LEMON Manuals: Even more car manuals for everyone
Home >> Pontiac >> 2001 >> Aztek Base, FWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1506 (Wheel Alignment Specifications & Adjustment Procedures) >> Repair Instructions >> Front Toe Adjustment

Front Toe Adjustment

WARNING: This page is about a different car, the 2002 Pontiac Aztek and 2002 Buick Rendezvous. However, it is still accessible from the selected car via links, so may be relevant.
Fig 1: Adjusting Left & Right Tie Rod Jam Nuts
G01746838Courtesy of GENERAL MOTORS CORP.
  1. Remove the power steering gear seal small clamps.
  2. Ensure that the steering wheel is centered and the wheels are in the straight ahead position.
  3. Loosen the left and right tie rod jam nuts (2).

    Important:  Ensure that the number of threads showing on both inner tie rod ends are approximately equal.

  4. Rotate the inner tie rods in order to obtain the proper toe angle of 0 degrees.
    NOTE: Refer to FASTENER NOTICE .
  5. Install the tie rod end jam nuts.

    Tighten 

    Tighten the left and right tie rod jam nuts (2) to 68 N.m (50 lb ft).

    Important:  Ensure the power steering gear seal is not twisted.

  6. Install the power steering gear seal small clamps.
scientia non olet · About LEMON Manuals