LEMON Manuals: Even more car manuals for everyone
Home >> Pontiac >> 2002 >> Aztek AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 541 (Wheel Alignment Specifications & Adjustment Procedures) >> Repair Instructions >> Front Toe Adjustment

Front Toe Adjustment

WARNING: This page is about a different car, the 2002 Buick Regal and 2002 Buick Century. However, it is still accessible from the selected car via links, so may be relevant.
  1. Perform the following steps to remove the small seal clamp:
  2. Position the steering wheel in the straight ahead position.
  3. Loosen the hex nut on the tie rod (2). Turn the tie rod shaft (1) in order to obtain the proper toe angle. Refer to Figure.
  4. Confirm the number of threads showing on each tie rod end is nearly equal.
  5. Confirm that the tie rod ends (3) are square before you tighten the lock nuts (2).

    Tighten: 

    Tighten the hex huts at the tie rod ends to 68 N.m (50 ft lbs) 

    Fig 1: Adjusting Front Toe
    G01720498Courtesy of GENERAL MOTORS CORP.
    NOTE: Ensure the seals do not twist.
  6. Install the seal clamps.
scientia non olet · About LEMON Manuals