Section 1917 (Steering And Wheel Alignment - Repair)
WARNING: This page is about a different car, the 2010 BMW 528i, 2009 BMW 528i, and 2008 BMW 528i. However, it is still accessible from the selected car via links, so may be relevant.
- Electronic Chassis Alignment
- 00 Danger of poisoning if oil is ingested/absorbed through the skin
- 00 Risk of injury if oil comes into contact with eyes and skin
- 00 Safety instructions for handling oil
- 00... ... Raising vehicle with trolley jack
- 31 00 ... Front axle + steering: wheel/chassis alignment check must be carried out after the following work
- 31 00 ... Instructions (damage to suspension)
- 32 ... . Overview of steering
- 32.. .. Overview of steering wheel / casing components / lock cylinder
- 32 00... Chassis/wheel alignment check procedure
- 32 00... General chassis and suspension definitions
- 32 00... General information and definitions
- 32 00... Identification of suspension without label
- 32 00... Identifying suspension from label on front axle
- 32 00... Information on replacing steering gear after accident damage
- 32 00... Moving vehicle into design position
- 32 00... Moving vehicle into normal position
- 32 00... Performing rim runout compensation
- 32 00... Test conditions for chassis/wheel alignment check
- 32 00... Troubleshooting after wheel/chassis alignment check on front axle
- 32 00... Troubleshooting after wheel/chassis alignment check on rear axle
- 32 00 150 KDS chassis/wheel alignment check with load up to design position
- 32 00 155 KDS chassis/wheel alignment check with ride-height measurement without load
- 32 00 610 Adjusting toe-in and camber on front axle
- 32 00 620 Adjusting rear axle
- 32 10 005 Adjustment for active front steering
- 33 00... Rear axle: wheel/chassis alignment check must be carried out after the following work
- 61 31 996 Carrying out steering angle sensor adjustment
- Mechanical Steering Gear
- Steering Gear With Servo Unit
- 32 13 006 Bleeding power steering (version with Dynamic Drive)
- 32 13 006 Bleeding power steering unit
- 32 13 060 Removing and installing/replacing power steering gear
- 32 13 065 Removing and installing/replacing active front steering power steering gear
- 32 13 650 Removing and installing/replacing EH converter for Servotronic
- Steering Arms, Tie Rod Ends, Steering Damper
- Steering Column
- 32 31 004 Removing and installing / replacing upper section of steering column trim
- 32 31 010 Removing and installing/replacing front section of steering column cover
- 32 31 020 Removing and installing / replacing lower section of steering column trim
- 32 31 070 Removing and installing / replacing lower section of steering spindle
- 32 31 082 Removing and installing/replacing steering angle sensor
- 32 31 087 Removing and installing/replacing steering column lock
- 32 31 090 Removing and installing/replacing steering column
- 32 31 102 Replacing steering spindle sleeve
- 32 31 241 Replacing adjusting lever for steering column (steering column with Nacam clamp)
- Steering Wheel
- 32 33 ... Replacing decorative strip for sport steering wheel
- 32 33 001 Removing and installing/replacing steering wheel (from 03/2007)
- 32 33 010 Removing and installing/replacing sport steering wheel
- 61 31 233 Removing and installing/replacing Lane Departure Warning motor electronics (sport steering wheel)
- 61 31 238 Removing and installing/replacing Lane Departure Warning motor electronics (standard steering wheel)
- Steering Wheel For Airbag
- 32 34 020 Removing and installing/replacing airbag unit (Version 1)
- 32 34 020 Removing and installing/replacing airbag unit (Version 2)
- 32 34 030 Removing and installing / replacing airbag unit (sport steering wheel)
- 65 77 ... Notes on scrapping BMW vehicles with gas generators (central airbag control unit, airbag system)
- 72 00 ... Safety regulations for handling components with gas generators
- 72 12 ... Procedure after airbag triggering as result of an accident
- Pump And Oil Supply
- 32 41 ... Instructions for removing and installing ear clips
- 32 41 ... Instructions for using special tool 32 4 000
- 32 41 ... Notes on hydraulic line with quick-connect coupling
- 32 41 ... Replacing level switch for Dynamic Drive fluid reservoir
- 32 41 009 Checking function of power steering vane pump
- 32 41 033 Removing and installing (replacing) power steering pump for power steering gear with active front steering
- 32 41 037 Removing and installing power steering pump for power steering gear with Dynamic Drive (N52, N53)
- 32 41 060 Removing and installing (replacing) power steering vane pump (N52, N53)
- 32 41 061 Replacing power steering vane pump
- 32 41 100 Removing and installing/replacing belt pulley on vane pump for power steering
- 32 41 250 Removing and installing/replacing fluid reservoir for power steering
- 32 41 253 Removing and installing / replacing fluid reservoir for power steering with Dynamic Drive / active front steering
- 32 41 311 Replacing suction line for power steering (N52, N53)
- 32 41 332 Replacing pressure line for power steering (N52, N53)
- 32 41 341 Replacing cooler return line for power steering
- 32 41 351 Replacing return line for power steering (N52, N53)
- Electronic Power Steering
- Troubleshooting