORMATION
Brakes
Bleeding Sequence BRAKE SYSTEM, BLEEDING
Disc Brakes FRONT BRAKES

REAR BRAKES, C 38

Torque FRONT BRAKES ASSEMBLY OVERVIEW, FN3
FRONT BRAKES OVERVIEW, FNR-G
REAR BRAKES ASSEMBLY OVERVIEW, C 38
REAR BRAKES ASSEMBLY OVERVIEW, BOSCH
REAR BRAKES OVERVIEW, CII 41
Charging
Generator DESCRIPTION AND OPERATION N/A
Torque

FASTENER TIGHTENING SPECIFICATIONS

Drive Belts
Adjustment
2.0L RIBBED BELT (WITH TENSIONING ROLLER)
2.5L RIBBED BELT
Belt Routing
2.0L See the figure under RIBBED BELT (WITH TENSIONER)
2.5L See the figure under RIBBED BELT OVERVIEW
Engine Cooling
General Service Specifications Refer to the appropriate MAINTENANCE, DIAGNOSIS - FLUID CAPACITY TABLES information.
Radiator Cap Pressure
2.0L 1.4 Bar
2.5L 1.4-1.6 Bar
Thermostat R & I
2.0L COOLANT THERMOSTAT
2.5L COOLANT THERMOSTAT
Water Pump R & I
2.0L COOLANT PUMP
2.5L COOLANT PUMP
Engine Mechanical
2.0L
Compression COMPRESSION TEST
Oil Pressure Increase the engine speed further. At 2000 RPM and with the oil temperature at 80°C (176°F), the oil pressure must be a minimum 2.0 bar.

At higher engine speeds, the oil pressure must not exceed 7.0 bar. If necessary, replace the oil filter bracket.

Overhaul 10 ENGINE ASSEMBLY
Torque FASTENER TIGHTENING SPECIFICATIONS
2.5L
Compression COMPRESSION PRESSURE, CHECKING
Oil Pressure -- Start the engine and increase the engine speed: The LED must illuminate at 1.2 to 1.6 bar. Replace the oil pressure switch if it does not.
-- Increase the engine speed further. At 2000 RPM and an oil temperature of 80°C (176°F), the oil pressure must be between 2.7 and 4.5 bar.
At higher engine speeds the oil pressure must not exceed 7.0 bar
Overhaul 10 ENGINE ASSEMBLY
Torque FASTENER TIGHTENING SPECIFICATIONS
Fluid Specifications See FLUIDS under MAINTENANCE tab.
Flywheel/Flex Plate Torque 60 Nm + an additional 90° (1/4) turn.
Fuel System
Pressure Specification
2.0L at least 3.5 bar
2.5L The fuel pressure in the high pressure pipe can be up to 120 bar
Fuel Pressure Test Procedure
2.0L FUEL PRESSURE REGULATOR VALVE, CHECKING
2.5L FUEL PUMP PRESSURE, CHECKING
Ignition
Firing Order & Cylinder Identification
FIRING ORDER & CYLINDER IDENTIFICATION
Ignition Wires (Resistance) Coil-On-Plug
Ignition Wires (Routing) Coil-On-Plug
Spark Plug
2.0L Glow Plugs
2.5L TEST DATA AND SPARK PLUGS
Starting
Starter STARTER, CHECKING
Torque FASTENER TIGHTENING SPECIFICATIONS
Wheel Alignment
Adjustment Specifications WHEEL ALIGNMENT SPECIFIED VALUES
Torque N/A
Wheel & Tire
Wheel Lug Nut Torque 120 Nm