Technical Service Bulletins
- A/C Compressor
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- A/C "O" Ring Usage Table (90-14-8)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- A/C Drier - Replace When Major Component Serviced (88-25-5)
- A/C Clutch Slips/Overheats - New Clutch Assembly (88-2-4)
- A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
- A/C Clutch Damage From OVERTIGHTEN - Torque Wrench (86-22-7)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- A/C Compressor Clutch Assembly I.D. (85-23-3)
- Accessories Control Systems
- Anti-Lock Brakes
- Anti-Theft Systems
- No Crank - Low State Of Battery Charge (91-10-8)
- Latches - Door - Replacement Required (91-8-4)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Automatic Trans
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- A/T Cooler Line Connections Leak - Modify Connectors (87-18-13)
- New ATF Applications Chart (87-18-14)
- Intermediate Clutch Return Spring Retaining Ring Tab (87-15-6)
- ATX Transaxle - Revised Planetary Gears (87-2-14)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- A/T No Speedo/Cruise/GOVERNER - Drive Gears/GOVERNER (86-11-18)
- New Synthetic Trans Fluid Information/Application (86-11-17)
- ATX Trans New Converter Hub Seal Design/Service (86-2-17)
- ATX Revised In-Chassis Differential R & R (86-1-6)
- Speedometer Gear Applications (85-21-4)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- One-Way Clutch Holding Tool Modification (85-22-13)
- Auxiliary Emission Control Systems
- 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- ECM Spout Line Connector Locations (86-4-17)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- 1.6/1.9/2.0 L Eng Poor Drivability - PCV Vacuum Tree (86-22-14)
- 1.6/1.9L Eng Idle Speed Varies - Throttle Plate Adj (86-7-13)
- 1.9L Eng Hesitate/Bad Idle - New HEGO Wire Connector (89-11T-3)
- 1.9L Eng PCV Valve "Hoot" Noise - Replace Valve/Hose (86-4-18)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
- Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
- Low Spark/Poor Performance - Spout Connector Sleeve (86-20-7)
- Low Spark/Poor Performance - Spout Connector Sleeve (86-17-10)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Blowers, Superchargers & Turbochargers
- Body Interior
- Electrical Diode Identification And Replacements (96-24-6)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Latches - Door - Replacement Required (91-8-4)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- 1.9/2.0/2.3L Eng Surge/Stall - Non Ford A/C Fix Kit (86-24-5)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Brakes Control Systems
- Charging Systems
- Clutch
- Cooling Fan
- Cooling System (Mechanical)
- Use Of Recycled Engine Coolant - Service Tip (95-18-2)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Cooling System - Use Of Recycled Engine Coolant (90-4-10)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Low Coolant Warning System Kit (88-1-12)
- 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- 1.6/2.3/2.9/3.0/5.0L Eng Hesitates - Dirty Injectors (86-13-22)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- 1.6/1.9/2.0/2.3L Non Ac Eng No Rad Fan - Cir Breaker (86-5-2)
- 1.9L Eng Oil Leak At Int Manifold- New Head Gasket (86-5-5)
- 2.0L Eng Revised Fuel Conditioner Assembly Servicing (85-23-11)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Fuel Supply/Return Spring Locks Hard To Install (86-10-7)
- High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
- Cruise Control Systems
- Differentials & Drive Axles
- Engine Control Systems
- 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Fuel Line Spring Lock Coupling R & R (87-3-8)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- ECM Spout Line Connector Locations (86-4-17)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- 1.6/1.9/2.0 L Eng Poor Drivability - PCV Vacuum Tree (86-22-14)
- 1.6/1.9L Eng Idle Speed Varies - Throttle Plate Adj (86-7-13)
- 1.9L Eng Hesitate/Bad Idle - New HEGO Wire Connector (89-11T-3)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
- Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
- Low Spark/Poor Performance - Spout Connector Sleeve (86-20-7)
- Low Spark/Poor Performance - Spout Connector Sleeve (86-17-10)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Entertainment Systems
- No Crank - Low State Of Battery Charge (91-10-8)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- Approved Radio Servicing Procedures (85-22-5)
- Door Speaker Water Damage - New Speaker Cover (86-17-5)
- Engine Miss/Surge Radio Noise - IGNITON Rotor Grease (85-21-8)
- Mechanically Tuned Radio/Cassette Unstable Reception (85-19-4)
- Radio IGN Noise - Confirm Distributor Rotor Lube (86-17-6)
- Exhaust
- Exterior Body Panels
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- High Mount BRAKELAMP Moisture: Resealing Procedure (87-24-1)
- Sealer Drips Onto Interior/Trunk: Cleaning Products (86-21-3)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- "B" Pillar Crack - Quarter Panel Reinforcement (86-6-6)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Fuel Line Spring Lock Coupling R & R (87-3-8)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Gas Check - Gasoline Testing Kit (86-13-21)
- Fuel Pressure Tool (86-11-21)
- New O-Ring Part # For Fuel Supply/Return Spring Lock (86-12-7)
- Fuses & Circuit Breakers
- Electrical Diode Identification And Replacements (96-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- New Micro-Pin Terminal Connectors Locking/Unlocking (87-7-7)
- Wiring System Diagnosis Cautions (87-4-8)
- New Waterproof Butt Splice Wire Connector (86-3-11)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Wiring Diagram Symbols Explanation (85-11-5)
- 1.6/1.9/2.0/2.3L Non Ac Eng No Rad Fan - Cir Breaker (86-5-2)
- Gauges & Instrument Panels
- Fuel Tank Sending Unit Wiring Damaged - New Wiring (89-14-6)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- False Lamp Out Warnings - Trailer Lighting Install. (88-2-6)
- Low Coolant Warning System Kit (88-1-12)
- Revised Electronic Clock Diagnostic Process (86-13-9)
- A/T No Speedo/Cruise/GOVERNER - Drive Gears/GOVERNER (86-11-18)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- Speedometer Gear Applications (85-21-4)
- Damaged Fuel Tank Sending Unit Connector Repair (89-7T-14)
- Erratic Fuel Gauge Prevention Info (86-16-3)
- New In Car Fuel Sender Test Procedure (86-15-5)
- Wiring Schematic Correction For Digital Clock (86-4-4)
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- New Refrigerant Fitting "O" Rings (91-22-5)
- A/C Chemical Smell - Clutch Cycling Pressure Switch (91-11-8)
- Air Conditioning - Refrigerant R-12 - Service Tips (91-9-7)
- A/C "O" Ring Usage Table (90-14-8)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- A/C Drier - Replace When Major Component Serviced (88-25-5)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- 1.9/2.0/2.3L Eng Poor Performance A/C Diagnostic (86-20-2)
- 1.9/2.0/2.3L Eng Surge/Stall - Non Ford A/C Fix Kit (86-24-5)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- 1.9L CARBURETED Eng Misfire - New Distributor Spring (89-1-11)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- New Distributor Drive Gear Removal Tool (87-2-18)
- 1.6/1.9L Eng Spark Plug Applications (86-23-8)
- 1.6/2.3/2.9/3.0/5.0L Eng Hesitates - Dirty Injectors (86-13-22)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
- ECM Spout Line Connector Locations (86-4-17)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- DRIVEABILITY Concerns - Moist EEC-IV Connectors (85-25-9)
- 1.6L Eng Hot Soak Stall When Braking - H.I.C. Valve (85-5-18)
- 1.6L Eng Distributor Stator Removal (83-18-12)
- 1.6/1.9/2.0L Eng Hot Engine Stalls - New Vacuum Tree (86-25-12)
- 1.9/2.0/2.3L Eng Surge/Stall - Non Ford A/C Fix Kit (86-24-5)
- 1.9L Carb Eng Miss - New Distributor CRNTRIFUGAL Adv (89-1T-18)
- 1.9L Eng New Idle Speed Setting Procedure (85-19-7)
- 2.0L Eng Revised Fuel Conditioner Assembly Servicing (85-23-11)
- Fuel Supply/Return Spring Locks Hard To Install (86-10-7)
- Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
- High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
- Low Spark/Poor Performance - Spout Connector Sleeve (86-20-7)
- Low Spark/Poor Performance - Spout Connector Sleeve (86-17-10)
- Interior/Exterior Trim
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Adhesive BODYSIDE Mouldings & Nameplates Replacement (88-10-4)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Interior Trim: Recommended Clean-Up Tips (87-2-3)
- Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
- Sealer Drips Onto Interior/Trunk: Cleaning Products (86-21-3)
- Adhesive-Backed Name Plate/Emblem Loose: Replacement (86-20-1)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Interior/Illumination Lights
- Lubrication System
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Oil Consumption Information (89-9-10)
- 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
- 1.6/1.9/2.3/2.5/3.0L Engine Oil Applications (86-23-7)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- 1.9L Eng Oil Leak At Int Manifold- New Head Gasket (86-5-5)
- 2.0L Eng Revised Fuel Conditioner Assembly Servicing (85-23-11)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Fuel Supply/Return Spring Locks Hard To Install (86-10-7)
- High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
- Normal Oil Consumption Information (89-5T-13)
- Manual Steering
- Manual Trans
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- MTX Trans Jumps Out Of 2ND/4TH Gears (85-24-9)
- Speedometer Gear Applications (85-21-4)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- MTX/MTXII/MTXIII Trans Pops Out Of 2ND/4TH - List (86-4-13)
- Mechanical
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Oil Consumption Information (89-9-10)
- Oil Dipstick Level Markings Unclear - Reading Marks (88-8-9)
- 1.9L Eng Revised Cylinder Bore Diameter Specs (87-12-10)
- 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
- 1.9/3.0/3.8L Engine Serial Number Location (87-1-9)
- 1.6/2.3/2.9/3.0/5.0L Eng Hesitates - Dirty Injectors (86-13-22)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- 1.6L Eng Hot Soak Stall When Braking - H.I.C. Valve (85-5-18)
- 1.9/2.0/2.3L Eng Surge/Stall - Non Ford A/C Fix Kit (86-24-5)
- 1.9L Eng New Idle Speed Setting Procedure (85-19-7)
- 1.9L Eng Oil Leak At Int Manifold- New Head Gasket (86-5-5)
- 2.0L Eng Revised Fuel Conditioner Assembly Servicing (85-23-11)
- Aluminum Oil Pan Drain Plug HELI-Coil Repair Info (86-24-15)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Fuel Pressure Tool (86-11-21)
- Fuel Supply/Return Spring Locks Hard To Install (86-10-7)
- High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
- Normal Oil Consumption Information (89-5T-13)
- Mechanical - Hydraulic
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brakes - Roughness Concern During Brake Application (95-6-2)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Occasional Or Intermittent Brake Squeal - Normal (90-22-6)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Riveted Rear Brake Shoe Squeal - New Bonded Shoe (86-12-5)
- Asbestos Brake & Clutch Warnings (83-22-1)
- 1.9L Carb Eng No Power Assist Cold Temp - Vac Tree (86-16-9)
- Clicking Noise At Front Disc Area During Application (88-20-6)
- Occasional\Intermittent Brake Squeal - Normal (86-6-9)
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Exterior Paint Comprehensive Repair Procedures (91-18-1)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Difficulty Matching Production Paint Colors (87-15-1)
- High Mount BRAKELAMP Moisture: Resealing Procedure (87-24-1)
- DECKLID Mounted Spoiler: Repainting Procedures (87-22-2)
- Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
- Sealer Drips Onto Interior/Trunk: Cleaning Products (86-21-3)
- Adhesive-Backed Name Plate/Emblem Loose: Replacement (86-20-1)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Surface Rust On Chassis Cosmetics Repair Info (85-23-5)
- Water Leak At Cow/Dash - Body Sealing Tips (86-25-3)
- Passive Restraints
- Rear Suspension
- Schedule
- Seats
- Sleeper
- Solar Ventilation
- Starter
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Low Charge - New Alternator Regulator Connector (87-16-5)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- 2.0L Eng Revised Fuel Conditioner Assembly Servicing (85-23-11)
- Fuel Supply/Return Spring Locks Hard To Install (86-10-7)
- High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
- Steering Column
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Inner Tie Rod In Vehicle Replacement Procedure (91-2-5)
- New Power Steering Inner Tie Rod R & R (90-14-6)
- 1.6/1.9/2.0/2.3L Eng P/S Fluid Leak - New Seals (88-9-5)
- Steering Gear Mounting Hardware (87-4-11)
- Aluminum Rivet Pin REPL For Steering Gear Tie Rod (86-8-10)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Sun Roof/T-Top/Convertible Top
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
- High Mount BRAKELAMP Moisture: Resealing Procedure (87-24-1)
- Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
- Adhesive-Backed Name Plate/Emblem Loose: Replacement (86-20-1)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Suspension Control Systems
- System
- 1.9L - Cleaning Intake Manifold When Remanufacturing (00-18-8)
- 1.9L H.O. Bucking/Jerking At Steady Highway Speeds (94-23-8)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- New Idle Air By-Pass Kit & ECA Relearn Procedure (91-7-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- Poor Cold Start/Idle/Run - Fuel Recommendations (91-8-13)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Rough Idle - Air By Pass Valve Replacement Part (89-24-4)
- TPS Service Replacement Chart (89-16-4)
- Throttle Position Sensor Screw Removal (89-14-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Distributor Gear Matched To Distributor At Assembly (89-6-11)
- 1.9L CARBURETED Eng Misfire - New Distributor Spring (89-1-11)
- EEC IV Eng & 2.3L/2.5L HSC CFI Map/Bap Sensor Applications Chart (89-1-12)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- 2.0L Diesel Revised Oil Pump/Seal/Crank/Belt Service (87-9-4)
- TFI Stall/No Start - TFI Module Diagnosis/Sealing (87-6-10)
- Fuel Line Spring Lock Coupling R & R (87-3-8)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Wiring System Testing Caution - Modify Probe Tips (87-2-5)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- 1.6/1.9L Eng Spark Plug Applications (86-23-8)
- 1.6/2.3/2.9/3.0/5.0L Eng Hesitates - Dirty Injectors (86-13-22)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Gas Check - Gasoline Testing Kit (86-13-21)
- TFI Eng No Start/Stall At Idle - New Ignition Module (86-11-25)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- ECM Spout Line Connector Locations (86-4-17)
- 1.6/1.9L Backfire On Deceleration/Shift - Diagnosis (86-3-21)
- Crank Seal Oil Leak - Diagnosis/Air Pressure Check (86-3-14)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- DRIVEABILITY Concerns - Moist EEC-IV Connectors (85-25-9)
- 1.6L Eng Hot Soak Stall When Braking - H.I.C. Valve (85-5-18)
- 1.6L Eng Distributor Stator Removal (83-18-12)
- 1.6/1.9/2.0 L Eng Poor Drivability - PCV Vacuum Tree (86-22-14)
- 1.6/1.9/2.0L Eng Hot Engine Stalls - New Vacuum Tree (86-25-12)
- 1.6/1.9L Eng Idle Speed Varies - Throttle Plate Adj (86-7-13)
- 1.9/2.0/2.3L Eng Surge/Stall - Non Ford A/C Fix Kit (86-24-5)
- 1.9L Carb Eng Miss - New Distributor CRNTRIFUGAL Adv (89-1T-18)
- 1.9L Eng Hesitate/Bad Idle - New HEGO Wire Connector (89-11T-3)
- 1.9L Eng New Idle Speed Setting Procedure (85-19-7)
- 1.9L Eng Oil Leak At Int Manifold- New Head Gasket (86-5-5)
- 1.9L Eng PCV Valve "Hoot" Noise - Replace Valve/Hose (86-4-18)
- 2.0L Eng Revised Fuel Conditioner Assembly Servicing (85-23-11)
- 2.3/2.5L Eng New Map/Bap Sensor Application Table (89-1T-19)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- EEC-IV Test Code 53 Throttle Position Sensor Diag (85-20-11)
- Fuel Supply/Return Spring Locks Hard To Install (86-10-7)
- Hard/No Start Runs Rough Corroded Dist Cap (85-22-17)
- High Throttle Effort - Corroded/Dirty Throttle Link (86-15-11)
- Injector Tester/Cleaner Tool Maintenance Info (89-15-3)
- Low Spark/Poor Performance - Spout Connector Sleeve (86-20-7)
- Low Spark/Poor Performance - Spout Connector Sleeve (86-17-10)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Wire Terminal Testing - Test Equipment Modification (86-22-11)
- Towing
- Transfer Case
- Transmission Control Systems
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Brake Shudder/Rotor Damage - Torque LUGNUTS Manually (90-19-9)
- Wheel Weights/Aluminum Rims (90-13-2)
- Aluminum Rims Leak Air - Inspection/Hot Melt Sealant (89-17-3)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Alum Wheel Leaks Air - Hot Melt Wheel Repair Info (89-9T-6)
- Aluminum Wheel Air Leak - Use Hot Melt-Stick On Leak (89-9T-6)
- Steering Drift To The Left - Check Tires/Alignment (85-23-6)
- Window Motors & Regulators
- Windshield And Interior Glass - Fog/Film (96-22-1)
- "Iridescence" Or "Mottling" In Tempered Glass (93-21-1)
- Manual Vent Windows - Glass Sticks To Weatherstrip (88-14-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Air Leak From Door Handles - Install Foam Gaskets (88-5-3)
- Manual Vent Windows Stuck - Pressure Sensitive Tape (88-5-2)
- High Mount BRAKELAMP Moisture: Resealing Procedure (87-24-1)
- Shredding Front Door Weatherstrip:Improved Materials (86-22-2)
- Adhesive-Backed Name Plate/Emblem Loose: Replacement (86-20-1)
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Electrical Diode Identification And Replacements (96-24-6)
- Generator Harness Connector Damage - Loose Contact (96-21-4)
- No Crank - Low State Of Battery Charge (91-10-8)
- Wire Harness Terminal & Connector Service Kit (89-19-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- New Micro-Pin Terminal Connectors Locking/Unlocking (87-7-7)
- Wiring System Diagnosis Cautions (87-4-8)
- New Waterproof Butt Splice Wire Connector (86-3-11)
- Engine Compartment - Use Waterproof Wire Connectors (87-2-6)
- Wiring Diagram Symbols Explanation (85-11-5)