Section 1 (Manual Transaxle On-Vehicle Service - Lancer Evolution)
WARNING: This page is about a different variant/trim than selected.
- General Information
- Service Specification
- Lubricant
- Special Tools
- Manual Transaxle Diagnosis
- Diagnosis
- Introduction
- Troubleshooting Strategy
- Diagnostic Function
- Diagnostic Trouble Code Chart
- Symptom Chart
- Diagnostic Trouble Code Procedures
- DTC C1000: Stoplight Switch System
- DTC C100A
, C1015 , C1020 , C102B : Wheel Speed Sensor System (Faulty Circuit) - DTC C1011
, C101C , C1027 , C1032 : Wheel Speed Sensor System (Faulty Signal) - DTC C1014
, C101F , C102A , C1035 : Wheel speed sensor system (characteristics abnormality) - DTC C1078: Tire Turning Malfunction
- DTC C1219: Steering Wheel Sensor System (Faulty Signal)
- DTC C121A: Steering Wheel Sensor System (neutral learning abnormality)
- DTC C123C: G and Yaw Rate Sensor (Faulty Signal)
- DTC C1242: G and Yaw Rate Sensor (Longitudinal G Output Data Error)
- DTC C1610: AWC Actuator Power Supply Electronic Relay Malfunction
- DTC C1611: AWC Pressure Sensor System (Low Voltage)
- DTC C1612: AWC Pressure Sensor System (High Voltage)
- DTC C1613: AWC Mode Select Switch System (Clogging)
- DTC C1613: AWC Mode Select Switch System (Clogging)
- DTC C1614: Parking Brake Switch System (Clogging ON)
- DTC C1615: Brake control prohibition request
- DTC C1616: Cranking Signal System (ON sticking)
- DTC C1617: AWC CAN Main Data System (data not received)
- DTC C1618: AWC CAN Local Data System (data not received)
- DTC C161C: ACD Proportioning Valve System (Malfunction)
- DTC C161D: Electric Pump Relay Circuit System (Malfunction)
- DTC C161E: Electric Pump Relay Circuit System (Stuck)
- DTC C1622: ACD Controlled System (Malfunction)
- DTC C1623: Brake Controlled System (Malfunction)
- DTC C1624: AWC-ECU System (Internal Malfunction)
- DTC C1625: AWC Pressure Sensor System (Abnormal Power Supply Voltage)
- DTC C2100: Battery Voltage Malfunction (Low Voltage)
- DTC C2101: Battery Voltage Malfunction (High Voltage)
- DTC C2114: G and Yaw Rate Sensor Power Supply (Low Voltage)
- DTC C2115: G and Yaw Rate Sensor Power Supply (High Voltage)
- DTC C2203: VIN not Recorded
- DTC C2204: G and Yaw Rate Sensor System (Internal Malfunction)
- DTC C2205: Steering Wheel Sensor System (Internal Malfunction)
- DTC U0001: Bus Off
- DTC U0100: Engine Time-out Error
- DTC U0101: TC-SST Time-out Error
- DTC U0121: ASC Time-out Error
- DTC U0126: Steering Wheel Sensor Time-out Error
- DTC U0141: ETACS Time-out Error
- DTC U0401: Engine Data Error
- DTC U0428: Steering Wheel Sensor Data Error
- DTC U0431: ETACS Data Error
- DTC U1003: Bas-off (Local CAN)
- DTC U1415: Coding incomplete/fail
- DTC U1417: Coding Data Malfunction
- DTC U1425: TC-SST Data Error
- DTC U1426: ASC Data Error
- DTC U1427: Wheel Speed Sensor Data Error
- DTC U1428: G and Yaw Rate Sensor Data Error
- Symptom Procedures
- INSPECTION PROCEDURE 1: Communication between the scan tool and AWC-ECU cannot be established
- INSPECTION PROCEDURE 2: Mode does not change even when the AWC switch is pressed
- INSPECTION PROCEDURE 2: Mode does not change even when the AWC switch is pressed
- INSPECTION PROCEDURE 3: AWC-ECU power supply circuit malfunction
- Data List Reference Table
- Special Function Reference Table
- AWD-Ecu Terminal Voltage Reference Chart For ACD
- On-Vehicle Service
- Transaxle Control
- Transfer Assembly
- Transaxle Assembly
- Removal And Installation
- Notes
- Removal Service Points
- < <A>> Strut Tower Bar Removal
- < <B>> Shift Cable/Select Cable Assembly And Cable Bracket Removal
- < <C>> Starter Mounting Bolt Removal
- < <D>> Clutch Release Bearing Disconnection
- < <E>> Transaxle Assembly Upper Part Mounting Bolt Removal
- < <F>> Transaxle Mounting Bracket Installation
- < <G>> Engine Assembly Support
- Installation Service Points
- Removal And Installation
- AWC-Ecu
- Sensor, Switch And Relay
- Hydraulic Unit