Technical Service Bulletins: Other Variant
WARNING: This page is about the 900 Base, 2D Hatchback, 2.0 D, Automatic, which is a different variant/trim than selected.
- A/C Compressor
- Accessories Control Systems
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- CONV. Top Fabric Wear: New Parts & Adjustment (10/91-0138)
- Alpine Alarm ROM Chip Malfunction: Replacement PROC. (STT 0893-02)
- Electrical System Function Loss: Ignition SW. Mods. (06/93-0355)
- Guard Alarm System Replacement Module (02/92-0190)
- New Rubber Bushings For Convertible Tops (03/91-0098)
- New Door Glass Retaining Clip: Scratch Prevention (06/90-0006)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Trailer Hitch Kit Availability (ACC, SEC. 7, PG. 2)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Revised Power Supply Wiring For Guard Alarm (09/88-1073)
- Fixed Trailer Hitch Installation (11/89-1192)
- Automatic Trans
- Cleaning Oil Cooling System For Automatic Trans. (440-2154)
- 9000 ZF A/T - Clarification Of Dipstick Part Number (TSB 02/22/95)
- Transmission Lubricants - Information (TSB 02/14/95)
- Fluid, Lubricants And Supplies: Reference Chart (10/92-0265)
- Auto Trans (Non-Turbo): Exchange Unit Part No. Ref (10/90-0033, PG. 16)
- Auto Trans (Turbo Eng): Exchange Unit Part No. Ref (10/90-0033, PG. 17)
- Fluid, Lubricants And Supplies Availability (06/89-1149)
- Fluids, Lubricants And Supplies Availability (SP.REF, SEC. 1, PG. 030)
- New CV-Joint Boot Clamps (01/92-0175)
- ZF A/T Testing Tool - Pressure Hose/Gauge (STT 0687-02)
- Auxiliary Emission Control Systems
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- Discontinuation Of Service Fuel Pump Assembly (11/94-0517)
- Exchange Unit Parts: Abs, TCS, ASR, ETS (07/93-0360)
- New Test Cables For The Breakout Box (03/93-0313)
- Idling Increase Malfunction:New Gear Selector Switch (02/93-0306)
- Exchange Air Mass Meters: Part Nos. Cross Reference (10/90-0033, PG. 03)
- EZK Electronic Control Units: Part Nos Reference (10/90-0033, PG. 12)
- LH Fuel Injection Control Units: Parts Ref.Nos (10/90-0033, PG. 04)
- Performance Tuning Kits Availability (ACC, SEC. 4, PG. 4)
- LH 2.4 Ecu Fault Code Retrieval (10/88-1086, PG. 211)
- 2.4L Eng New OXY Sensor - Service Schedule Revision (02/91-0088)
- APC Pressure Transducer Ground Check (STT 0487-16)
- Emission Label Removal Caution (STT 0587-13)
- EZK Ignition Hard Cold Start - New Ground Wire (03/91-0093)
- EZK Ignition System Tester Modification (08/89-1170)
- EZK Ignition Test Socket Caution (STT 0587-14)
- False Mil Intermittent Flashing - EZK Ignition Ecu (10/89-1181)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- New Test Cables For The Breakout Box (03/93-0313)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Trailer Hitch Kit Availability (ACC, SEC. 7, PG. 2)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Automatic Performance Control (APC) - APC Table (04/91-0102)
- Fixed Trailer Hitch Installation (11/89-1192)
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Availability Of Child Tether Anchorages (855-1900)
- Fog Lights: Part Number References (06/90-0003)
- Winter Aids: Various Options Available (ACC, SEC. 6, PG. 1)
- Trailer Hitch Accessories Availability (ACC, SEC. 7, PG. 4)
- Trailer Hitch Kit Availability (ACC, SEC. 7, PG. 2)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Component Locations
- Cooling System (Mechanical)
- Rear Main Seal 4-Cylinder Engine (STT 0594-06)
- Engine Gaskets Replaced By Sealant (02/94-0436)
- Antifreeze/Coolant Part Numbers Reference (ACC, SEC. 20, PG. 1)
- Engine-To-Gearbox Sealing (05/91-0110)
- New Cylinder Head Gaskets (09/87-994)
- Oil Leak - New Timing Chain Cover Gasket (STT 0788-05)
- Turbo/Radiator Inlet Pipe Clamp Removal 7MM Tool (STT 0587-03)
- WALBRO Fuel Pump Noise/Overheat - New Pump Assembly (10/90-0032)
- Cruise Control Systems
- Differentials & Drive Axles
- New Grease For Inboard CV Joint (Tripod) (774-1578)
- New Bolt For The Final Drive (11/94-0516)
- Fluid, Lubricants And Supplies: Reference Chart (10/92-0265)
- New Special Tool For Installing CV-Joint Boot Clamps (01/92-0174)
- Fluid, Lubricants And Supplies Availability (06/89-1149)
- Fluids, Lubricants And Supplies Availability (SP.REF, SEC. 1, PG. 030)
- 5-SPD Pinion Bearing Fitting Ring Tool Modification (04/91-0103)
- New CV-Joint Boot Clamps (01/92-0175)
- Driveshaft & Universal Joints
- Engine Control Systems
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- Discontinuation Of Service Fuel Pump Assembly (11/94-0517)
- Exchange Unit Parts: Abs, TCS, ASR, ETS (07/93-0360)
- New Test Cables For The Breakout Box (03/93-0313)
- Idling Increase Malfunction:New Gear Selector Switch (02/93-0306)
- 2.0L Eng DRIVEABILITY/Stalling - Air Bypass Valve (10/90-0034)
- EZK Electronic Control Units: Part Nos Reference (10/90-0033, PG. 12)
- LH Fuel Injection Control Units: Parts Ref.Nos (10/90-0033, PG. 04)
- Performance Tuning Kits Availability (ACC, SEC. 4, PG. 4)
- LH 2.4 Ecu Fault Code Retrieval (10/88-1086, PG. 211)
- EZK Ignition Hard Cold Start - New Ground Wire (03/91-0093)
- EZK Ignition System Tester Modification (08/89-1170)
- EZK Ignition Test Socket Caution (STT 0587-14)
- False Mil Intermittent Flashing - EZK Ignition Ecu (10/89-1181)
- Idle Speed Adjustment Wrench (06/87-976)
- Entertainment Systems
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Manually Releasing Cd Magazine From Cd Changer (936-1897)
- Open Circuit In Electrically-Heated Rear Window (04/93-0328)
- Clarion Warranty Program On OEM Radios (PARTS, SEC. 7, PG. 6)
- Clarion Radio Volume Control Fault: Power Loss (04/90-1234)
- Trailer Hitch Kit Availability (ACC, SEC. 7, PG. 2)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Fuel System
- Fuses & Circuit Breakers
- Map Light Fuse Blows:Drivers Seat Belt Wiring Check (STT 0793-05)
- Improving Taillight Ground Circuit (10/91-0140)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Clarion Radio Volume Control Fault: Power Loss (04/90-1234)
- Electrical Connector Pin Removal Tool (03/90-1222)
- Trailer Hitch Kit Availability (ACC, SEC. 7, PG. 2)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- A/C Spike SUPRESSION Diode (SP.REF, SEC. 3, PG. 019)
- Fan Doesn't Shut Down\New Standard Fan Relay (06/92-0218)
- Fixed Trailer Hitch Installation (11/89-1192)
- Wiring Defect Between MICROSW. & Recirculating SW. (07/89-1161)
- Gauges & Instrument Panels
- Inaccurate Speed Warning Function: Recalibrated SCC (STT 0893-01)
- Erratic/Inoperative Clock: Rear Foil Contact Check (STT 0793-04)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Trailer Hitch Kit Availability (ACC, SEC. 7, PG. 2)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Fixed Trailer Hitch Installation (11/89-1192)
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- Horns
- HVAC Control Systems
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Spark Plug Reference Table (06/92-0217)
- B202 Eng Ignition Distributors: Part Nos Reference (10/90-0033, PG. 14)
- APC Pressure Transducer Ground Check (STT 0487-16)
- EZK Ignition Hard Cold Start - New Ground Wire (03/91-0093)
- EZK Ignition System Tester Modification (08/89-1170)
- EZK Ignition Test Socket Caution (STT 0587-14)
- False Mil Intermittent Flashing - EZK Ignition Ecu (10/89-1181)
- Hard Cold Weather Start - Service Kit (12/90-0073)
- WALBRO Fuel Pump Noise/Overheat - New Pump Assembly (10/90-0032)
- Infotainment
- Interior/Exterior Trim
- Interior/Illumination Lights
- Lubrication System
- Service Interval Is Determined By Both Distance And Time (100-2490)
- Rear Main Seal 4-Cylinder Engine (STT 0594-06)
- Engine Gaskets Replaced By Sealant (02/94-0436)
- Fluid, Lubricants And Supplies: Reference Chart (10/92-0265)
- Fluid, Lubricants And Supplies Availability (06/89-1149)
- Fluids, Lubricants And Supplies Availability (SP.REF, SEC. 1, PG. 030)
- 16V Eng Excessive Oil Consumption - Sealing Washers (04/88-1047)
- Engine-To-Gearbox Sealing (05/91-0110)
- New Cylinder Head Gaskets (09/87-994)
- Oil Leak - New Timing Chain Cover Gasket (STT 0788-05)
- Oil Pick-Up Pipe Alignment Tool (06/87-974)
- WALBRO Fuel Pump Noise/Overheat - New Pump Assembly (10/90-0032)
- Manual Trans
- Transmission Lubricants - Information (TSB 02/14/95)
- Manual Trans (Non-Turbo): Exchange Unit Part No. Ref (10/90-0033, PG. 21)
- 5-Speed Gearbox - New Synchromesh Parts (12/87-1016)
- Engine-To-Gearbox Sealing (05/91-0110)
- Fuel Pump Line & Gear Selector Adjustment New Tools (10/90-0029)
- M/T New Drive Shafts (05/87-964)
- M/T Sealing - LOCTITE 510 Application (09/89-1172)
- Manual Transmission Oils (STT 0690-11)
- New CV-Joint Boot Clamps (01/92-0175)
- Shaft End-Play Measuring (STT 0288-09)
- Mechanical
- Service Interval Is Determined By Both Distance And Time (100-2490)
- Rear Main Seal 4-Cylinder Engine (STT 0594-06)
- Engine Gaskets Replaced By Sealant (02/94-0436)
- "Hooting" Noise From Engine: New Turbo By-Pass Valve (11/93-0401)
- Camshaft Cover Oil Film Reduction: New Cover Ident. (STT 0893-04)
- Changing Timing Chain: Engine In Vehicle (07/93-0357)
- 16V Eng Excessive Oil Consumption - Sealing Washers (04/88-1047)
- 2.0L Eng Crankshaft - Superseded Part Info/Guide (02/92-0188)
- Crankshaft-Mounted Hall Effect Sensor Diagnosis (08/89-1168)
- Engine-To-Gearbox Sealing (05/91-0110)
- Fuel Pump Line & Gear Selector Adjustment New Tools (10/90-0029)
- Modified Crankshaft Seal Installation Tool (STT 0488-02)
- Motor Mount Noise/Vibration Check (STT 0690-07)
- New Cylinder Head Gaskets (09/87-994)
- Noisy Fuel Pump/Poor Performance - New Service Pump (03/90-1224)
- Oil Leak - New Timing Chain Cover Gasket (STT 0788-05)
- Oil Pick-Up Pipe Alignment Tool (06/87-974)
- Oversized Valve Guide Identification (STT 0987-07)
- Spare Parts Part Numbers For Short Engines (SP.REF, SEC. 2, PG. 141)
- WALBRO Fuel Pump Noise/Overheat - New Pump Assembly (10/90-0032)
- Mechanical - Hydraulic
- Brake Vibration Complaints - New Pads (500-1795)
- Brake Pad Part Supersession Chart (11/94-0519)
- Fluid, Lubricants And Supplies: Reference Chart (10/92-0265)
- New Special Tool: Brake Rotor Measuring Fixture (10/91-0146)
- Front Brake Calipers: Part Numbers Cross Reference (10/90-0033, PG. 25)
- Fluid, Lubricants And Supplies Availability (06/89-1149)
- Fluids, Lubricants And Supplies Availability (SP.REF, SEC. 1, PG. 030)
- Brake Rotor Inspection Procedures (11/89-1190)
- New Type Brake Pad Recommendations (08/90-0017)
- Sticking Handbrake Button - Modify/Replace Lever (10/89-1180)
- Memory Modules
- Mirrors
- Improper Or Poor Window Operation (11/94-0522)
- Checking CONV. Top HYD. Fluid Level: New Procedure (07/89-1156)
- Driver's Side Door Mirror Adjustment (06/91-0120)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Trailer Hitch Kit Availability (ACC, SEC. 7, PG. 2)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Fixed Trailer Hitch Installation (11/89-1192)
- Overdrive Unit
- Paint & Coatings
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- SAAB Paint Colors (890-9049)
- SAAB Paint Colors (890-1807 ED. 4)
- Handling Of ISOCYANATES (101-2056)
- SAAB Touch-Up Paint Reference Table (08/92-0242)
- Water Leak Entry Points Determination (07/91-0125)
- Cross-Reference Paint Codes (09/88-1078)
- Passive Restraints
- Procedures
- Restraints Control Systems
- Schedule
- Seats
- Availability Of Child Tether Anchorages (855-1900)
- Improper Or Poor Window Operation (11/94-0522)
- Checking CONV. Top HYD. Fluid Level: New Procedure (07/89-1156)
- Front Seat Replacement Assemblies (06/91-0123)
- UNDERSEAT Waste Basket Availability (11/90-0067)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Trailer Hitch Kit Availability (ACC, SEC. 7, PG. 2)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Passive Seat Belt System Tester Availability (S.I., SEC. A-1, PG. 137)
- Fixed Trailer Hitch Installation (11/89-1192)
- Protective Front Seat Backrest Cover Availability (08/89-1162)
- Seat Belt System Power Circuit Modification (12/91-0166)
- Starter
- "Hooting" Noise From Engine: New Turbo By-Pass Valve (11/93-0401)
- Starters: Part Numbers Cross Reference (10/90-0033, PG. 11)
- Noisy Fuel Pump/Poor Performance - New Service Pump (03/90-1224)
- Starters Failure - Starter Application Table (07/91-0128)
- WALBRO Fuel Pump Noise/Overheat - New Pump Assembly (10/90-0032)
- Steering Column
- Steering Column Switches
- Steering Control Systems
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- CONV. Top Fabric Wear: New Parts & Adjustment (10/91-0138)
- CONV. Top Water & Wind Leaks: New Procedure (06/93-0350)
- Convertible Rear Spoiler: Microfiche Illustration (01/92-0177)
- New Rubber Bushings For Convertible Tops (03/91-0098)
- Soft Boot Cover Availability (11/90-0058)
- Sunroof Deflector Accessory Parts Availability (ACC, SEC. 8, PG. 1)
- Convertible Top Cover Wear: Adjustment Specification (06/90-0011)
- New Door Glass Retaining Clip: Scratch Prevention (06/90-0006)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Trailer Hitch Kit Availability (ACC, SEC. 7, PG. 2)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Adjustment Of Door Glass (Convertible Models) (07/89-1158)
- Convertible Windshield Adhesive Kit Availability (SP.REF, SEC. 8, PG. 130)
- Fixed Trailer Hitch Installation (11/89-1192)
- Revised Convertible Spacer Pin Tool Availability (07/89-1159)
- Windshield Replacement Procedures:Convertible Models (09/89-1176)
- Suspension Control Systems
- System
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- Discontinuation Of Service Fuel Pump Assembly (11/94-0517)
- Rear Main Seal 4-Cylinder Engine (STT 0594-06)
- Engine Gaskets Replaced By Sealant (02/94-0436)
- Loose Clip On Cruise Control Ball Chain: New Clip (11/93-0411)
- Changing Timing Chain: Engine In Vehicle (07/93-0357)
- Exchange Unit Parts: Abs, TCS, ASR, ETS (07/93-0360)
- New Test Cables For The Breakout Box (03/93-0313)
- Idling Increase Malfunction:New Gear Selector Switch (02/93-0306)
- Spark Plug Reference Table (06/92-0217)
- 2.0L Eng DRIVEABILITY/Stalling - Air Bypass Valve (10/90-0034)
- Exchange Air Mass Meters: Part Nos. Cross Reference (10/90-0033, PG. 03)
- EZK Electronic Control Units: Part Nos Reference (10/90-0033, PG. 12)
- LH Fuel Injection Control Units: Parts Ref.Nos (10/90-0033, PG. 04)
- Performance Tuning Kits Availability (ACC, SEC. 4, PG. 4)
- LH 2.4 Ecu Fault Code Retrieval (10/88-1086, PG. 211)
- 2.4L Eng New OXY Sensor - Service Schedule Revision (02/91-0088)
- APC Pressure Transducer Ground Check (STT 0487-16)
- B201 Engine Low Idle - Clean Throttle Plate/Body (STT 0988-11)
- Emission Label Removal Caution (STT 0587-13)
- Engine-To-Gearbox Sealing (05/91-0110)
- EZK Ignition Hard Cold Start - New Ground Wire (03/91-0093)
- EZK Ignition System Tester Modification (08/89-1170)
- EZK Ignition Test Socket Caution (STT 0587-14)
- False Mil Intermittent Flashing - EZK Ignition Ecu (10/89-1181)
- Hard Cold Weather Start - Service Kit (12/90-0073)
- Idle Speed Adjustment Wrench (06/87-976)
- New Cylinder Head Gaskets (09/87-994)
- Oil Leak - New Timing Chain Cover Gasket (STT 0788-05)
- Poor Start\Replace Hose Clamps On Turbo Bypass Valve (05/92-0205)
- WALBRO Fuel Pump Noise/Overheat - New Pump Assembly (10/90-0032)
- Towing
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheels & Tire System
- Vibration Complaint Caused By Rims Or Tires (05/94-0460)
- Tire Purchasing Program - Dealer Info Parts Numbers (11/91-0048)
- Cross Spoke Wheel Center Cap: New Spring (STT 0793-06)
- Tire Program: Direct Manufacturer Provision (09/90-0025)
- Winter Tire Program: Special Snow Tires Availability (09/90-0026)
- SAAB 900 & 9000 Alloy Wheels Availability (06/90-0002)
- Winter Aids: Various Options Available (ACC, SEC. 6, PG. 1)
- Special Tool Availability To Check Total Toe-In (03/88-1045)
- Front Wheel Bearing Noise Service Procedure (03/91-0099)
- Window Motors & Regulators
- Improper Or Poor Window Operation (11/94-0522)
- CONV. Top Fabric Wear: New Parts & Adjustment (10/91-0138)
- Checking CONV. Top HYD. Fluid Level: New Procedure (07/89-1156)
- CONV. Top Water & Wind Leaks: New Procedure (06/93-0350)
- New Rubber Bushings For Convertible Tops (03/91-0098)
- New Door Glass Retaining Clip: Scratch Prevention (06/90-0006)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Trailer Hitch Kit Availability (ACC, SEC. 7, PG. 2)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Rear Window Roller Blinds Acc. Parts Availability (ACC, SEC. 5, PG. 1)
- Side Window Deflector Accessory Parts Availability (ACC, SEC. 8, PG. 4)
- Adjustment Of Door Glass (Convertible Models) (07/89-1158)
- Fixed Trailer Hitch Installation (11/89-1192)
- Windshield Replacement Procedures:Convertible Models (09/89-1176)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Improving Taillight Ground Circuit (10/91-0140)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Electrical Connector Pin Removal Tool (03/90-1222)
- Trailer Hitch Kit Availability (ACC, SEC. 7, PG. 2)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Fixed Trailer Hitch Installation (11/89-1192)
- Wiring Defect Between MICROSW. & Recirculating SW. (07/89-1161)