LEMON Manuals: Even more car manuals for everyone
Home >> Pontiac >> 2004 >> Aztek Base, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 137 (Sunroof System) >> Repair Instructions >> Moveable Roof Panel Latch Replacement - Rear >> Installation Procedure

Installation Procedure

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2004 Oldsmobile Bravada, 2004 GMC Envoy XUV, 2004 GMC Envoy XL, 2004 GMC Envoy, and 2004 Chevrolet TrailBlazer. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: Removing/Installing Moveable Roof Panel Latch - Rear
    GM1237926Courtesy of GENERAL MOTORS CORP.
  1. Install the rear latch slide (2) to the front latch slide.
  2. Install the rear latch levers (1) to the rear latch slide (2).
  3. Slide the rear latch assembly forward into the slot of moveable roof frame assembly.
    4. Fig 2: Identifying Moveable Roof Panel Latch - Front
    GM1237923Courtesy of GENERAL MOTORS CORP.
  4. Install the front latch (1) to the front latch slide.
    5. NOTE: Refer to Fastener Notice in Cautions and Notices.
  5. Install the fastener retaining the front latch (1) to the front latch slide.

    Tighten:  Tighten the front latch retainer to 0.75 N.m (6 lb in).

  6. Install the moveable roof panel guide assembly. Refer to Moveable Roof Panel Guide Replacement .
  7. Install the moveable roof panel actuator/motor. Refer to Moveable Roof Panel Motor/Actuator Replacement .
  8. Install the moveable roof panel. Refer to Moveable Roof Panel Assembly Replacement .
scientia non olet · About LEMON Manuals