LEMON Manuals: Even more car manuals for everyone
Home >> Tesla >> 2022 >> Model X Base >> Repair and Diagnosis >> Steering >> Steering Control Systems >> Steering -- Model X >> Upper Column, Steering Wheel >> Steering Column - Remove And Replace >> Install

Steering Column - Remove And Replace: Install

  1. Transfer the lower steering column shroud datum to the new steering column.
    G15411162Courtesy of TESLA, INC.
    G15411163Courtesy of TESLA, INC.
  2. Install the nuts (x4) that attach the steering column to the IP carrier.

    15 N.m (11.1 ft-lbs) 

    Tip: Use of the following tool(s) is recommended:

    • 13 mm socket
    NOTE: Guide the lower steering shaft down through the bulkhead.
    G15411164Courtesy of TESLA, INC.
    G15411165Courtesy of TESLA, INC.
    G15411166Courtesy of TESLA, INC.
  3. Connect the steering column electrical harness connector, and then secure the harness with clip.
    G15411167Courtesy of TESLA, INC.
    G15411168Courtesy of TESLA, INC.
  4. Secure the steering intermediate shaft dash boot.
    NOTE: Ensure the boot is flush with the dash panel.
    G15411169Courtesy of TESLA, INC.
    G15411170Courtesy of TESLA, INC.
  5. Raise the vehicle to a comfortable working height.
  6. Slide the lower steering column shaft onto the steering rack, and then secure it with bolt.

    30 N.m (22.1 ft-lbs) 

    Tip: Use of the following tool(s) is recommended:

    • 13 mm socket
    G15411171Courtesy of TESLA, INC.
    G15411172Courtesy of TESLA, INC.
  7. Install the front skidplate. See Skidplate - Front (Remove and Replace) .
  8. Install the front aero shield panel. See Panel - Aero Shield - Front (Remove and Replace) .
  9. Lower the vehicle until the tires are touching the ground.
  10. Install the lower instrument panel. See Instrument Panel - Lower (Remove and Replace) .
  11. Install the steering column control module. See MODULE - STEERING COLUMN CONTROL (REMOVE AND REPLACE) .
  12. Install the steering column lower shroud. See SHROUD - LOWER - STEERING COLUMN (REMOVE AND REPLACE) .
  13. Install the steering column upper shroud. See Shroud - Upper - Steering Column (Remove and Replace) .
  14. Install the driver knee airbag. See Knee Airbag - Driver (Remove and Replace) .
  15. Install the LH center console side panel carpet. See Carpet - Side Panel - Center Console - LH (Remove and Replace) .
  16. Install the driver inboard footwell cover. See Cover - Footwell - Inboard - Driver (Remove and Replace) .
  17. Install the driver outboard footwell cover. See Cover - Footwell - Outboard - Driver (Remove and Replace) .
  18. Install the driver floor mat.
  19. Install the steering yoke/wheel. See Steering Yoke/Wheel (Remove And Replace) .
  20. Install the driver airbag. See Airbag - Driver (Remove and Replace) .
  21. Install the main instrument panel decor. See Decor - Instrument Panel - Main (Remove and Replace) .
  22. Install the glove box. See Glove Box (Remove and Replace) .
  23. Install the front passenger knee airbag. See Knee Airbag - Front Passenger (Remove and Replace) .
  24. Install the RH center console side panel carpet. See Carpet - Side Panel - Center Console - LH (Remove and Replace) .
  25. Install the front passenger footwell cover. See Cover - Footwell - Passenger (Remove and Replace) .
  26. Install the RH lower A-pillar trim. See Trim - A-Pillar - Lower - LH (Remove and Replace) .
  27. Install the RH middle A-pillar trim. See Trim - A-Pillar - Middle - LH (Remove and Replace) .
  28. Install the RH instrument panel end cap. See End Cap - Instrument Panel - LH (Remove and Replace) .
  29. Install the RH front sill panel trim. See Trim - Sill Panel - Front - LH (Remove and Replace) .
  30. Install the front passenger floor mat.
  31. Install the RH instrument panel middle trim. See Trim - Middle - Instrument Panel - RH (Remove and Replace) .
  32. Fasten the tabs (x4) that attach the IP closeout panel.
    G15411173Courtesy of TESLA, INC.
    G15411174Courtesy of TESLA, INC.
    G15411175Courtesy of TESLA, INC.
  33. Install the touchscreen. See Touchscreen - Rear (Remove and Replace) .
  34. Install the instrument panel service panel. See Service Panel - Instrument Panel (Remove and Replace) .
  35. Install the center console phone dock. See Phone Dock - Center Console (Remove and Replace) .
  36. Reconnect LV power. See LV Power (Disconnect and Connect) .
  37. Install the rear underhood apron. See Underhood Apron - Rear (Remove and Replace) .
  38. Restore the front passenger seat back to its original position.
  39. Calibrate the RH rear door by holding the upper B-pillar button in the down position.
    G15411176Courtesy of TESLA, INC.
  40. Install the LH instrument panel middle trim. See Trim - Middle - Instrument Panel - LH (Remove and Replace) .
  41. Install LH lower A-pillar trim. See Trim - A-Pillar - Lower - LH (Remove and Replace) .
  42. Install the LH front sill panel trim. See Trim - Sill Panel - Front - LH (Remove and Replace) .
  43. Install the LH middle A-pillar trim. See Trim - A-Pillar - Middle - LH (Remove and Replace) .
  44. Install the LH instrument panel end cap. See End Cap - Instrument Panel - LH (Remove and Replace) .
  45. Restore the driver seat back to its original position.
  46. Calibrate the LH rear door by holding the upper B-pillar button in the down position.
    G15411177Courtesy of TESLA, INC.
  47. Connect a laptop with Toolbox 3 to be vehicle. See Toolbox 3 (Connect and Disconnect) .
  48. In Toolbox, click the Actions  tab, and then search for STEERING  .
  49. Click STEERING COLUMN CALIBRATION  , and then click Run  . Allow the routine to complete before continuing to the next step.
    NOTE: Click X  at top right of the window to close once complete.
    NOTE: Steering column will run through the full range of motion up/down and in/out during calibration.
    G15411178Courtesy of TESLA, INC.
    G15411179Courtesy of TESLA, INC.
    G15411180Courtesy of TESLA, INC.
    G15411181Courtesy of TESLA, INC.
  50. Disconnect the laptop with Toolbox 3 from be vehicle. See Toolbox 3 (Connect and Disconnect) .
  51. Adjust the steering column back to its original position.
  52. Remove the vehicle from the lift.
  53. Raise the LH and RH front windows.
  54. Close the LH front door.
scientia non olet · About LEMON Manuals