Common Specs & Procedures
AVALON COMMON SPECS & PROCEDURES
| System | Specification/Procedure | ||
|---|---|---|---|
| Air Conditioning | |||
| Service | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Axle Nut/Hub Nut | |||
| Front | 294 N.m (217 ft lbs) | ||
| Rear | 80 N.m (59 ft.lbf) | ||
| Battery | N/A | ||
| Brakes | |||
| Bleeding Sequence | BLEEDING | ||
| Disc/Drum Brakes | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Charging | |||
| Generator | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Drive Belts | |||
| Adjustment | INSPECTION | ||
| Belt Routing | See "Identifying Drive Belt Routing And Pulleys" under INSTALLATION | ||
| Engine Cooling | |||
| General Service Specifications | SERVICE DATA | ||
| Radiator Cap Pressure | 69.0 to 112.8 kPa (0.70 to 1.15 kgf/cm2 , 10.0 to 16.4 psi) | ||
| Thermostat R & I | THERMOSTAT | ||
| Water Pump R & I | WATER PUMP | ||
| Engine Mechanical | |||
| (2GR-FE) | |||
| Compression | SERVICE DATA | ||
| Oil Pressure | at idle, 80 kPa (0.8 kgf.cm2
, 11.6 psi) or more at 6, 000 RPM, 380 kPa (3.9 kgf.cm2 , 55.5 psi) |
||
| Overhaul | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. | ||
| Flywheel/Flex Plate (Drive Plate) Torque | 83 N.m (850 kgf.cm, 61 ft lbs) | ||
| Fuel System | |||
| Pressure Specification | @ Idle: 304 to 343 kPa (3.1 to 3.5 kgf/cm2
, 44.1 to 49.7 psi) 5 Min After Eng Stops: 147 kPa (1.5 kgf/cm2 , 21 psi) or more |
||
| Fuel Pressure Test Procedure | ON-VEHICLE INSPECTION | ||
| Fuel Filter Location | FUEL PUMP | ||
| Ignition | |||
| Firing Order & Cylinder Identification | |||
| 2GR-FE | FIRING ORDER & CYLINDER IDENTIFICATION |
||
| Spark Plug | |||
| Type | DENSO FK20HR11 | ||
| Gap | 1.0 to 1.1 mm (0.039 to 0.043 in.) | ||
| Torque | 18 N.m (184 kgf.cm, 13 ft. lbs) | ||
| Starting | |||
| Starter | SERVICE DATA | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Wheel Alignment | |||
| Front | |||
| Adjustment Specifications | FRONT WHEEL ALIGNMENT | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Rear | |||
| Adjustment Specifications | REAR WHEEL ALIGNMENT | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Wheel & Tire | |||
| Wheel Lug Nut Torque | 103 N.m (1, 050 kgf.cm, 76 ft lbs.) | ||