Technical Service Bulletins: Other Variant
WARNING: This page is about the Achieva SC, 2.4 T, Automatic, 4T40E/MN4, which is a different variant/trim than selected.
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- Information on GM ACR2000 (J-43600) and New Refrigerant Recovery Recharging Equipment Standard SAE J2788 (07-01-38-004)
- New PAG Oil Released (02-01-39-004B)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- J 44551 A/C Suction Screen Kit Repair Recommendations And Procedures After Catastrophic Compressor Failures (01-01-39-003A)
- A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
- Diagnostic Information To Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
- Essential Tool J 43600 ACR 2000 (00-01-38-006)
- PUREGUARD 2 Operating Alert (73-12-13)
- Service Issues For R12/R134A Air Conditioning System (73-12-04)
- Reference Chart For A/C COMPRESSSOR Seal Washers (63-12-15)
- Accessories & Equipment
- Accessories Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- Information on Error Codes on Radio Display - Their Cause and Corrective Action (64-90-04A)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Accessory Drive Belts
- Air Bag, SRS
- General Motors Position Statement on Installation of Used, Salvaged, or Imitation Air Bag System Components (08-09-41-003)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- Frontal Supplemental Inflatable Restraints (SIR) On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
- Operating Vehicle With Sir Warning Light Illuminated (83-81-34)
- Frontal Air Bag On-Off Switch Kits (99-09-41-004)
- Revised Supplemental Inflatable Restraint Labels (73-01-07)
- Sir Module Shipping/Return Procedures (31-90-04A)
- Anti-Lock Brakes
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- GM Training - August 2009 New Course Information (For U.S. Dealers and Aftermarket) (09-00-89-035)
- Abs Indicator Lamp On, DTC 21, 22, 32 Or 33 Set (63-50-15B)
- Abs Light On - DTC'S 46 And 86 Set (73-50-26)
- Anti-Theft Systems
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Key Code Information (99-00-89-011E)
- Remote Keyless Entry Operational Characteristics (99-08-52-005C)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Trap Resistant Rear Compartment Kit (99-08-66-002A)
- Door Handles On White Painted Vehicle Turning Yellow (83-17-04)
- Information - Essential Tool J-43241 Remote Keyless Entry And Passive Keyless Entry Transmitter Tester (83-90-12)
- SMU - Section 6E - DTC P1601 - Serial Communication (61-65-67)
- Automatic Trans
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Release Of DEXRON®-VI Automatic Transmission Fluid (ATF) (04-07-30-037E)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Information on 4T65-E MN7, M15, M76, MN3 Automatic Transmission Case, Cooler Fitting and Torque Converter Drain Back Check Ball Change (04-07-30-017B)
- Transmission Oil Leaking From Transmission Vent (Replace Transmission Case Cover (Channel Plate) Gasket) (01-07-30-032E)
- No Reverse, Second Gear or Fourth Gear (Replace Reaction Sun Shell with More Robust Heat Treated Parts) (00-07-30-022D)
- No Movement When Transmission is Shifted to Drive or Third - Normal Operation When Shifted to Second, First or Reverse (Replace Forward Sprag Assembly) (08-07-30-027)
- Automatic Transmission/Transaxle Torque Converter Replacement (01-07-30-010C)
- Grinding and/or Growling Noise in Park on Incline (99-07-30-030F)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- New Product Feedback Form and Process For Automatic Transmission Core Returns (01-07-30-029A)
- Transmission Fluid Leak Diagnosis (01-07-30-041B)
- Most Frequently Asked Questions And Answers For J 45096 TRANSFLOW Transmission Oil Cooling System Flushing Machine (03-07-30-027)
- MN4 (4T40-E) MN5 (4T45-E) Engineering Changes (03-07-30-006)
- 3T40/4T60/4T60-E - Grind/Growl In Park On Incline (99-07-30-030)
- New Solenoid Testing Kit From KENT MOORE (99-07-30-021)
- Cleaning Of Upper Instrument Panel Surfaces (99-08-49-006)
- Auto Trans Oil Cooler Flushing & Flow Check Process (77-71-59)
- Intermittent Neutral Or Loss Of Drive From 4TH Gear (67-71-64)
- Cold Start Rattle Noise - Diagnosis/Service Procedure (57-71-06A)
- Auxiliary Emission Control Systems
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- I/M Readiness as Part of Emission Inspection and Maintenance Program for OBD II Vehicles (00-06-04-033B)
- New Add Time For Labor Operation L2300 - Converter, Oxidation Catalytic-Replace (02-00-89-006C)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- U.S. On-Board Diagnostics (OBD) II Retrofit Program (02-06-04-039A)
- Test Guidelines For Use Of Essential Tool J 41413-200 Evaporative System Tester (01-06-04-044)
- Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
- Powertrain Control Module Product Feedback Program (00-06-04-026)
- Proper Service Of Quick Connect EVAP Connectors (00-06-04-021)
- Evaporative Emissions Testing On Vehicles (00-06-04-001)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Powertrain Control Module Reprogramming (99-06-04-053)
- SMU - Section 0B - New Crankcase Vent System Service (83-02-01)
- 3.1/3.4L Eng False DTC P0121 - Reprogram Pcm (77-65-14A)
- Guidelines For Using I/M 240 Labor Operations (72-05-06)
- 2.4L Eng VIN T No Start - Reprogram Pcm (77-65-16)
- SMU - Section 6 Revised Fuel Tank Pressure Diagnosis (71-65-43)
- SMU - Section 6E Revised DTC P0401 EGR System Flow (71-65-38)
- Oxygen Sensor Designations In Various Engines (67-65-40)
- Reprogramming Capability Using Off Board Adapter (73-65-13)
- Section 6E - Clear DTC'S After Pcm,VCM Or EGR REPLAC (61-65-59)
- Section 6E3 - Rev. DTC P1404 EGR Valve Closed Pintle (61-65-58)
- New Pcm Identification LABLE (67-65-35)
- Section 6E3 - Revised EVAP. Emissions System Check (61-65-55)
- Section 6E - Engine Controls Revised DTC P0121 Diag (61-65-44)
- Section 6E3 - DTC P1629 Theft Deterrent Crank Signal (61-65-40)
- Section 6E3 - Rev. DTC P0440, P0442, P0446 & P1441 (61-65-31A)
- Body Electrical
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Body Interior
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- SMU - Section 6E - DTC P1601 - Serial Communication (61-65-67)
- Section 8C1 - Revised Diagnostic Chart #7 (63-83-11)
- Brakes Control Systems
- Charging Systems
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Proper Diagnostic Procedures For No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, Sir, Brake, Security, Theft, Abs, Hot, DIC Messages, Lamp, Light, Battery And Generator Diag. Testing (02-06-03-012)
- Essential Tool J42000 Battery Tester (99-06-03-001)
- New Tool J 41450-B - Released For Cs Generator Diag. (83-64-09)
- SMU - Section 6D1 - Revised Parasitic Load Test (73-64-03)
- No Start Condition, Generator May No Be Charging (63-64-08)
- Collision/Avoidance
- Communication Devices
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information on OnStar® Analog-Only Systems (06-08-64-007A)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- OnStar(R) Kit Part Numbers and Compatibility (99-08-46-001A)
- Vehicle Integration of Cellular Phones and Normal Operating Characteristics (01-08-46-004A)
- OnStar(R) Proactive Parts Shipment Process (02-08-46-013A)
- Radio Telephone/Mobile Radio (Transceiver) Installation and Troubleshooting Guidelines (04-08-46-002)
- Cooling Fan
- Cooling System (Mechanical)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- DEX-COOL® Coolant - New Leak Detection Dye J 46366 - Replaces J 29545-6 (05-06-02-002B)
- Engine Coolant Recycling and Warranty Information (00-06-02-006D)
- Instructions for Using GE-47716 Vac-N-Fill Coolant Refill Tool (05-06-02-006)
- DEX-COOL(R) Engine Coolant Information (736214)
- Water Pump Weep (Install Coolant Collector) (01-06-02-012)
- Water Pump Weep (Normal condition) (00-06-02-009)
- Radiator Repair/Replacement Guidelines (99-06-02-017)
- 3.1/3.4L Eng Engine Oil Odor - REPL Rear Main Seal (87-60-02)
- Engine Oil Consumption Guidelines (76-60-04)
- DRIVEABILITY Symptoms Due To Fuel Injector Deposits (77-63-04)
- Aluminum Heater Core &/Or Radiator Service (736213A)
- Coolant Loss, Leakage, Odor (67-62-04)
- Cruise Control Systems
- Differentials & Drive Axles
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- U.S. On-Board Diagnostics (OBD) II Retrofit Program (02-06-04-039A)
- Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
- DRIVEABILITY Symptoms Due To Clogged Fuel Injectors (Clean Injectors) (99-06-04-005B)
- Powertrain Control Module Product Feedback Program (00-06-04-026)
- Evaporative Emissions Testing On Vehicles (00-06-04-001)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Powertrain Control Module Reprogramming (99-06-04-053)
- 3.1/3.4L Eng False DTC P0121 - Reprogram Pcm (77-65-14A)
- 2.4L Eng VIN T No Start - Reprogram Pcm (77-65-16)
- SMU - Section 6E Revised DTC P0401 EGR System Flow (71-65-38)
- Reprogramming Capability Using Off Board Adapter (73-65-13)
- Section 6E - Clear DTC'S After Pcm,VCM Or EGR REPLAC (61-65-59)
- Section 6E3 - Rev. DTC P1404 EGR Valve Closed Pintle (61-65-58)
- Section 6E - Engine Controls Revised DTC P0121 Diag (61-65-44)
- Section 6E3 - DTC P1629 Theft Deterrent Crank Signal (61-65-40)
- Section 6E3 - Rev. DTC P0440, P0442, P0446 & P1441 (61-65-31A)
- Entertainment Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information On Procedure To Unlock DELCO Radio With THEFTLOCK (PIC4696E)
- Changes to XM Network of Terrestrial Repeaters (08-08-46-006)
- Information on Refurbish Instead of Replace Out of Warranty Radios with Worn Graphics on Faceplate, Knobs or Buttons (08-08-44-026)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- Compact Disc (Cd) Or DVD Player Skipping, Inoperative, Sluggish And/Or Long Search Times (05-08-44-001)
- Information on Error Codes on Radio Display - Their Cause and Corrective Action (64-90-04A)
- Accessory Receptacle/Cigar Lighter Is Inoperative (99-08-45-005)
- Compact Disc (Cd) Players And Compatible CD'S (99-08-44-006)
- SMU - Section 8A New Diag Tables For Speed Sensor (73-81-32)
- (CLN) Appears On Radio Display & Does Not Turn Off (54-90-01A)
- Compact Disc Players - Use & Maintenance (64-96-01)
- Radio Diagnosis Worksheet Repair Centers (68-96-01A)
- Exhaust
- Exterior Body Panels
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- Metal Panel Bonding (02-08-98-001C)
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
- Expandable Acoustic Foam (Two Component Sound Dampener) Usage With Collision Damage Repairs (02-08-98-003)
- Exterior Lights
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- Exterior Lamp Condensation And Replacement Guideline (63-82-06A)
- SMU - Section 8A New Diag Tables For Speed Sensor (73-81-32)
- SMU - Section 6E - DTC P1601 - Serial Communication (61-65-67)
- Daytime Running Lamps On W/Ignition Off/INOP Fog LT (63-81-26)
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Use of E85 Fuels in Vehicles Not Certified by GM as being FlexFuel Compatible / Aftermarket Conversion of Vehicles to Operate on E85 Fuels (06-06-04-035A)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Usage of E85 Fuels in GM Vehicles (05-06-04-035)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
- DRIVEABILITY Symptoms Due To Clogged Fuel Injectors (Clean Injectors) (99-06-04-005B)
- Difficult To Depress Accelerator Pedal - Separation (67-63-05)
- Fuses & Circuit Breakers
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Service Alert: Concerns With Aftermarket Fuses in GM Vehicles (07-08-45-002)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- Accessory Receptacle/Cigar Lighter Is Inoperative (99-08-45-005)
- Gauges & Instrument Panels
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Verifying Odometer Accuracy (PIC3100G)
- Information On Speedometer Accuracy (08-08-49-011B)
- Information On Speedometer Accuracy (08-08-49-011)
- PRNDL Display Reduced Visibility For Approximately One Minute (02-08-72-004A)
- Information on Radio and Instrument Panel Cluster (IPC) Part Restrictions (U.S. Only) (06-00-89-038)
- Instrument Panel (I/P), Body and General Wiring Harness Repair (06-08-45-004)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Instrument Cluster Identification (78-83-03A)
- SMU - Section 8A New Diag Tables For Speed Sensor (73-81-32)
- Fuel Gauge Responds Slowly After Fueling (73-83-15)
- SMU - Section 6E - DTC P1601 - Serial Communication (61-65-67)
- Section 8A-102 Diag. Chart #5 For Daytime Running Li (63-81-34)
- General Servicing
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Information On Aluminum Heater Core and/or Radiator Replacement (73-62-13A)
- Information On New GE-48800 CoolTech Refrigerant Recovery/Recharge Equipment (08-01-38-001)
- 18 Digit "Snapshot/Charge Summary" Code No Longer Required For A/C Refrigerant System Repairs Submitted For Warranty Reimbursement (05-01-38-008B)
- Contaminated R134a Refrigerant Found on Market for Automotive Air-Conditioning Systems (06-01-39-007)
- Contaminated R-134a A/C Systems - Air Conditioning System Flushing Procedures and Universal In-Line A/C Filter Installation (83-12-21)
- J-43600 ACR 2000 Essential Refrigerant Recovery/Recharge Equipment (99-01-38-006B)
- J 44551 A/C Suction Screen Kit Repair Recommendations And Procedures After Catastrophic Compressor Failures (01-01-39-003A)
- A/C Refrigerant System Sealer And A/C System Leak Detection Guidelines (03-01-38-001)
- Automatic Air Conditioning Control Operation (99-01-39-007B)
- Diagnostic Information To Consider Before Air Conditioning Compressor Replacement (01-01-38-013A)
- Essential Tool J 43600 ACR 2000 (00-01-38-006)
- Diagnostic Procedure For A/C Refrigerant Leak (73-12-12A)
- PUREGUARD 2 Operating Alert (73-12-13)
- Aluminum Heater Core &/Or Radiator Service (736213A)
- Service Issues For R12/R134A Air Conditioning System (73-12-04)
- Air Coming From I/P Vent While In Heater Mode (63-11-09)
- Reference Chart For A/C COMPRESSSOR Seal Washers (63-12-15)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- DRIVEABILITY Symptoms Due To Fuel Injector Deposits (77-63-04)
- 2.4L Eng VIN T No Start - Reprogram Pcm (77-65-16)
- Production Spark Plug Gap Change (77-65-11A)
- Coil And Ignition Housing Characteristic Conditions (67-65-34)
- Infotainment
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information on Obtaining Replacement Navigation Discs When Radios are Exchanged - Order Replacement Navigation Disc Through Navigation Disc Center (07-08-44-007)
- OnStar(R) System Cellular Antenna Replacement Parts Availability (00-08-46-002A)
- Global Position Sensor (GPS) Performance Degradation (00-08-46-003B)
- SMU - Section 6E - DTC P1601 - Serial Communication (61-65-67)
- Interior/Exterior Trim
- Information On Proper Use Of Floor Mats (10-08-110-001L)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Information on Discoloration, Blistering, Peeling or Erosion of Various Exterior Emblems Including Chevy Bowtie (Bulletin Cancelled) (06-08-111-004B)
- Information on Maintaining Exterior Weatherstrip Appearance (99-08-64-016C)
- Plastic Wheel Nut Covers Missing and/or Loose (Replace Missing Covers and Add Sealant to All Covers) (01-03-10-009A)
- HOMELINK Transceiver/Garage Door Opener Transmitter Test Kit (01-08-97-001B)
- Trap Resistant Rear Compartment Kit (99-08-66-002A)
- Door Handles On White Painted Vehicle Turning Yellow (83-17-04)
- Water Leaking Into Passenger Compartment - Seal Vent (73-10-68)
- New Body Sealer Tape For Collision Repairs (73-10-49)
- Interior/Illumination Lights
- Lubrication System
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Engine Oil Consumption Guidelines (01-06-01-011Q)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- 60 Degree V6 Engine Oil Leak at Crankshaft Front Oil Seal (Use New Crankshaft Front Oil Seal Installer Tool EN-48869) (07-06-01-023)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- Engine Crankcase Flush (02-06-01-028)
- Cleaning Of Upper Instrument Panel Surfaces (99-08-49-006)
- 3.1/3.4L Eng Engine Oil Odor - REPL Rear Main Seal (87-60-02)
- Engine Oil Consumption Guidelines (76-60-04)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Diagnostic Tips/Recommendations When Power Steering Pump Replacement is Necessary (06-02-32-013B)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Guidelines For Essential Tool J 44721 Power Steering System Analyzer (01-02-32-004)
- Special Tool J 43435 Adjuster Locknut Wrench (83-32-10)
- Info - Essential Tool J43485 Power Steering Bleeder Adapter (83-32-09)
- Manual Trans
- Mechanical
- Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Diagnosing Accessory Drive Belt / Serpentine Belt Noise and Availability and Use of Kent-Moore EN-49228 Laser Alignment Tool - Drive Belt (08-06-01-008A)
- Engine Oil Leak at Crankshaft Rear Main Oil Seal (Install Revised Crankshaft Rear Main Oil Seal Using Revised Rear Main Seal Installer and Remover Tools) (05-06-01-019F)
- GM Performance Parts Engine Warranty Q & A (04-06-01-019A)
- Revised Mass Air Flow Core Return Requirements (06-06-04-057)
- Timing Chain Tensioner Installation Procedure (00-06-01-010A)
- Instructions To Be Followed To Aid in Obtaining Root Cause Analysis on Both OEM and Goodwrench(R) Engines, Transmissions and Transfer Cases on Vehicles with 402 km (250 mi) or Less (04-06-01-034C)
- Powertrain Quality Center For Performance Parts Engine Replacements (03-06-01-006)
- Engine Crankcase Flush (02-06-01-028)
- Engine Identification Information (02-06-01-026)
- Information On A New Engine PRELUBER Tool (02-06-01-008)
- SMU- Revised Piston Ring Gap,Crank Bearing Clearance (87-61-30)
- SMU - Section 6A 2.4L Eng Timing Chain TENSIONER SVC (67-61-22A)
- 3.1/3.4L Eng Tick Or Rattle After Cold Start Up (57-61-24A)
- 3.1/3.4L Eng Engine Oil Odor - REPL Rear Main Seal (87-60-02)
- Engine Oil Consumption Guidelines (76-60-04)
- DRIVEABILITY Symptoms Due To Fuel Injector Deposits (77-63-04)
- Engine Stall At Cold Start, Rough Idle, Misfire DTCS (77-61-09A)
- Cold Start Rattle Noise - Diagnosis/Service Procedure (57-71-06A)
- Popping Noise Heard W/Normal Movement Of Engine (63-61-11)
- Mechanical - Hydraulic
- Brake Lathe Calibration Procedure (VSS20040074)
- Brake Align® System for Brake Rotor Lateral Runout Correction (01-05-23-001B)
- On-Car Brake Lathe Specifications and Maintenance Requirements (05-05-22-001)
- Service Information Regarding Rear Brake Drum Wheel Cylinder Inspections (03-05-24-001A)
- Brake Fluid Level & Filling Recommendations (00-05-22-004)
- Snow Intrusion Into Rear Brake Drum Assemblies (00-05-24-001)
- Cleaning Of Upper Instrument Panel Surfaces (99-08-49-006)
- Revision To J 42450 Tool; Rotor/Hub Flange Cleaning (73-50-37)
- Brake Rotor Warranty Service Procedure (23-50-05B)
- Various Brake Noises When Applying Service Brake (73-50-25)
- Inspection Of Restricted Brake Pad/Caliper & Knuckle (63-50-19)
- Memory Modules
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Information On Paint Stain Under Protective Shipping Film (05-08-51-001L)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Bumps or Rust Colored Spots in Paint Due to Rail or Iron Dust (Remove Rail Dust) (43-17-01B)
- Repair Procedure for Service Sheet Metal - Craters in ELPO Surface (04-08-98-002)
- Additional Material and Source for Metal Panel Bonding Adhesives (04-08-98-001)
- Door Handles On White Painted Vehicle Turning Yellow (83-17-04)
- Windshield & Stationary Glass Adhesive Caulking Kit (83-15-16)
- Water Leaking Into Passenger Compartment - Seal Vent (73-10-68)
- Paint Peeling From Muffler - New Repair Paint (33/17/01A)
- Two Part Urethane Adhesive For Windshield Installs (73-10-54)
- New Paint Specs For BASECOAT/CLEARCOAT Systems (63-17-07A)
- Passive Restraints
- Procedures
- Rear Suspension
- Restraints Control Systems
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Proper Air Bag System Diagnosis And Service (03-09-41-003A)
- Frontal Supplemental Inflatable Restraints (SIR) On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Schedule
- Seats
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Top Tether Hardware Package For Child Restraint Seats (99-09-40-004B)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Frontal Supplemental Inflatable Restraints (SIR) On-Off Switch Kits, New Parts and Procedures (00-09-41-002)
- Dealer Installed Rear Seat Lap/Shoulder Belt Kits (99-09-40-006)
- Inoperative Power Door Locks/Locks Function Manually (63-10-41B)
- Seat Belt Latch Slides To Seat Belt Anchor Sleeve (73-16-16)
- SMU - Section 6E - DTC P1601 - Serial Communication (61-65-67)
- Starter
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Low Voltage Display on IP Gauge, Lights Dim at Stop Lights, Battery Discharged, No Start, Slow Cranking, Dim Lights at Idle, Low Generator Output (43-64-07A)
- GM Dealer Visits: Proper Management of Batteries in Dealer Parts Stock / Vehicle Inventory (08-06-03-005)
- Battery and Charging System Electrical Diagnostics (99-06-03-012)
- Battery Charging Tips (Includes Information References for HP2 Hybrid Truck [PHT] 42-volt System) (02-06-03-009C)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- Battery Specification Label (04-06-03-016)
- Battery Parasitic Drain (02-06-03-010A)
- Proper Diagnostic Procedures For No Start, No Crank, Battery, Batteries, Generator, Gauges, SES, Sir, Brake, Security, Theft, Abs, Hot, DIC Messages, Lamp, Light, Battery And Generator Diag. Testing (02-06-03-012)
- CALIF Consent Order On Settlement Of Lawsuit On Batt (00-06-03-006)
- Battery Insulator Replacement (99-06-03-002)
- Essential Tool J42000 Battery Tester (99-06-03-001)
- Weak\Dead Battery Slow Start Gen\Mil Light On (83-64-16)
- New Vehicle/Replacement Battery Warranty Instruction (82-05-01)
- DRIVEABILITY Symptoms Due To Fuel Injector Deposits (77-63-04)
- Campaign 97018 - UNDERHOOD FUSEBLOCK Cover (97018)
- SMU - Section 6D1 - Revised Parasitic Load Test (73-64-03)
- Steering Column
- Steering Control Systems
- Steering Gear
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Special Tool J 43435 Adjuster Locknut Wrench (83-32-10)
- Info - Essential Tool J43485 Power Steering Bleeder Adapter (83-32-09)
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
- GM Training - GM Moveable Roof Systems Hands-On (#12040.30H) (U.S. Dealers) (This is not a Saturn STS Requirement) (08-00-89-027)
- Vehicles Equipped With WEBASTO Sunroof System (99-08-67-003)
- Door Handles On White Painted Vehicle Turning Yellow (83-17-04)
- Suspension Control Systems
- System
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Prior To Any Circuit Testing (PIP5094A)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Normal Characteristics of Malfunction Indicator Lamp (MIL) During On-Board Diagnostic (OBD) Inspection/Maintenance (I/M) Testing (06-06-04-037)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Misfire DTCs P0300, P1380, P1381 and Catalytic Converter Damage Due to Installation of Alarm Systems (02-06-05-004B)
- Warranty Coverage Change for Emission-Related Reprogramming Events (PCM, ECM and TCM) (04-06-04-036)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- U.S. On-Board Diagnostics (OBD) II Retrofit Program (02-06-04-039A)
- Test Guidelines For Use Of Essential Tool J 41413-200 Evaporative System Tester (01-06-04-044)
- Evaporative Emissions DTC P0440, P0441, P0442, P0446 (00-06-04-011A)
- DRIVEABILITY Symptoms Due To Clogged Fuel Injectors (Clean Injectors) (99-06-04-005B)
- Powertrain Control Module Product Feedback Program (00-06-04-026)
- Proper Service Of Quick Connect EVAP Connectors (00-06-04-021)
- Evaporative Emissions Testing On Vehicles (00-06-04-001)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- Powertrain Control Module Reprogramming (99-06-04-053)
- SMU - Section 0B - New Crankcase Vent System Service (83-02-01)
- 3.1/3.4L Eng False DTC P0121 - Reprogram Pcm (77-65-14A)
- 3.1/3.4L Eng Engine Oil Odor - REPL Rear Main Seal (87-60-02)
- Engine Oil Consumption Guidelines (76-60-04)
- DRIVEABILITY Symptoms Due To Fuel Injector Deposits (77-63-04)
- Guidelines For Using I/M 240 Labor Operations (72-05-06)
- 2.4L Eng VIN T No Start - Reprogram Pcm (77-65-16)
- Engine Stall At Cold Start, Rough Idle, Misfire DTCS (77-61-09A)
- Production Spark Plug Gap Change (77-65-11A)
- SMU - Section 6 Revised Fuel Tank Pressure Diagnosis (71-65-43)
- SMU - Section 6E Revised DTC P0401 EGR System Flow (71-65-38)
- Difficult To Depress Accelerator Pedal - Separation (67-63-05)
- Oxygen Sensor Designations In Various Engines (67-65-40)
- Reprogramming Capability Using Off Board Adapter (73-65-13)
- Coolant Loss, Leakage, Odor (67-62-04)
- Section 6E - Clear DTC'S After Pcm,VCM Or EGR REPLAC (61-65-59)
- Section 6E3 - Rev. DTC P1404 EGR Valve Closed Pintle (61-65-58)
- Coil And Ignition Housing Characteristic Conditions (67-65-34)
- New Pcm Identification LABLE (67-65-35)
- Section 6E3 - Revised EVAP. Emissions System Check (61-65-55)
- Section 6E - Engine Controls Revised DTC P0121 Diag (61-65-44)
- Section 6E3 - DTC P1629 Theft Deterrent Crank Signal (61-65-40)
- Section 6E3 - Rev. DTC P0440, P0442, P0446 & P1441 (61-65-31A)
- Towing
- Transfer Case
- Transmission Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Prior To Any Circuit Testing (PIP5094A)
- Expanded Coverage For Remanufacture And Return (R&R) Electronic Control Modules (GMNA Only) (13-00-89-009A)
- Warranty Coverage for Emission-Related Reprogramming Events (PCM, ECM and TCM) (4-06-04-036E)
- Diagnostic Trouble Code (DTC) P0757 Set, Malfunction Indicator Lamp (MIL) Illuminated, Poor Performance of Transmission, Transmission Slipping (Clean Transmission Valve Body and Case Oil Passages of Debris) (01-07-30-038D)
- Information Regarding Automatic Transmission Shift Lock Control Function (03-07-30-043A)
- Labor Operation Assignments For All Control Module Reprogramming (02-06-04-057E)
- Malfunction Indicator Lamp (MIL) On, Transmission Stuck in Second or Third Gear, Instrument Cluster Inoperative (Verify and Repair Source of Voltage Loss In Transmission Solenoid Power Supply Circuit) (01-07-30-002E)
- Inspection Of Related Wiring Harness Connections When Diagnosing Misc. DTCS, Intermittent DRIVEABILITY Concerns, Hard Start, No Start, Incorrect Gauges, INOP I/C Systems, SES/4WD Lamps Illuminated (03-06-04-012A)
- ADM MSG - Important Programming/TIS Information For Technicians (VSS20020120)
- Year 2000 (Y2K) And Vehicle Electronics (99-00-89-022)
- New Solenoid Testing Kit From KENT MOORE (99-07-30-021)
- SMU - 6E Revised DTC P0705 Scan Tool Trans Table (77-65-37)
- Warning Systems
- Wheel Alignment
- Wheel Hubs
- Wheels & Tire System
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- Information on Replacement Wheel Weights (09-03-10-017)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Use of Chrome or Chrome Plated Steel Valve Caps on Aluminum Valve Stems (08-03-10-005A)
- Performance Characteristics of Vehicles with Accessory Wheel/Tire Assemblies Installed as "Upsized" to Original Equipment (05-03-10-005D)
- Minimizing Damage to Tire Pressure Monitor (TPM) Sensors During Tire Mounting/Dismounting (08-03-10-007)
- Pitting and Brake Dust on Chrome Wheels (04-03-10-012B)
- Proper Use of OEM Service Wheel Weights, Marring and/or Damage Due to Use of Non-OEM and/or Incorrect Wheel Weight Installation (06-03-10-004)
- Use Recommended Tire Mounting Lubricant To Prevent Tires From Slipping on Chrome Wheels (T-93-93)
- Tire Sidewall Damage (01-03-10-011)
- Original Equipment Chrome Plated Aluminum WEEEL Id (99-03-10-102)
- Revision To J 42450 Tool; Rotor/Hub Flange Cleaning (73-50-37)
- Guidelines For Using E0420 Wheel Replace (72-05-05)
- SMU - Revised Tire/Wheel PROPSHAFT Rotation Sheet (63-01-03)
- Window Motors & Regulators
- Urethane Adhesives For Stationary Glass And Other Applications (02-08-48-001A)
- Door Handles On White Painted Vehicle Turning Yellow (83-17-04)
- Water Leaking Into Passenger Compartment - Seal Vent (73-10-68)
- Inoperative Power Door Locks/Locks Function Manually (63-10-41B)
- Windshield Reveal Molding Etching Due To Tape USEAGE (73-10-52)
- New Body Sealer Tape For Collision Repairs (73-10-49)
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Prior To Any Circuit Testing (PIP5094A)
- Information on Changes to the SI Table of Contents, Electrical Connectors, Terminal Testing/Repair, and the Importance of J-38125 Electrical Terminal Repair Kit Maintenance (06-08-45-001)
- SMU - Section 6E - DTC P1601 - Serial Communication (61-65-67)
- No Start Condition, Generator May No Be Charging (63-64-08)