LEMON Manuals: Even more car manuals for everyone
Home >> Saturn >> 2002 >> L100 >> Repair and Diagnosis >> External Pages >> Different car >> Section 267 (HVAC Systems - Automatic) >> Repair Instructions >> Recirculation Actuator Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2003 Saturn LW300, 2003 Saturn LW200, 2003 Saturn L300, and 2003 Saturn L200. However, it is still accessible from the selected car via links, so may be relevant.
  1. Disconnect the negative battery cable. Refer to BATTERY NEGATIVE CABLE DISCONNECT/CONNECT PROCEDURE in Battery.
  2. Remove the I/P compartment. Refer to Compartment Replacement - Instrument Panel (I/P) in Instrument Panel, Gages and Console.
    3. Fig 1: Removing/Installing Right Side Heater Duct Assembly & Retainer
    GM896489Courtesy of GENERAL MOTORS CORP.
  3. Remove the right side heater duct assembly retainer.
  4. Remove the right side heater duct assembly.
    5. Fig 2: Locating Recirculation Actuator Electrical Connector
    GM894265Courtesy of GENERAL MOTORS CORP.
  5. Disconnect the recirculation actuator electrical connector.
    6. Fig 3: Removing & Installing Recirculation Actuator
    GM892697Courtesy of GENERAL MOTORS CORP.
  6. Remove the recirculation actuator bracket screws.
  7. Remove the recirculation actuator assembly from the shaft by pulling the assembly towards the front of the dash.
scientia non olet · About LEMON Manuals