Automatic Transmission
- Precautions
- General Description
- Schematic and Routing Diagram
- Component Location
- Diagnostic Information and Procedures
- A/T System Check
- Notes
- Step 1. Customer Complaint Analysis
- Step 2. DTC / Freeze Frame Data Check, Record and Clearance
- Step 3 and 4. Visual Inspection
- Step 5. Trouble Symptom Confirmation
- Step 6 and 7. Rechecking and Record of DTC
- Step 8. A/T Basic Check and A/T Symptom Diagnosis
- Step 9. Troubleshooting for DTC
- Step 10. Check for Intermittent Problem
- Step 11. Final Confirmation Test
- Visual Inspection
- Malfunction Indicator Lamp (MIL) Check
- "O/D OFF" Lamp Check
- DTC Table
- DTC Check
- DTC Clearance
- Fail Safe Table
- Scan Tool Data
- Notes
- Scan Tool Data Definitions:
- Engine speed (RPM)
- Notes
- Input shaft rev (Input shaft revolution, RPM)
- Output shaft rev (Output shaft revolution, RPM)
- Battery volt. (Battery voltage, V)
- ATF temp. (ATF temperature, °C, °F)
- Shift sol #1 COM/MON (Shift solenoid-A (No. 1) command/monitor, ON/OFF)
- Shift sol #2 COM/MON (Shift solenoid-B (No. 2) command/monitor, ON/OFF)
- TCC sol COM/MON (TCC solenoid command/monitor, ON/OFF)
- Press cont sol (Pressure control solenoid, %)
- Vehicle speed (kph / mph)
- O/D off switch (ON / OFF)
- Trans. range (P/R/N/D/2/L)
- D range signal (P/N range / D range)
- Throttle position (Throttle position, %)
- Brake switch (ON / OFF)
- Torq reduction sig (Torque reduction signal, ON / OFF)
- Coolant temp. (°C, °F)
- A/C switch
- Engine torque (N.m)
- Cruise control sw
- A/T Basic Check
- Road Test
- Manual Road Test
- Stall Test
- Time Lag Test
- Line Pressure Test
- Engine Brake Test
- "P" Range Test
- A/T Symptom Diagnosis
- No Gear Shift to O/D
- No Lock-Up Occurs
- DTC P0705 (No. 34): Transmission Range Sensor Circuit Malfunction
- DTC P0707 (No. 34): Transmission Range Sensor Circuit Low
- DTC P0712 (No. 38): Transmission Fluid Temperature Sensor Circuit Low
- DTC P0713 (No. 36): Transmission Fluid Temperature Sensor Circuit High
- DTC P0717 (No. 37): Input / Turbine Speed Sensor Circuit No Signal
- DTC P0722 (No. 31): Output Speed Sensor Circuit No Signal
- DTC P0727 (No. 35): Engine Speed Input Circuit No Signal
- DTC P0741 / P0742 (No. 29): TCC Circuit Performance or Stuck OFF / Stuck ON
- DTC P0751 / P0752 / P0756 / P0757 (No. 17 / No. 17 / No. 28 / No. 28): Shift Solenoid-A (No. 1) Performance or Stuck OFF / Shift Solenoid-A (No. 1) Stuck ON / Shift Solenoid-B (No 2) Performance or Stuck OFF / Shift Solenoid-B (No. 2) Stuck ON
- DTC P0962 (No. 41): Pressure Control Solenoid Control Circuit Low
- DTC P0963 (No. 42): Pressure Control Solenoid Control Circuit High
- DTC P0973 / P0976 (No. 22 / No. 24): Shift Solenoid-A (No. 1) Control Circuit Low / Shift Solenoid-B (No. 2) Control Circuit Low
- DTC P0974 / P0977 (No. 21 / No. 23): Shift Solenoid-A (No. 1) Control Circuit High / Shift Solenoid-B (No. 2) Control Circuit High
- DTC P1700 (No. 32 / 33): Throttle Position Signal Circuit Malfunction
- DTC P1702 (No. 52): Internal Malfunction of TCM
- DTC P1709 (No. 51): Engine Coolant Temperature and Barometric Pressure Signal Circuit Malfunction
- DTC P1730 (No. 64): Engine Torque Signal Circuit Malfunction
- DTC P1740 (No. 75): Cruise Control Signal Circuit Malfunction
- DTC P1895 (No. 27): Torque Reduction Signal Circuit Malfunction
- DTC P2763 (No. 25): TCC Pressure Control Solenoid Control Circuit High
- DTC P2764 (No. 26): TCC Pressure Control Solenoid Control Circuit Low
- Inspection of TCM and Its Circuits
- TCM Power and Ground Circuit Check
- "O/D OFF" Lamp Circuit Check
- Brake Interlock System Inspection
- A/T System Check
- Repair Instructions
- A/T Fluid Level Check
- A/T Fluid Change
- Select Cable Removal and Installation
- Select Lever Components
- Selector Lever Inspection
- Select Cable Components
- Select Cable Adjustment
- Transmission Range Sensor (Shift Switch) Inspection and Adjustment
- Output Shaft Speed Sensor Removal and Installation
- Output Shaft Speed Sensor Inspection
- Input Shaft Speed Sensor Removal and Installation
- Input Shaft Speed Sensor Inspection
- Transmission Fluid Temperature Sensor Removal and Installation
- Transmission Fluid Temperature Sensor Inspection
- "O/D OFF" Switch Inspection
- Solenoid Valves (Shift Solenoid Valves, TCC Solenoid Valve and Pressure Control Solenoid Valve) Removal and Installation
- Solenoid Valves (Shift Solenoid Valves and TCC Solenoid Valve) Inspection
- Pressure Control Solenoid Valve Inspection
- Transmission Control Module (TCM) Removal and Installation
- Differential Side Oil Seal Replacement
- Shift Lock Solenoid Replacement
- Key Interlock Cable Removal and Installation
- A/T Fluid Cooler Hoses Replacement
- Automatic Transaxle Unit Components
- Automatic Transaxle Unit Dismounting and Remounting
- Automatic Transaxle Assembly Components
- Automatic Transaxle Unit Disassembly
- Oil Pump 2nd Coast Brake and 2nd Brake Components
- 2nd Coast Brake and 2nd Brake Preliminary Check
- Oil Pump, 2nd Coast Brake and 2nd Brake Disassembly and Reassembly
- Oil Pump, 2nd Brake and 2nd Coast Brake Inspection
- One-Way No. 1 Clutch Components
- One-Way No. 1 Clutch Operation Check
- One-Way No. 1 Clutch Disassembly and Reassembly
- One-Way No. 1 Clutch Inspection
- Forward and Direct Clutch Components
- Forward and Direct Clutch Preliminary Check
- Forward and Direct Clutch Disassembly and Reassembly
- Forward and Direct Clutch Inspection
- 1st / Reverse Brake and One-Way No. 2 Clutch Components
- 1st / Reverse Brake and One-Way No. 2 Clutch Operation Check
- 1st / Reverse Brake and One-Way No. 2 Clutch Disassembly and Reassembly
- 1st / Reverse Brake and One-Way No. 2 Clutch Inspection
- Underdrive Clutch and One-Way No. 3 Clutch Components
- Underdrive Clutch and One-Way No. 3 Clutch Preliminary Check
- Underdrive Clutch and One-Way No. 3 Clutch Operation Check
- Underdrive Clutch and One-Way No. 3 Clutch Disassembly and Reassembly
- Underdrive Clutch and One-Way No. 3 Clutch Inspection
- Planetary Gear Components
- Planetary Gear Disassembly and Reassembly
- Planetary Gear Inspection
- Underdrive Brake Components
- Underdrive Brake Disassembly and Reassembly
- Underdrive Brake Inspection
- Reduction Drive Gear Assembly Operation Check
- Underdrive Gear Assembly Components
- Underdrive Gear Preliminary Check
- Valve Body Assembly Components
- Valve Body Assembly Disassembly and Reassembly
- Differential Components
- Differential Preliminary Check
- Differential Gear Assembly Removal and Installation
- Transaxle Rear Cover Components
- Transaxle Rear Cover Disassembly and Reassembly
- Transaxle Rear Cover Inspection
- Automatic Transaxle Unit Assembly
- Specifications
- Special Tools and Equipment