Common Specifications & Procedures
PATHFINDER COMMON SPECIFICATIONS & PROCEDURES
| System | Specification/Procedure | ||
|---|---|---|---|
| Air Conditioning | |||
| Service | SERVICE DATA AND SPECIFICATIONS (SDS) | ||
| Torque | See Torque Specifications in Text and applicable graphics in HEATER & AIR CONDITIONING SYSTEM article. | ||
| Axle Nut/Hub Nut | |||
| Front Axle Nut | 137 N.m (101 Ft.lbs) | ||
| Rear Axle Nut | 240 N.m (177 Ft.lbs) | ||
| Battery | BATTERY | ||
| Brakes | |||
| Bleeding Sequence | BLEEDING BRAKE SYSTEM | ||
| Disc Brakes | |||
| Front | FRONT DISC BRAKE | ||
| Rear | REAR DISC BRAKE | ||
| Torque | |||
| Front | See Torque Specifications in applicable graphics under FRONT DISC BRAKE . | ||
| Rear | See Torque Specifications in applicable graphics under REAR DISC BRAKE . | ||
| Charging | |||
| Generator | GENERATOR | ||
| Torque | REMOVAL AND INSTALLATION | ||
| Drive Belts | |||
| VQ40DE (4.0L) | |||
| Belt Routing | DRIVE BELTS | ||
| Belt Tensioning | The drive belt tension is automatically adjusted by an auto tensioner. | ||
| VK56DE (5.6L) | |||
| Belt Routing | DRIVE BELTS | ||
| Belt Tensioning | The drive belt tension is automatically adjusted by an auto tensioner. | ||
| Engine Cooling | |||
| General Service Specifications | |||
| VQ40DE (4.0L) | SERVICE DATA AND SPECIFICATIONS (SDS) | ||
| VK56DE (5.6L) | SERVICE DATA AND SPECIFICATIONS (SDS) | ||
| Radiator Cap Pressure | |||
| VQ40DE (4.0L) | 98 - 118 kPa (1.0 - 1.2 kg/cm2 , 14 - 17 psi) | ||
| VK56DE (5.6L) | 98 - 118 kPa (1.0 - 1.2 kg/cm2 , 14 - 17 psi) | ||
| Thermostat R & I | |||
| VQ40DE (4.0L) | THERMOSTAT AND WATER PIPING | ||
| VK56DE (5.6L) | THERMOSTAT AND WATER PIPING | ||
| Water Pump R & I | |||
| VQ40DE (4.0L) | WATER PUMP | ||
| VK56DE (5.6L) | WATER PUMP | ||
| Engine Mechanical | |||
| Compression | |||
| VQ40DE (4.0L) | CHECKING COMPRESSION PRESSURE | ||
| VK56DE (5.6L) | CHECKING COMPRESSION PRESSURE | ||
| Oil Pressure | |||
| @ Idle | 98 kPa (1.0 kgf/cm2 , 14 psi) or more | ||
| @ 2000 RPM | 294 kPa (3.0 kgf/cm2 , 43 psi) or more | ||
| Overhaul | |||
| VQ40DE (4.0L) | SERVICE DATA AND SPECIFICATIONS (SDS) | ||
| VK56DE (5.6L) | SERVICE DATA AND SPECIFICATIONS (SDS) | ||
| Torque | |||
| VQ40DE (4.0L) | See Torque Specifications in Text and applicable graphics in ENGINE MECHANICAL (VQ40DE) article. | ||
| VK56DE (5.6L) | See Torque Specifications in Text and applicable graphics in ENGINE MECHANICAL (VK56DE) article. | ||
| Fluid Specifications | See FLUIDS under MAINTENANCE tab. From within Manager or Service Writer, click the "30/60/90 Interval" or "Maint." button. | ||
| Flywheel/Flex Plate (Drive Plate) Torque | 88 N.m (65 Ft.lbs) | ||
| Fuel System | |||
| Fuel Pressure Release Procedure | |||
| VQ40DE (4.0L) | FUEL PRESSURE RELEASE | ||
| VK56DE (5.6L) | FUEL PRESSURE RELEASE | ||
| Fuel Pressure Specification | @ Idling: Approximately 350 kPa (3.57 kg/cm2 , 51 psi) |
||
| Fuel Pressure Test Procedure | |||
| VQ40DE (4.0L) | FUEL PRESSURE CHECK | ||
| VK56DE (5.6L) | FUEL PRESSURE CHECK | ||
| Fuel Filter Location | In Tank Type | ||
| Fuel Filter R & I | FUEL LEVEL SENSOR UNIT, FUEL FILTER AND FUEL PUMP ASSEMBLY | ||
| Ignition | |||
| Firing Order & Cylinder Identification | |||
| VQ40DE (4.0L) | FIRING ORDER & CYLINDER IDENTIFICATION | ||
| VK56DE (5.6L) | FIRING ORDER & CYLINDER IDENTIFICATION | ||
| Ignition Wires (Resistance) | Engine has coil-on-plug ignition. | ||
| Ignition Wires (Routing) | Engine has coil-on-plug ignition. | ||
| Spark Plugs | |||
| VQ40DE (4.0L) | SPARK PLUG Tightening torque: 24.5 N.m (18 Ft. Lbs) |
||
| VK56DE (5.6L) | SPARK PLUG Tightening torque: 24.5 N.m (18 Ft. Lbs) |
||
| Starting | |||
| Starter | STARTER MOTOR | ||
| Torque | See Torque Specifications in Text and applicable graphics in REMOVAL AND INSTALLATION . | ||
| Wheel Alignment | |||
| Adjustment Specifications | |||
| Front | WHEEL ALIGNMENT (UNLADEN*1) | ||
| Rear | WHEEL ALIGNMENT (UNLADEN*) | ||
| Torque | |||
| Front | See Torque Specifications in Text and applicable graphics in FRONT SUSPENSION article. | ||
| Rear | See Torque Specifications in Text and applicable graphics in REAR SUSPENSION article. | ||
| Wheel & Tire | |||
| Wheel Lug Nut Torque | 133 N.m (14 kg-m, 98 ft-lb) | ||
| How To Use Nissan Service Information | |||
| Includes: Standard Bolt Torque Symbol Identification General Connector Info |
GENERAL INFORMATION | ||