Data List / Active Test
- DATA LIST
HINT:
With the intelligent tester connected to the DLC3 and the ignition switch in the ON position, the ABS, TRAC and VSC data list can be displayed. Follow the prompts on the tester screen to access the DATA LIST.
ITEM DIAGNOSTIC NOTEItem Measurement Item / Range (Display) Normal Condition Diagnostic Note ABS MOT RELAY ABS motor relay / ON or OFF ON : Motor relay ON
OFF : Motor relay OFF- SOL RELAY Solenoid relay / ON or OFF ON : Solenoid relay ON
OFF : Solenoid relay OFF- VSC / TRC OFF SW TRAC control switch / ON or OFF ON : TRAC control switch ON
OFF : TRAC control switch OFF- AIR BLD SUPPORT Air bleed support / ON or OFF ON : Support ON
OFF: Support OFF- IDLE SW Main idle switch / ON or OFF ON : Accelerator pedal released
OFF: Accelerator pedal depressed- STOP LIGHT SW Stop light switch / ON or OFF ON : Brake pedal depressed
OFF : Brake pedal released- PKB SW Parking brake switch / ON or OFF ON : Parking brake applied
OFF : Parking brake released- ABS OPERT FR ABS operation (FR) / BEFORE or OPERATE BEFORE : No ABS operation (FR)
OPERATE : During ABS operation (FR)- ABS OPERT FL ABS operation (FL) / BEFORE or OPERATE BEFORE : No ABS operation (FL)
OPERATE : During ABS operation (FL)- ABS OPERT RR ABS operation (RR) / BEFORE or OPERATE BEFORE : No ABS operation (RR)
OPERATE : During ABS operation (RR)- ABS OPERT RL ABS operation (RL) / BEFORE or OPERATE BEFORE : No ABS operation (RL)
OPERATE : During ABS operation (RL)- WHEEL SPDFR Wheel speed sensor (FR) reading / min.: 0 km/h (0 MPH), max.: 326 km/h (202 MPH) Actual wheel speed Similar speed as indicated on speedometer WHEEL SPD FL Wheel speed sensor (FL) reading / min.: 0 km/h (0 MPH), max.: 326 km/h (202 MPH) Actual wheel speed Similar speed as indicated on speedometer WHEEL SPD RR Wheel speed sensor (RR) reading / min.: 0 km/h (0 MPH), max.: 326 km/h (202 MPH) Actual wheel speed Similar speed as indicated on speedometer WHEEL SPD RL Wheel speed sensor (RL) reading / min.: 0 km/h (0 MPH), max.: 326 km/h (202 MPH) Actual wheel speed Similar speed as indicated on speedometer DECELERAT SENS Acceleration sensor 1 reading / min.: -1.869 G, max.: 1.869 G Approximately 0 +- 0.13 G at still condition Reading changes when vehicle is bounced DECELERAT SENS2 Acceleration sensor 2 reading / min.: -1.869 G, max.: 1.869 G Approximately 0 +- 0.13 G at still condition Reading changes when vehicle is bounced IG VOLTAGE ECU power supply voltage / TOO LOW / NORMAL / TOO HIGH TOO LOW : 9.5 V or less NORMAL: 9.5 to 14.0 V TOO HIGH :14.0 V or more - SFRR ABS solenoid (SFRR) / ON or OFF ON : Operated
OFF: Not operated- SFRH ABS solenoid (SFRH) / ON or OFF ON : Operated
OFF: Not operated- SFLR ABS solenoid (SFLR) / ON or OFF ON : Operated
OFF : Not operated- SFLH ABS solenoid (SFLH) / ON or OFF ON : Operated
OFF : Not operated- SRRR (SRR) ABS solenoid (SRRR (SRR)) / ON or OFF ON : Operated
OFF : Not operated- SRRH (SRH) ABS solenoid (SRRH (SRH)) / ON or OFF ON : Operated
OFF: Not operated- SRLR ABS solenoid (SRLR) / ON or OFF ON : Operated
OFF: Not operated- SRLH ABS solenoid (SRLH) / ON or OFF ON : Operated
OFF : Not operated- SMF (BA-SOL) TRAC solenoid (SMF) / ON or OFF ON : Operated
OFF : Not operated- SMR TRAC solenoid (SMR) / ON or OFF ON : Operated
OFF : Not operated- THROTTLE Throttle position sensor / min.: 0 deg, max.: 125 deg Release accelerator pedal:
Approx. 0 deg.
Depress accelerator pedal:
Approx. 90 deg.- ENGINE SPD Engine Speed / min.: 0 rpm, max.: 6000 rpm Actual engine speed - VEHICLE SPD Maximum wheel speed sensor reading / min.: 0 km/h (0 MPH), max.: 326 km/h (202 MPH) Actual vehicle speed Speed indicated on speedometer YAW RATE Yaw rate sensor / min.: -128 deg/ s, max.: 127deg/s min.: -128 deg/s max.: 127 deg/s - YAW ZERO VALUE Memorized zero value / min.: -128 deg/s, max.: 127 deg/s min.:-128 deg/s max.: 127 deg/s - STEERING ANG Steering angle sensor / min.: -1152 deg, max.: 1150.875 deg Left turn: Increase Right turn: Decrease - MAS CYL PRS 1 Master cylinder pressure sensor 1 reading / min.: 0 V, max.: 5 V When brake pedal is released : 0.3 to 0.9 V Reading increases when brake pedal is depressed TEST MODE Test mode / NORMAL or TEST NORMAL: Normal mode TEST : During test mode - SPD SEN FR FR speed sensor open detection / OPEN or NORMAL OPEN : Momentary interruption - SPD SEN FL FL speed sensor open detection / OPEN or NORMAL OPEN : Momentary interruption - SPD SEN RR RR speed sensor open detection / OPEN or NORMAL OPEN : Momentary interruption - SPD SEN RL RL speed sensor open detection / OPEN or NORMAL OPEN : Momentary interruption - YAW RATE SEN Yaw rate sensor open detection OPEN : Momentary interruption - DECELE SEN G sensor open detection OPEN : Momentary interruption - STEERING SEN Steering angle sensor open detection OPEN : Momentary interruption - M/C SEN 1 Master Cylinder pressure sensor 1 open detection OPEN : Momentary interruption - EFI COM EFI communication open detection OPEN : Momentary interruption - - ACTIVE TEST
HINT:
Performing the ACTIVE TEST using the intelligent tester allows the relay, actuator, etc. to operate without removing any parts. Performing the ACTIVE TEST as the first step of troubleshooting is one of the methods to shorten labor time.
It is possible to display the DATA LIST during the ACTIVE TEST.
- Connect the intelligent tester to the DLC3.
- Turn the ignition switch to the ON position.
- According to the display on the tester, perform the ACTIVE TEST.
HINT:
Ignition switch must be turned to the ON position to proceed to the ACTIVE TEST using the intelligent tester.
ITEM DIAGNOSTIC NOTE
| Item | Vehicle Condition / Test Details | Diagnostic Note |
|---|---|---|
| SFRR | Turns ABS solenoid (SFRR) ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SFRH | Turns ABS solenoid (SFRH) ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SFLR | Turns ABS solenoid (SFLR) ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SFLH | Turns ABS solenoid (SFLH) ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SRRR | Turns ABS solenoid (SRRR) ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SRRH | Turns ABS solenoid (SRRH) ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SRLR | Turns ABS solenoid (SRLR) ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SRLH | Turns ABS solenoid (SRLH) ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SMF (BA-SOL) | Turns TRAC solenoid SMF (BA-SOL) ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SMR | Turns TRAC solenoid SMR ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SOL RELAY | Turns ABS solenoid relay ON / OFF | Operation of solenoid (clicking sound) can be heard |
| ABS MOT RELAY | Turns ABS motor relay ON / OFF | Operation of motor (clicking sound) can be heard |
| ABS WARN LIGHT | Turns ABS warning light ON / OFF | Observe combination meter |
| VSC WARN LIGHT | Turns VSC warning light ON / OFF | Observe combination meter |
| VSC / TRC OFF IND | turns VSC / TRAC OFF indicator ON / OFF | Observe combination meter |
| SLIP INDI LIGHT | Turns SLIP indicator light ON / OFF | Observe combination meter |
| BRAKE WRN LIGHT | Turns BRAKE warning light ON / OFF | Observe combination meter |
| VSC / BR WARN BUZ | Turns VSC / BRAKE warning buzzer ON / OFF | Buzzer can be heard |
| SFRR & SFRH | Turns ABS solenoid SFRR and SFRH ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SFLR & SFLH | Turns ABS solenoid SFLR and SFLH ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SRH & SRR | Turns ABS solenoid SRH and SRR ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SRLR &SRLH | Turns ABS solenoid SRLR and SRLH ON / OFF | Operation of solenoid (clicking sound) can be heard |
| SFRH & SFLH | Turns ABS solenoid SFRH and SFLH ON / OFF | Operation of solenoid (clicking sound) can be heard |