Specifications Index
ACHIEVA, GRAND AM, SKYLARK SPECIFICATIONS INDEX
| System | Specification/Procedure | ||
|---|---|---|---|
| Air Conditioning | |||
| Service | A/C SYSTEM SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Axle Nut/Hub Nut | 185 Ft. lbs. (251 N.m) | ||
| Battery | |||
| 2.4L | CAPACITIES | ||
| 3.1L | CAPACITIES | ||
| Brakes | |||
| Bleeding Sequence | RR, LR, RF, LF | ||
| Disc Brakes | |||
| Service Specifications | DISC BRAKE SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Drum Brakes | |||
| Service Specifications | DRUM BRAKE SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Charging | |||
| Generator | GENERATOR USAGE CHART | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Drive Belts | |||
| Adjustment | BELT ADJUSTMENT | ||
| Drive Belt Routing | See appropriate figure under SERPENTINE BELT ROUTING | ||
| Engine Cooling | |||
| General Service Specifications | COOLING SYSTEM SPECIFICATIONS | ||
| Radiator Cap Pressure | 15 psi | ||
| Thermostat R & I | |||
| 2.4L | THERMOSTAT | ||
| 3.1L | THERMOSTAT | ||
| Water Pump R & I | |||
| 2.4L | WATER PUMP | ||
| 3.1L | WATER PUMP | ||
| Engine Mechanical | |||
| 2.4L | |||
| Compression | COMPRESSION | ||
| Oil Pressure | At least 10 psi (69.0 kPa) at 900 RPM, or 30 psi (206.9 kPa) at 2000 RPM | ||
| Overhaul | ENGINE SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| 3.1L | |||
| Compression | COMPRESSION | ||
| Oil pressure | Minimum 15 psi (103.4 kPa) at 1100 RPM | ||
| Overhaul | ENGINE SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Fluid Specifications | See FLUIDS under MAINTENANCE/FLUIDS tab. From within Manager or Service Writer, click the "30/60/90 Interval" or "Maint." button. | ||
| Flywheel/Flex Plate/Drive Plate Torque | |||
| 2.4L | |||
| Step 1 | 22 Ft. lbs. (30 N.m) | ||
| Step 2 | Additional 45 Degrees | ||
| 3.1L | 61 Ft. lbs. (83 N.m) Apply Thread Locker (12345382) | ||
| Fuel System | |||
| Pressure Specification | 41-47 psi (282.7-324.1 kPa) | ||
| Fuel Pressure Test Procedure | |||
| 2.4L | FUEL SYSTEM PRESSURE TEST | ||
| 3.1L | FUEL SYSTEM PRESSURE TEST | ||
| Fuel Filter Location | Under rear of car, rearward of fuel tank. | ||
| Fuel Filter R & I | |||
| 2.4L | FUEL FILTER | ||
| 3.1L | IN-LINE FUEL FILTER | ||
| Ignition | |||
| Firing Order & Cylinder Identification | |||
| 2.4L | FIRING ORDER | ||
| 3.1L | FIRING ORDER | ||
| Ignition Wires (Resistance) | 30,000 Ohms Maximum | ||
| Ignition Wires (Routing) | |||
| 2.4L | NA | ||
| 3.1L | FIRING ORDER | ||
| Spark Plug | |||
| 2.4L | |||
| Type | AC 41-910 | ||
| Gap | .060 In. (1.52 mm) | ||
| Torque | 13 Ft. lbs. (18 N.m) | ||
| 3.1L | |||
| Type | AC 41-940 | ||
| Gap | .060 In. (1.52 mm) | ||
| Torque | 11 Ft. lbs. (15 N.m) | ||
| Starting | |||
| Starter | ON-VEHICLE TESTING | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Wheel Alignment | |||
| Adjustment Specifications | WHEEL ALIGNMENT SPECIFICATIONS | ||
| Torque | TORQUE SPECIFICATIONS | ||
| Wheel & Tire | |||
| Wheel Lug Nut Torque | 100 Ft. lbs. (136 N.m) | ||