Specifications Index

SPECIFICATIONS INDEX

System		Specification/Procedure
Air Conditioning
	Service	CAPACITIES & SPECIFICATIONS
	Torque	TORQUE SPECIFICATIONS
Axle Nut/Hub Nut (Collar Nut)
	Front	See applicable components in FRONT AXLE SHAFT
	Rear	REAR AXLE SHAFT
Battery		TEST VALUES FOR BATTERY, VOLTAGE SUPPLY
Brakes
	Bleeding Sequence	CARRYING OUT BLEEDING OPERATION
	Disc Brakes	TEST & ADJUSTMENT VALUES
	Torque	TORQUE SPECIFICATIONS
Charging
	Generator	CHECK VALUES FOR ALTERNATOR
	Torque	TORQUE SPECIFICATIONS
Drive Belts
	Adjustment	REMOVE/INSTALL POLY-V-BELT TENSIONING DEVICE
	Belt Routing	POLY-V BELT ROUTING DIAGRAM or POLY-V BELT ROUTING DIAGRAM
Engine Cooling
	General Service Specifications	CAPACITIES & SPECIFICATIONS
	Radiator Cap Pressure	CHECK VALUES FOR COOLING SYSTEM CAP
	Thermostat R & I	REMOVE/INSTALL COOLANT THERMOSTAT or REMOVE/INSTALL COOLANT THERMOSTAT FOR HIGH TEMPERATURE CIRCUIT
	Water Pump R & I	REMOVE/INSTALL COOLANT PUMP , or REMOVE/INSTALL ELECTRIC COOLANT PUMP FOR HIGH TEMPERATURE CIRCUIT or REMOVE/INSTALL LOW-TEMPERATURE CIRCUIT COOLANT PUMP FOR 48 V BATTERY
Engine Mechanical
	Compression	COMPRESSION PRESSURE CYLINDER LEAKTIGHTNESS
	Oil pressure	ENGINE OIL PRESSURE
	Overhaul	COMPLETE ENGINE - TEST & ADJUSTMENT VALUES --> ............................................................................... ENGINE TIMING - TEST & ADJUSTMENT VALUES --> ............................................................................... CRANK ASSEMBLY - TEST & ADJUSTMENT VALUES -->
	Torque	COMPLETE ENGINE - TORQUE SPECIFICATIONS --> ............................................................................... ENGINE TIMING - TORQUE SPECIFICATIONS --> ............................................................................... CRANK ASSEMBLY - TORQUE SPECIFICATIONS -->
Flywheel/Flex Plate Torque		FLYWHEEL, DRIVEN PLATE, VIBRATION DAMPER, STARTER RING GEAR
Fuel System
	Fuel Filter Location	Fuel filter is integrated into the fuel pump, see REMOVE/INSTALL FUEL PUMP AND FILL LEVEL SENSOR
	Fuel Filter R & I	REPLACE FUEL FILTER
	Pressure Release Procedure	RELIEVE FUEL PRESSURE or RELIEVE FUEL PRESSURE
	Pressure Specification	N/A
	Fuel Pressure Test Procedure	CHECK HIGH PRESSURE FUEL CIRCUIT
Ignition
	Firing Order	FIRING ORDER & CYLINDER IDENTIFICATION
	Ignition Wires (Routing)	Coil on plug
Spark Plug
	Gap	SPARK PLUGS
	Torque	IGNITION SYSTEM
Starting
	Starter	REMOVE/INSTALL STARTER
	Torque	STARTER
Wheel Alignment
	Adjustment Specifications	PERFORM WHEEL ALIGNMENT CHECK
	Torque	N/A
Wheel & Tire
	Wheel Lug Nut Torque	WHEELS