Fuel Pump: Removal
- PREVENT GASOLINE FROM SPILLING OUT
- DISCONNECT BATTERY NEGATIVE TERMINAL
- REMOVE REAR SEAT CUSHION ASSEMBLY (See
REMOVAL
)
- REMOVE REAR FLOOR SERVICE HOLE COVER
- Remove the rear floor service hole cover.
- Disconnect the fuel pump connector.
Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
- SEPARATE FUEL PUMP TUBE SUB-ASSEMBLY
- Remove the tube joint clip, and pull out the fuel pump tube.
NOTE:
- Check that there is no dirt around the fuel tube joint before this work and clean the dirt away.
- Be careful of dirt like mud because the fuel tube joint has O-rings to seal the fuel tube connector and fuel suction plate.
- Do not use any tools in this work.
- Do not bend or twist the nylon tube by force.
- After disconnecting, cover the fuel tube joint with a plastic bag.
- When the fuel tube joint and fuel suction plate are stuck, pinch the fuel tank tube between fingers, and turn it carefully to release. Disconnect the fuel tank tube.
Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
- REMOVE FUEL TANK VENT TUBE SET PLATE
- Remove the 8 bolts and set plate.
Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
- REMOVE FUEL SUCTION TUBE ASSEMBLY WITH PUMP AND GAUGE
- Pull out the fuel suction tube from the fuel tank.
Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
NOTE:
- Do not damage the fuel pump filter.
- Be careful that the arm of the sender gauge should not bend.
- Remove the gasket from the fuel suction tube.