Technical Service Bulletins: Other Variant
WARNING: This page is about the 9000 S, Automatic, which is a different variant/trim than selected.
- A/C Compressor
- Accessories Control Systems
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Guard Alarm System Replacement Module (02/92-0190)
- Mid-Length Mud Flaps Parts Availability (05/91-0106)
- New Special Tool For The Striker Plate Adjustment (05/91-0113)
- Replacement Door Seal Section Availability (05/91-0111)
- Rear Window Louver Availability (11/90-0060)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Front & Rear Mudflap Kit Availability (ACC, SEC. 7, PG. 2)
- Rubber FLOORMATS Accessory Parts Availability (ACC, SEC. 2, PG. 4)
- TAILER Hitch Kit Availability (ACC, SEC. 7, PG. 3)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Correcting Loose Door Handle Backing Plate (03/88-1041)
- Air Flow Kit Tips To Be Read Before Installing (06/89-1155)
- Alarm Installation - Seat Belt Reel Caution (STT 0487-12)
- Anti-Theft VIN Marking Labels (08/86-873)
- Door Stop Brackets Repair Procedure (07/87-984)
- Door Trim Seal Separating At "B" Pillar: New Clips (05/87-961)
- GLOVEBOX Door Adjustment Kit Availability (06/87-972)
- Intermittent Pictogram Flashing - Service Kit (06/88-1060)
- LT Speaker Grille Led Bezel Replacement Availability (01/87-924)
- Rear Hatch Inoperative With Central Locking - Repair (01/88-1028)
- Rear Hatch Water Leakage: Adhesive Re-Applied (05/87-962)
- Rear Hatch Water Leaks: New Water Deflector (10/86-893)
- Sunroof R & R Procedure (03/87-951)
- Trailer Hitch Installation Procedure (01/87-921)
- Automatic Trans
- 9000 ZF A/T - Clarification Of Dipstick Part Number (TSB 02/22/95)
- Transmission Lubricants - Information (TSB 02/14/95)
- Poor Shifting 3-4 Performance A/T - Replace Springs (08/94-0491)
- A/T Upshift Noise: Transmission Fluid Additive (06/93-0352)
- ATF Filtering Procedure (12/92-0281)
- Fluid, Lubricants And Supplies: Reference Chart (10/92-0265)
- Auto Trans (Turbo Eng): Exchange Unit Part No. Ref (10/90-0033, PG. 19)
- Fluids, Lubricants And Supplies Availability (SP.REF, SEC. 1, PG. 030)
- Fluids, Lubricants And Supplies Availability (06/89-1150)
- 4HP18 Trans 3RD To 4TH Shift Flare - Rev Valve Body (03/87-947)
- A/T Gear Selector Lever Inspection & Adjustment (03/88-1040)
- A/T Governor R & R (07/88-1061)
- A/T New Throttle Cable/Clips Location (02/88-1032)
- A/T Stall In Drive/Rev - Clean Governor/Change Oil (09/86-887)
- ATF Cooling System Noise - New Hose Service Kit (11/89-1194)
- Automatic Transmissions Identification (STT 0387-13)
- Automatic Transmissions,9000 Turbo,Part Numbers (07/92-0232)
- New A/T Throttle Housing Levers (STT 0687-04)
- New CV-Joint Boot Clamps (01/92-0175)
- New Engine Stand Spindle For Adapting SAAB Fixtures (01/87-917)
- Transportation Cover For Oil Cooler Return Pipe: PDI (07/87-987)
- ZF 4HP-18 4-SPD A/T - Special Service Tools (10/86-897)
- ZF A/T Damage From Coolant In ATF - Replace Radiator (07/88-1063)
- ZF A/T Oil Cooler Leakage - Replace Radiator (07/88-1062)
- ZF A/T Testing Tool - Pressure Hose/Gauge (STT 0687-02)
- ZF Transmission Coolant Contamination Diagnosis (02/90-1215)
- Auxiliary Emission Control Systems
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- Discontinuation Of Service Fuel Pump Assembly (11/94-0517)
- New Test Cables For The Breakout Box (03/93-0313)
- B202 LH Fuel Injection Control Units: Part Nos Ref (10/90-0033, PG. 05)
- Exchange Air Mass Meters: Part Nos. Cross Reference (10/90-0033, PG. 03)
- Performance Tuning Kits Availability (ACC, SEC. 4, PG. 4)
- 16V Eng Stall/Hard Start - Injector Test/Clean Tools (10/86-904)
- 16V Eng Stall/Hard Start/Rough Idle - Fuel Injectors (10/86-902)
- Abs System Inoperative - Loose Ground (STT 1287-02)
- Emission Label Removal Caution (STT 0587-13)
- Lambda LH JETRONIC FI New Air Mass Meter Tool (STT 0787-02)
- Modified Knock Detector Availability (05/87-968)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- 2.0L Eng DRIVEABILITY/Stalling - Air Bypass Valve (10/90-0034)
- B202 Engine Pulley Parts Correction: Fiche Correct (11/90-0048)
- A/C System New Idler Pulley Bearing/Retaining Bolt (STT 0387-14)
- Poly-V Belt Inspection (B202 Engine) (12/89-1197)
- Turbo/Radiator Inlet Pipe Clamp Removal 7MM Tool (STT 0587-03)
- Body Interior
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- New Test Cables For The Breakout Box (03/93-0313)
- Error Message On Electronic Display Unit (EDU) (10/91-0142)
- Mid-Length Mud Flaps Parts Availability (05/91-0106)
- Rear Window Louver Availability (11/90-0060)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Front & Rear Mudflap Kit Availability (ACC, SEC. 7, PG. 2)
- Rubber FLOORMATS Accessory Parts Availability (ACC, SEC. 2, PG. 4)
- TAILER Hitch Kit Availability (ACC, SEC. 7, PG. 3)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Driver/Co-Driver Trip Computer - Parts Table (ACC, SEC. 7, PG. 1)
- Air Flow Kit Tips To Be Read Before Installing (06/89-1155)
- Diagnosing EDU 1 And EDU 2 Trip Computers (03/88-1044)
- Electronic Display Unit - EDU Application Table (04/91-0102)
- Intermittent Pictogram Flashing - Service Kit (06/88-1060)
- Trailer Hitch Installation Procedure (01/87-921)
- Brakes Control Systems
- Charging Systems
- Clutch
- Shorty Driver Discomfort - Pedal Raising Kit (524-1788 ED. 2)
- Clutch Operating Problems:New Clutch Master Cylinder (05/93-0329)
- Manual TRAN (Turbo): Exchange Part No. Reference (10/90-0030, PG. 24)
- Manual Trans (Turbo): Exchange Part Nos. Reference (10/90-0033, PG. 22)
- 5-Speed M/T Clutch Noise - New Clutch Disc (10/86-896)
- New CV-Joint Boot Clamps (01/92-0175)
- Communication Devices
- New 5-Spoke Full-Face Wheel (08/93-0364)
- New Rear Spoiler - Application/Description (06/93-0353)
- Fog Lights: Part Number References (06/90-0004)
- Winter Aids: Various Options Available (ACC, SEC. 6, PG. 1)
- Trailer Hitch Accessories Availability (ACC, SEC. 7, PG. 4)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Roadholding Kit Availability (ACC, SEC. 7, PG. 3)
- Fog Light Kit For Cars Equipped W/Air Flow Kit (01/88-1021)
- Accessory Cellular Phone Installation Procedure (06/87-971)
- Component Locations
- Cooling System (Mechanical)
- Rear Main Seal 4-Cylinder Engine (STT 0594-06)
- Engine Gaskets Replaced By Sealant (02/94-0436)
- Coolant Leak At Water Pump:New Pump, O-Ring & Gasket (06/93-0343)
- Antifreeze/Coolant Part Numbers Reference (ACC, SEC. 20, PG. 1)
- 16V Eng Coolant Thermostat Identification/Caution (03/87-945)
- Coolant Pump Leakage Diagnosis (STT 0188-11)
- Expansion Tank Pressure Cap Check/ADAPTOR (02/87-935)
- Expansion Tank Pressure Cap Checking Adapter (02/87-933)
- New 16 Valve Eng. CYL. Head Gasket: No RETORQUING (09/87-995)
- New Cylinder Head Gaskets (09/87-994)
- Revised Cylinder Head Torque Specifications (09/86-885)
- Turbo/Radiator Inlet Pipe Clamp Removal 7MM Tool (STT 0587-03)
- WALBRO Fuel Pump Noise/Overheat - New Pump Assembly (10/90-0032)
- Cruise Control Systems
- Loose Clip On Cruise Control Ball Chain: New Clip (11/93-0411)
- Troubleshooting Cruise Control: New Breakout Box (11/93-0412)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Cruise Control Fault Testing Test Box Procedure (03/87-954)
- HELLA Cruise Control - Special Test Box (03/87-950)
- Intermittent Pictogram Flashing - Service Kit (06/88-1060)
- Differentials & Drive Axles
- New Bolt For The Final Drive (11/94-0516)
- A/T Upshift Noise: Transmission Fluid Additive (06/93-0352)
- Fluid, Lubricants And Supplies: Reference Chart (10/92-0265)
- New Special Tool For Installing CV-Joint Boot Clamps (01/92-0174)
- Fluids, Lubricants And Supplies Availability (SP.REF, SEC. 1, PG. 030)
- Fluids, Lubricants And Supplies Availability (06/89-1150)
- Manual/Auto Trans Identifying Drive Axles (11/86-907)
- New CV-Joint Boot Clamps (01/92-0175)
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- Discontinuation Of Service Fuel Pump Assembly (11/94-0517)
- New Test Cables For The Breakout Box (03/93-0313)
- Error Message On Electronic Display Unit (EDU) (10/91-0142)
- 2.0L Eng DRIVEABILITY/Stalling - Air Bypass Valve (10/90-0034)
- B202 LH Fuel Injection Control Units: Part Nos Ref (10/90-0033, PG. 05)
- Performance Tuning Kits Availability (ACC, SEC. 4, PG. 4)
- 16V Eng Stall/Hard Start - Injector Test/Clean Tools (10/86-904)
- 16V Eng Stall/Hard Start/Rough Idle - Fuel Injectors (10/86-902)
- Abs System Inoperative - Loose Ground (STT 1287-02)
- BOSCH Fuel Pump R & I - New Wrench (10/87-1005)
- Idle Speed Adjustment Wrench (06/87-976)
- Lambda LH JETRONIC FI New Air Mass Meter Tool (STT 0787-02)
- Modified Knock Detector Availability (05/87-968)
- New Idle Speed Adjustment Wrench Availability (06/87-977)
- Entertainment Systems
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Manually Releasing Cd Magazine From Cd Changer (936-1898)
- Open Circuit In Electrically-Heated Rear Window (04/93-0328)
- Modified Front Speaker Grills (11/91-0157)
- Clarion Warranty Program On OEM Radios (PARTS, SEC. 7, PG. 6)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Exterior Body Panels
- Exterior Lights
- Map Light Fuse Blows:Drivers Seat Belt Wiring Check (STT 0793-05)
- Fog Lights: Part Number References (06/90-0004)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Fog Light Kit For Cars Equipped W/Air Flow Kit (01/88-1021)
- Fuses Blowing - Fuse Rating Upgrade (STT 0687-07)
- Intermittent Pictogram Flashing - Service Kit (06/88-1060)
- LT Speaker Grille Led Bezel Replacement Availability (01/87-924)
- Seat Heat Switch Won't Light - Bulb Repair Kit (05/91-0119)
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Shorty Driver Discomfort - Pedal Raising Kit (524-1788 ED. 2)
- Loose Clip On Cruise Control Ball Chain: New Clip (11/93-0411)
- 16V Eng Stall/Hard Start - Injector Test/Clean Tools (10/86-904)
- 16V Eng Stall/Hard Start/Rough Idle - Fuel Injectors (10/86-902)
- B201 Engine Low Idle - Clean Throttle Plate/Body (STT 0988-11)
- BOSCH Fuel Pump R & I - New Wrench (10/87-1005)
- Idle Speed Adjustment Wrench (06/87-976)
- Lambda LH JETRONIC FI New Air Mass Meter Tool (STT 0787-02)
- New Idle Speed Adjustment Wrench Availability (06/87-977)
- Fuses & Circuit Breakers
- Troubleshooting Cruise Control: New Breakout Box (11/93-0412)
- Map Light Fuse Blows:Drivers Seat Belt Wiring Check (STT 0793-05)
- Securing Of Fuse Box Distribution Terminals (12/92-0278)
- Mid-Length Mud Flaps Parts Availability (05/91-0106)
- Rear Window Louver Availability (11/90-0060)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Front & Rear Mudflap Kit Availability (ACC, SEC. 7, PG. 2)
- Rubber FLOORMATS Accessory Parts Availability (ACC, SEC. 2, PG. 4)
- TAILER Hitch Kit Availability (ACC, SEC. 7, PG. 3)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- A/C Spike SUPRESSION Diode (SP.REF, SEC. 3, PG. 019)
- Air Flow Kit Tips To Be Read Before Installing (06/89-1155)
- Fuses Blowing - Fuse Rating Upgrade (STT 0687-07)
- Intermittent Pictogram Flashing - Service Kit (06/88-1060)
- Proper Wiring Harness Routing (01/87-922)
- Trailer Hitch Installation Procedure (01/87-921)
- Gauges & Instrument Panels
- Rattles/Squeaks In Dashboard (08/95-0607)
- Inaccurate Speed Warning Function: Recalibrated SCC (STT 0893-01)
- Exchange Unit Part: Electronic Display Unit (07/93-0359)
- Modified Front Speaker Grills (11/91-0157)
- Error Message On Electronic Display Unit (EDU) (10/91-0142)
- Mid-Length Mud Flaps Parts Availability (05/91-0106)
- Rear Window Louver Availability (11/90-0060)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Front & Rear Mudflap Kit Availability (ACC, SEC. 7, PG. 2)
- Rubber FLOORMATS Accessory Parts Availability (ACC, SEC. 2, PG. 4)
- TAILER Hitch Kit Availability (ACC, SEC. 7, PG. 3)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Separated Glove Box Door Fix (08/88-1065)
- Speedometer Flutter - Replace Defective Speed Sensor (03/88-1043)
- Air Flow Kit Tips To Be Read Before Installing (06/89-1155)
- GLOVEBOX Door Adjustment Kit Availability (06/87-972)
- Loose Center Console Lid Trim: Adhesive Re-Applied (10/86-894)
- Trailer Hitch Installation Procedure (01/87-921)
- Hazardous Waste Material
- Headlights
- Map Light Fuse Blows:Drivers Seat Belt Wiring Check (STT 0793-05)
- Fog Lights: Part Number References (06/90-0004)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Fog Light Kit For Cars Equipped W/Air Flow Kit (01/88-1021)
- Fuses Blowing - Fuse Rating Upgrade (STT 0687-07)
- Intermittent Pictogram Flashing - Service Kit (06/88-1060)
- LT Speaker Grille Led Bezel Replacement Availability (01/87-924)
- Seat Heat Switch Won't Light - Bulb Repair Kit (05/91-0119)
- Heated Glass/Defoggers
- Mid-Length Mud Flaps Parts Availability (05/91-0106)
- Rear Window Louver Availability (11/90-0060)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Front & Rear Mudflap Kit Availability (ACC, SEC. 7, PG. 2)
- Rubber FLOORMATS Accessory Parts Availability (ACC, SEC. 2, PG. 4)
- TAILER Hitch Kit Availability (ACC, SEC. 7, PG. 3)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Air Flow Kit Tips To Be Read Before Installing (06/89-1155)
- Trailer Hitch Installation Procedure (01/87-921)
- HVAC Control Systems
- R134A Compressors For Converted A/C System (870-1783 ED. 2)
- Compressor Oil (98-11-854)
- Correcting Self-Closing Center Air Vent (12/92-0294)
- Replacement Availability For Acc PUSHBUTTONS (06/90-0001)
- 2.0L Eng Cracked Evaporator - New A/C Hose Clamp (06/87-970)
- Automatic Climate Control (Acc), Exchange Part No.S (03/92-0199)
- New A/C Compressor & Hose (SP.REF, SEC. 8, PG. 129)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Spark Plug Reference Table (06/92-0217)
- B202 Eng Ignition Distributors: Part Nos Reference (10/90-0033, PG. 14)
- 16-Valve Engine Ignition Distributor Overhaul (10/87-1010)
- Excessive Line Pressure: DRIVEABILITY Complaints Fix (06/89-1152)
- Hall-Effect Ignition Distributor Puller Availability (06/87-979)
- Ignition System Amplifier Installation - Grease (03/87-956)
- Lambda LH JETRONIC FI New Air Mass Meter Tool (STT 0787-02)
- LH 2.2 FI Hard Cold Weather Start - Service Kit (01/90-1204)
- New Distributor Wire Tightener Strap (STT 0787-10)
- Poor DRIVEABILITY - New Fuel Return Check Valve (06/89-1151)
- Turbo Coking - Replace Turbo & Clean Oil Lines (STT 0688-11)
- Updated Replacement Spark Plug Recommendations (07/87-983)
- WALBRO Fuel Pump Noise/Overheat - New Pump Assembly (10/90-0032)
- Infotainment
- Interior/Exterior Trim
- Rattles/Squeaks In Dashboard (08/95-0607)
- Noise From Windshield: New Sealant Application (10/93-0383)
- Loose Or Sagging Door Seals: New Attachment Tape (08/93-0363)
- New Rear Spoiler - Application/Description (06/93-0353)
- Modified Front Speaker Grills (11/91-0157)
- Fender Flares Part Availability (02/91-0091)
- Corporate Emblem Replacement Availability (01/91-0080)
- Correcting Loose Door Handle Backing Plate (03/88-1041)
- Accessory Rear Decor Door Panel Install Modification (05/90-1240)
- Door Trim Seal Separating At "B" Pillar: New Clips (05/87-961)
- Interior/Illumination Lights
- Map Light Fuse Blows:Drivers Seat Belt Wiring Check (STT 0793-05)
- Fog Lights: Part Number References (06/90-0004)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Fog Light Kit For Cars Equipped W/Air Flow Kit (01/88-1021)
- Fuses Blowing - Fuse Rating Upgrade (STT 0687-07)
- LT Speaker Grille Led Bezel Replacement Availability (01/87-924)
- Seat Heat Switch Won't Light - Bulb Repair Kit (05/91-0119)
- Locking Hubs
- Lubrication System
- Service Interval Is Determined By Both Distance And Time (100-2490)
- Rear Main Seal 4-Cylinder Engine (STT 0594-06)
- Engine Gaskets Replaced By Sealant (02/94-0436)
- A/T Upshift Noise: Transmission Fluid Additive (06/93-0352)
- Coolant Leak At Water Pump:New Pump, O-Ring & Gasket (06/93-0343)
- Fluid, Lubricants And Supplies: Reference Chart (10/92-0265)
- Fluids, Lubricants And Supplies Availability (SP.REF, SEC. 1, PG. 030)
- Fluids, Lubricants And Supplies Availability (06/89-1150)
- Excessive Engine Oil Consumption (16-Valve) (04/88-1048)
- 16V Eng Excessive Oil Consumption - Sealing Washers (04/88-1047)
- Break-In Oil Filter Wrench Availability (11/85-807)
- New 16 Valve Eng. CYL. Head Gasket: No RETORQUING (09/87-995)
- New Cylinder Head Gaskets (09/87-994)
- Oil Pick-Up Pipe Alignment Tool (06/87-974)
- Revised Cylinder Head Torque Specifications (09/86-885)
- WALBRO Fuel Pump Noise/Overheat - New Pump Assembly (10/90-0032)
- Manual Trans
- Transmission Lubricants - Information (TSB 02/14/95)
- Manual TRAN (Turbo): Exchange Part No. Reference (10/90-0030, PG. 24)
- Manual Trans (Turbo): Exchange Part Nos. Reference (10/90-0033, PG. 22)
- New Shift Lever Boot:PRVENT 3RD & 5TH Gears Slip-Out (07/88-1064)
- GMT52/54 Trans 4TH To 5TH Grind - New Support Plate (06/87-969)
- GMT52/54TRANS Gearbox Fluid Level Check/Fill (01/87-926)
- Gearbox Synchromesh Ring Revision (STT 0689-08)
- LOCTITE 510 Availability (Models W/Man. Trans.) (09/89-1173)
- M/T New Bearing Press Tool For Output Shaft Bearing (STT 1287-03)
- M/T Sealing - LOCTITE 510 Application (09/89-1172)
- Manual Transmission Oils (STT 0690-11)
- New CV-Joint Boot Clamps (01/92-0175)
- New Engine Stand Spindle For Adapting SAAB Fixtures (01/87-917)
- New Speedometer Drive Mounting (STT 0487-06)
- Shaft End-Play Measuring (STT 0288-09)
- Mechanical
- Service Interval Is Determined By Both Distance And Time (100-2490)
- Changing Upper Engine Mount Bushing (210-2029)
- Rear Main Seal 4-Cylinder Engine (STT 0594-06)
- Engine Gaskets Replaced By Sealant (02/94-0436)
- "Hooting" Noise From Engine: New Turbo By-Pass Valve (11/93-0401)
- Camshaft Cover Oil Film Reduction: New Cover Ident. (STT 0893-04)
- Changing Timing Chain: Engine In Vehicle (07/93-0357)
- Coolant Leak At Water Pump:New Pump, O-Ring & Gasket (06/93-0343)
- Holding Tool For Relieving Strain On Engine (02/93-0302)
- Excessive Engine Oil Consumption (16-Valve) (04/88-1048)
- 16-Valve Engine Guide Seals Removal Pliers Available (01/86-818)
- 16V Eng Camshaft Noise - New Cam Chain TENSIONER (11/86-911)
- 16V Eng Excessive Oil Consumption - Sealing Washers (04/88-1047)
- 2.0L Eng Crankshaft - Superseded Part Info/Guide (02/92-0188)
- Break-In Oil Filter Wrench Availability (11/85-807)
- Excessive Line Pressure: DRIVEABILITY Complaints Fix (06/89-1152)
- Modified Crankshaft Seal Installation Tool (STT 0488-02)
- New 16 Valve Eng. CYL. Head Gasket: No RETORQUING (09/87-995)
- New Cylinder Head Gaskets (09/87-994)
- New Cylinder/Engine Block Manganese Freeze Plugs (STT 0587-08)
- New Engine Stand Spindle For Adapting SAAB Fixtures (01/87-917)
- New Extractor Vent Fastener (STT 0687-05)
- Noisy Fuel Pump/Poor Performance - New Service Pump (03/90-1224)
- Oil Pick-Up Pipe Alignment Tool (06/87-974)
- Oversized Valve Guide Identification (STT 0987-07)
- Poor DRIVEABILITY - New Fuel Return Check Valve (06/89-1151)
- Revised Cylinder Head Torque Specifications (09/86-885)
- Spare Parts Part Numbers For Short Engines (SP.REF, SEC. 2, PG. 141)
- Turbo Coking - Replace Turbo & Clean Oil Lines (STT 0688-11)
- WALBRO Fuel Pump Noise/Overheat - New Pump Assembly (10/90-0032)
- Mechanical - Hydraulic
- Brake Pad Short Life Complaints (500-1789)
- Brake Pad Part Supersession Chart (11/94-0519)
- A/T Upshift Noise: Transmission Fluid Additive (06/93-0352)
- Fluid, Lubricants And Supplies: Reference Chart (10/92-0265)
- New Special Tool: Brake Rotor Measuring Fixture (10/91-0146)
- Front Brake Calipers: Part Numbers Cross Reference (10/90-0033, PG. 25)
- Fluids, Lubricants And Supplies Availability (SP.REF, SEC. 1, PG. 030)
- Fluids, Lubricants And Supplies Availability (06/89-1150)
- Brake Rotor Inspection Procedures (11/89-1191)
- New Type Brake Pad Recommendations (08/90-0017)
- Memory Modules
- Mid-Length Mud Flaps Parts Availability (05/91-0106)
- Rear Window Louver Availability (11/90-0060)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Front & Rear Mudflap Kit Availability (ACC, SEC. 7, PG. 2)
- Rubber FLOORMATS Accessory Parts Availability (ACC, SEC. 2, PG. 4)
- TAILER Hitch Kit Availability (ACC, SEC. 7, PG. 3)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Air Flow Kit Tips To Be Read Before Installing (06/89-1155)
- Intermittent Pictogram Flashing - Service Kit (06/88-1060)
- Trailer Hitch Installation Procedure (01/87-921)
- Mirrors
- Improper Or Poor Window Operation (11/94-0522)
- Binding Or Slow Operating Front Windows (04/93-0321)
- Mid-Length Mud Flaps Parts Availability (05/91-0106)
- Rear Window Louver Availability (11/90-0060)
- Window Switch Assembly: Part No. (Fiche Correction) (11/90-0042)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Front & Rear Mudflap Kit Availability (ACC, SEC. 7, PG. 2)
- Rubber FLOORMATS Accessory Parts Availability (ACC, SEC. 2, PG. 4)
- TAILER Hitch Kit Availability (ACC, SEC. 7, PG. 3)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Air Flow Kit Tips To Be Read Before Installing (06/89-1155)
- Fuses Blowing - Fuse Rating Upgrade (STT 0687-07)
- Intermittent Pictogram Flashing - Service Kit (06/88-1060)
- Seat Heat Switch Won't Light - Bulb Repair Kit (05/91-0119)
- Sunroof R & R Procedure (03/87-951)
- Trailer Hitch Installation Procedure (01/87-921)
- Overdrive Unit
- Paint & Coatings
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- SAAB Paint Colors (890-9049)
- SAAB Paint Colors (890-1807 ED. 4)
- Handling Of ISOCYANATES (101-2056)
- Noise From Windshield: New Sealant Application (10/93-0383)
- SAAB Touch-Up Paint Reference Table (08/92-0242)
- 1987 SAAB 9000 Paint Formula Codes (09/86-889)
- Passive Restraints
- Procedures
- Rear Suspension
- Restraints Control Systems
- Schedule
- Seats
- Improper Or Poor Window Operation (11/94-0522)
- Binding Or Slow Operating Front Windows (04/93-0321)
- Trunk Lid Hinge Springs: Foam Rubber Inserts (06/92-0214)
- Front Seat Replacement Assemblies (06/91-0123)
- Mid-Length Mud Flaps Parts Availability (05/91-0106)
- Rear Window Louver Availability (11/90-0060)
- Window Switch Assembly: Part No. (Fiche Correction) (11/90-0042)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Front & Rear Mudflap Kit Availability (ACC, SEC. 7, PG. 2)
- Rubber FLOORMATS Accessory Parts Availability (ACC, SEC. 2, PG. 4)
- TAILER Hitch Kit Availability (ACC, SEC. 7, PG. 3)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Accessory Armrest - Part Number Table (ACC, SEC. 4, PG. 2)
- Air Flow Kit Tips To Be Read Before Installing (06/89-1155)
- Front Seat Belt Harness Detonation Prior To Replace (06/86-853)
- Fuses Blowing - Fuse Rating Upgrade (STT 0687-07)
- Intermittent Pictogram Flashing - Service Kit (06/88-1060)
- Rear Seat Upholstery Protective Edging Installation (05/87-965)
- Seat Backrest Angle Adjustment Changes Position (07/89-1167)
- Seat Heat Switch Won't Light - Bulb Repair Kit (05/91-0119)
- Sunroof R & R Procedure (03/87-951)
- Trailer Hitch Installation Procedure (01/87-921)
- Starter
- "Hooting" Noise From Engine: New Turbo By-Pass Valve (11/93-0401)
- Starters: Part Numbers Cross Reference (10/90-0033, PG. 11)
- 16V Eng Camshaft Noise - New Cam Chain TENSIONER (11/86-911)
- Excessive Line Pressure: DRIVEABILITY Complaints Fix (06/89-1152)
- LH 2.2 FI Hard Cold Weather Start - Service Kit (01/90-1204)
- New Remote Starter Box Tool Availability (02/87-929)
- Noisy Fuel Pump/Poor Performance - New Service Pump (03/90-1224)
- Starters Failure - Starter Application Table (07/91-0128)
- WALBRO Fuel Pump Noise/Overheat - New Pump Assembly (10/90-0032)
- Steering Column
- Steering Column Switches
- Steering Control Systems
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Noise From Windshield: Source & Correction Procedure (STT 0893-03)
- Trunk Lid Hinge Springs: Foam Rubber Inserts (06/92-0214)
- Mid-Length Mud Flaps Parts Availability (05/91-0106)
- Rear Window Louver Availability (11/90-0060)
- Sunroof Deflector Accessory Parts Availability (ACC, SEC. 8, PG. 1)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Front & Rear Mudflap Kit Availability (ACC, SEC. 7, PG. 2)
- Rubber FLOORMATS Accessory Parts Availability (ACC, SEC. 2, PG. 4)
- TAILER Hitch Kit Availability (ACC, SEC. 7, PG. 3)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Stiff Operating Steel Sunroofs:Fitting Thinner Seals (09/89-1177)
- Sunroof Road Noise Correction With One-Way Caps (04/88-1051)
- Correcting Loose Door Handle Backing Plate (03/88-1041)
- Air Flow Kit Tips To Be Read Before Installing (06/89-1155)
- Closed Sunroof Aligning Tool Availability (03/87-948)
- GLOVEBOX Door Adjustment Kit Availability (06/87-972)
- Loose Center Console Lid Trim: Adhesive Re-Applied (10/86-894)
- Slow/Binding Sunroof Repair (02/88-1030)
- Trailer Hitch Installation Procedure (01/87-921)
- Suspension Control Systems
- System
- Tech2 (03-09-248)
- SPS And Tech2 (02-11-248)
- Shorty Driver Discomfort - Pedal Raising Kit (524-1788 ED. 2)
- Discontinuation Of Service Fuel Pump Assembly (11/94-0517)
- Rear Main Seal 4-Cylinder Engine (STT 0594-06)
- Engine Gaskets Replaced By Sealant (02/94-0436)
- Loose Clip On Cruise Control Ball Chain: New Clip (11/93-0411)
- Changing Timing Chain: Engine In Vehicle (07/93-0357)
- Coolant Leak At Water Pump:New Pump, O-Ring & Gasket (06/93-0343)
- New Test Cables For The Breakout Box (03/93-0313)
- Spark Plug Reference Table (06/92-0217)
- Error Message On Electronic Display Unit (EDU) (10/91-0142)
- 2.0L Eng DRIVEABILITY/Stalling - Air Bypass Valve (10/90-0034)
- B202 LH Fuel Injection Control Units: Part Nos Ref (10/90-0033, PG. 05)
- Exchange Air Mass Meters: Part Nos. Cross Reference (10/90-0033, PG. 03)
- Performance Tuning Kits Availability (ACC, SEC. 4, PG. 4)
- 16V Eng Stall/Hard Start - Injector Test/Clean Tools (10/86-904)
- 16V Eng Stall/Hard Start/Rough Idle - Fuel Injectors (10/86-902)
- Abs System Inoperative - Loose Ground (STT 1287-02)
- B201 Engine Low Idle - Clean Throttle Plate/Body (STT 0988-11)
- BOSCH Fuel Pump R & I - New Wrench (10/87-1005)
- Emission Label Removal Caution (STT 0587-13)
- Excessive Line Pressure: DRIVEABILITY Complaints Fix (06/89-1152)
- Hall-Effect Ignition Distributor Puller Availability (06/87-979)
- Idle Speed Adjustment Wrench (06/87-976)
- Ignition System Amplifier Installation - Grease (03/87-956)
- Lambda LH JETRONIC FI New Air Mass Meter Tool (STT 0787-02)
- LH 2.2 FI Hard Cold Weather Start - Service Kit (01/90-1204)
- Modified Knock Detector Availability (05/87-968)
- New 16 Valve Eng. CYL. Head Gasket: No RETORQUING (09/87-995)
- New Cylinder Head Gaskets (09/87-994)
- New Distributor Wire Tightener Strap (STT 0787-10)
- New Idle Speed Adjustment Wrench Availability (06/87-977)
- Poor DRIVEABILITY - New Fuel Return Check Valve (06/89-1151)
- Revised Cylinder Head Torque Specifications (09/86-885)
- Turbo Coking - Replace Turbo & Clean Oil Lines (STT 0688-11)
- Updated Replacement Spark Plug Recommendations (07/87-983)
- WALBRO Fuel Pump Noise/Overheat - New Pump Assembly (10/90-0032)
- Towing
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheel Hubs
- Wheels & Tire System
- Vibration Complaint Caused By Rims Or Tires (05/94-0460)
- Tire Purchasing Program - Dealer Info Parts Numbers (11/91-0048)
- New 5-Spoke Full-Face Wheel (08/93-0364)
- Cross Spoke Wheel Center Cap: New Spring (STT 0793-06)
- Tire Program: Direct Manufacturer Provision (09/90-0025)
- Winter Tire Program: Special Snow Tires Availability (09/90-0026)
- SAAB 900 & 9000 Alloy Wheels Availability (06/90-0002)
- Winter Aids: Various Options Available (ACC, SEC. 6, PG. 1)
- Special Tool Availability To Check Total Toe-In (03/88-1046)
- Front Wheel Hubs Removal/Installation Procedure (08/86-868)
- Winter Tire/Wheel Rim Recommendations (10/86-900)
- Window Motors & Regulators
- Improper Or Poor Window Operation (11/94-0522)
- New Adhesive For Glass Installation (08/94-0485)
- Loose Or Sagging Door Seals: New Attachment Tape (08/93-0363)
- Noise From Windshield: Source & Correction Procedure (STT 0893-03)
- Binding Or Slow Operating Front Windows (04/93-0321)
- Trunk Lid Hinge Springs: Foam Rubber Inserts (06/92-0214)
- Mid-Length Mud Flaps Parts Availability (05/91-0106)
- Rear Window Louver Availability (11/90-0060)
- Window Switch Assembly: Part No. (Fiche Correction) (11/90-0042)
- New Special Tool For Removing Glued-In Glass (08/90-0019)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Front & Rear Mudflap Kit Availability (ACC, SEC. 7, PG. 2)
- Rubber FLOORMATS Accessory Parts Availability (ACC, SEC. 2, PG. 4)
- TAILER Hitch Kit Availability (ACC, SEC. 7, PG. 3)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Rear Window Roller Blinds Acc. Parts Availability (ACC, SEC. 5, PG. 1)
- Side Window Deflector Accessory Parts Availability (ACC, SEC. 8, PG. 4)
- Accessory Rear Window Louver - Part Numbers (ACC, SEC. 8, PG. 3)
- Correcting Loose Door Handle Backing Plate (03/88-1041)
- Air Flow Kit Tips To Be Read Before Installing (06/89-1155)
- Fuses Blowing - Fuse Rating Upgrade (STT 0687-07)
- GLOVEBOX Door Adjustment Kit Availability (06/87-972)
- Loose Center Console Lid Trim: Adhesive Re-Applied (10/86-894)
- Recommended Glass Removal Tool Availability (01/87-918)
- Seat Heat Switch Won't Light - Bulb Repair Kit (05/91-0119)
- Slow/Binding Sunroof Repair (02/88-1030)
- Sunroof R & R Procedure (03/87-951)
- Trailer Hitch Installation Procedure (01/87-921)
- Windshield Removal/Installation Procedures (04/87-959)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Securing Of Fuse Box Distribution Terminals (12/92-0278)
- Mid-Length Mud Flaps Parts Availability (05/91-0106)
- Rear Window Louver Availability (11/90-0060)
- Hubcaps & WHEELCOVERS Accessory Parts Availability (ACC, SEC. 20, PG. 1)
- Front & Rear Mudflap Kit Availability (ACC, SEC. 7, PG. 2)
- Rubber FLOORMATS Accessory Parts Availability (ACC, SEC. 2, PG. 4)
- TAILER Hitch Kit Availability (ACC, SEC. 7, PG. 3)
- Car Cover Accessory Parts Availability (ACC, SEC. 19, PG. 1)
- Air Flow Kit Tips To Be Read Before Installing (06/89-1155)
- Intermittent Pictogram Flashing - Service Kit (06/88-1060)
- Proper Wiring Harness Routing (01/87-922)
- Trailer Hitch Installation Procedure (01/87-921)