Technical Service Bulletins: Other Variant
WARNING: This page is about the Sprinter 2500, Van Cargo, which is a different variant/trim than selected.
- A/C Compressor
- Air Conditioning System Inoperative, Magnetic Clutch On Refrigerant Compressor Makes Noises, Is Damaged (LI83.55-N-059903)
- Poly-V Belt For Roof Air Conditioning (H08) Or Second Level Alternator (N62) Or Front Power Take-Off (N63) Torn (TT 09/15-K)
- Additional Poly-V Belt For Roof Air Conditioning Or Front Power Take-Off Torn (LI13.20-N-054722)
- Air Conditioning Inoperative (LI83.30-N-055607)
- Noise Complaint At Refrigerant Compressor/Belt Drive With Air Conditioning Activated And Deactivated (LI83.55-P-056349)
- Belt Drive Alignment With Auxiliary A/C Compressor Causing Abnormal Belt Wear (TT 05/12-D)
- Rattling Noise In Area Of Belt Pulley Of Refrigerant Compressor With Air Conditioning Deactivated (LI83.55-P-053157)
- No Cooling Output/Refrigerant Compressor Defective (LI83.55-P-052743)
- Accessories & Equipment
- Rattling Noises From Electric Step When Retracted (LI88.30-N-060760)
- Step Does Not Extend/Retract Completely Or Is Sluggish (LI88.00-N-062142)
- Special Tool Return Due To Interference Issue (V-B-58.20/04)
- Installation Of Partition Wall (V-B-68.70/01)
- Special Tools In EPC (V-B-58.20/03)
- Change To Single Component Windshield Bonding System (67.10/30)
- DAS/XD Add-On 2013-09-02-3032 For Passenger Cars (GI58.40-P-057260)
- DAS/XD Add-On 2013-09-02-3033 For Passenger Cars (GI58.40-P-057262)
- DAS/XD Add-On 2013-09-09-3051 For Passenger Cars (GI58.40-P-057310)
- DAS/XD Add-On 2013-09-30-3101 For Passenger Cars (GI58.40-P-057473)
- DAS/XD Add-On 2013-09-30-3102 For Passenger Cars (GI58.40-P-057474)
- DAS/XD Add-On 2013-10-14-3139 For Passenger Cars (GI58.40-P-057556)
- DAS/XD Add-On 2013-10-21-3153 For Passenger Cars (GI58.40-P-057694)
- DAS/XD Add-On 2013-10-28-3170 For Passenger Cars (GI58.40-P-057711)
- DAS/XD Add-On 2013-03-25-2734 For Passenger Cars (GI58.40-P-056100)
- DAS/XD Add-On 2013-03-25-2735 For Passenger Cars (GI58.40-P-056101)
- DAS/XD Add-On 2013-04-15-2758 For Passenger Cars (GI58.40-P-056250)
- DAS/XD Add-On 2013-04-15-2759 For Passenger Cars (GI58.40-P-056251)
- DAS/XD Add-On 2013-04-22-2773 For Passenger Cars (GI58.40-P-056268)
- DAS/XD Add-On 2013-04-29-2787 For Passenger Cars (GI58.40-P-056313)
- DAS/XD Add-On 2013-05-06-2790 For Passenger Cars (GI58.40-P-056330)
- DAS/XD Add-On 2013-05-06-2791 For Passenger Cars (GI58.40-P-056331)
- DAS/XD Add-On 2013-05-13-2798 For Passenger Cars (GI58.40-P-056375)
- DAS/XD Add-On 2013-05-13-2799 For Passenger Cars (GI58.40-P-056376)
- DAS/XD Add-On 2013-05-13-2800 For Passenger Cars (GI58.40-P-056377)
- DAS/XD Add-On 2013-05-21-2807 For Passenger Cars (GI58.40-P-056540)
- DAS/XD Add-On 2013-05-21-2808 For Passenger Cars (GI58.40-P-056541)
- DAS/XD Add-On 2013-05-27-2816 For Passenger Cars (GI58.40-P-056542)
- DAS/XD Add-On 2013-05-27-2817 For Passenger Cars (GI58.40-P-056543)
- DAS/XD Add-On 2013-06-03-2828 For Passenger Cars (GI58.40-P-056552)
- DAS/XD Add-On 2013-07-01-2884 For Passenger Cars (GI58.40-P-056796)
- DAS/XD Add-On 2013-07-08-2892 For Passenger Cars (GI58.40-P-056808)
- DAS/XD Add-On 2013-07-08-2893 For Passenger Cars (GI58.40-P-056813)
- DAS/XD Add-On 2013-07-22-2926 For Passenger Cars (GI58.40-P-056881)
- DAS/XD Add-On 2013-07-29-2939 For Passenger Cars (GI58.40-P-056956)
- DAS/XD Add-On 2013-08-05-2954 For Passenger Cars (GI58.40-P-056988)
- DAS/XD Add-On 2013-08-12-2968 For Passenger Cars (GI58.40-P-057091)
- DAS/XD Add-On 2013-08-19-2985 For Passenger Cars (GI58.40-P-057149)
- DAS/XD Add-On 2013-08-26-3013 For Passenger Cars (GI58.40-P-057195)
- DAS/XD Add-On 2013-08-26-3014 For Passenger Cars (GI58.40-P-057196)
- Diagnosis Button In XENTRY Inactive (LI00.30-N-056650)
- UPFITTER Bulletin - Retrofitting Equipment Codes (06/24/2013)
- DAS/XD Add-On 2013-02-18-2694 For Passenger Cars (GI58.40-P-055738)
- DAS/XD Add-On 2012-10-01-2521 For Passenger Cars (GI58.40-P-054953)
- DAS/XD Add-On 2012-11-12-2582 For Passenger Cars (GI58.40-P-055195)
- DAS/XD Add-On 2012-11-19-2589 For Passenger Cars (GI58.40-P-055232)
- Multiplexer (58.40/162)
- Accessories Control Systems
- Malfunctions In The Vehicle In Connection With The PARAMETERIZABLE Special Module (PSM) (LI54.21-N-071993)
- COMAND Download Manager (DLM): Download Aborted, Does Not Load To Selected USB Drive (LI82.85-P-071912)
- Message "A Data Plan For Internet Services From MERCEDES Me Portal Is Needed To Use This Service" In The Head Unit (LI82.85-P-069515)
- Fuel GUAGE Jumps From 3 Bars To 1 (LI54.30-N-066583)
- PSM Or AAG (Trailer Connection Unit) Cannot Be Activated (LI54.21-N-048716)
- CEL With Multiple Control Modules Exhibiting Numerous Can Codes (TT 06/16-D)
- Interior Lamp Inoperative When Opening Door (Bulb Working) (LI82.20-N-054617)
- Software-Based Retrofits (V-B-00.00/08)
- Fuel Gauge Not Reading Correctly On Vehicles W/ Additional Generators Using Vehicle's Fuel Supply (TT 02/15-E)
- Brake Warning Lamp Illuminates About 5 Seconds After Every Start-Up And Stays Lit; No DTCS (TT 10/14-Q)
- Sprinters Equipped With INTERMOTIVE Mobility Lift (LI27.60-N-056078)
- UPFITTER Bulletin - PSM Information (PSM INFO.)
- DAS/XD Add-On 2013-09-16-3075 For Passenger Cars (58.40-P-057368)
- UPFITTER Bulletin - PSM - Program Loading (09/26/2013)
- Instrument Cluster Display Message "La 13" (LI54.30-N-048713)
- PARKTRONIC Indicator, Signal Tone Too Quiet (LI54.65-N-048717)
- Warning Lamp Indicates "Air Filter Fouled" (LI54.30-N-056978)
- UPFITTER Bulletin - Retrofitting Equipment Codes (06/24/2013)
- Time Cannot Be Adjusted In Instrument Cluster (LI54.30-N-051765)
- UPFITTER Bulletin - PSM - Parametric Special Module (02/26/2013)
- Fuse And Relay Box (V-B-54.15/08)
- Contact For Retro-Fitments, PARAMETERIZABLE Special Module (PSM) Or Bodybuilding Issues (V-B-00.00/01)
- Programming Control Units (V-B-54.21/09)
- Auxiliary Heater With Ceramic Glow Plugs (V-B-83.70/04)
- Trailer Operation (V-B-31.00/01)
- TPMS System (Tire Pressure Monitor, Special Equipment Code Ry2) Nonfunctional - After Installation Of Complete Wheels Without Wheel Sensors. (LI40.15-N-040597)
- Warning Lamp Indicates "Air Filter Fouled" (LI54.30-N-048758)
- Accessory Drive Belts
- Drive Belt Chatter At Idle/Power Steering Complaints/Vehicle Runs Hot/CEL With DTCS P13BA00 - P13BF00 Or P13C000 - P13C500 (LI13.20-N-066706)
- Excessive Belt Vibration And/Or CEL With DTCS: 13BA00, 13BB00, 13BC00, 13BD00, 13BE00, 13BF00 "Maximum Actuation Duration For Zero Quantity Calibration For Fuel Injector Of Cylinder X Exceeded" (TT 05/16-E)
- Poly-V Belt For Roof Air Conditioning (H08) Or Second Level Alternator (N62) Or Front Power Take-Off (N63) Torn (TT 09/15-K)
- Additional Poly-V Belt For Roof Air Conditioning Or Front Power Take-Off Torn (LI13.20-N-054722)
- Noise Complaint At Refrigerant Compressor/Belt Drive With Air Conditioning Activated And Deactivated (LI83.55-P-056349)
- Belt Drive Alignment With Auxiliary A/C Compressor Causing Abnormal Belt Wear (TT 05/12-D)
- Rattling Noise In Area Of Belt Pulley Of Refrigerant Compressor With Air Conditioning Deactivated (LI83.55-P-053157)
- Belt TENSIONER Noises (LI13.22-N-050271)
- Air Bag, SRS
- Anti-Lock Brakes
- DISTRONIC And/Or Active Brake Assist Inoperative After Driving For An Extended Period (LI54.71-N-075673)
- Indicator Lamps For Brake System Light Up (LI42.45-N-048724)
- Esp Indicator Lamp Active, Fault Code C007500 In Esp Control Unit (LI54.25-N-061756)
- Esp Indicator Lamp Lights Up While Driving, Esp Fault 441A Or 445A (LI42.45-N-053055)
- Fault Code 43C0 Esp Control Unit - The Supply Voltage Is Too Low (LI54.15-N-064960)
- CEL With Multiple Control Modules Exhibiting Numerous Can Codes (TT 06/16-D)
- Perform SCN Coding In Electronic Stability Program (Esp) When Retrofitting Retarder And Wheelbase Extension (V-B-42.45/01)
- Anti-Theft Systems
- Sliding Door In Partition Wall Cannot Be Locked In Open Position (LI68.74-N-057463)
- Rattle From Passenger Side Sliding Door (LI72.16-N-065605)
- Cable Track Of Load Compartment Sliding Door Has Excessive Resistance/Is Cracked/Makes Noises (LI72.16-N-048764)
- SCERF - Stationary Continues Engine Running Feature (TT 09/15-L)
- Garage Door Opener Led Light On Bottom Of Inside Rearview Mirror Pushed In And No Longer Visible (TT 10/14-F)
- Complete Key And Lock Set Replacement For Lost Or Missing Keys (TT 01/14-G)
- Door Holder Of Front Hinged Door Broken/Door Cannot Be Opened Or Closed/Door Holder Makes Noises (LI72.10-N-048762)
- Sliding Door In Partition Wall Cannot Be Locked In Open Position (LI68.74-N-056459)
- Instrument Cluster Message "Replace Key Battery" (80.61/61A)
- Interruptions In Radio-Operated Vehicle Systems (V-B-80.57/01)
- Automatic Trans
- Lubricating Oil Analysis Information (LI01.00-P-068886)
- Automatic Transmission Oil Loss In Area Of Wiring Harness And Oil Pan Gasket (LI27.00-N-048696)
- Delayed Upshift During DPF Regeneration (TT 04/15-G)
- EEPROM (TT 01/15-J)
- EHS Number (TT 01/15-K)
- Lack Of Power Going Up A Hill Or From A Stop But OK When Driving (TT 10/14-P)
- Compatibility Of Transmission Fluids "Gold," "Red," & "Blue" (TT 07/14-C)
- Sprinters Equipped With INTERMOTIVE Mobility Lift (LI27.60-N-056078)
- ESM (Electronic Selector Lever Module) Fault 0002 "UNDERVOLTAGE" (LI27.60-N-048766)
- Automatic Transmission Fluid Burnt, Shavings In Fluid, Automatic Transmission Stalls Engine (Only 5-Speed Automatic Transmission SA G40) (LI27.00-N-048695)
- Gear Range Cannot Be Engaged / No Power Flow (LI27.60-N-048889)
- Nag2 With DTC XXXX And Corresponding Code Description "Component Y3/8N4 (Fully Integrated Transmission Control (VGS) Control Unit) Is Defective" (LI27.35-P-051683)
- Drive Plate (V-B-03.30/01)
- Auxiliary Emission Control Systems
- My2010-2016 906 Sprinter: New NOX Sensor Part Numbers Are Not Recognized During The Approved Emission Modification (AEM) Campaign (LI49.20-N-074942)
- How To Address 906 Sprinters Appearing At A Us Dealer For The Approved Emission Modification (AEM) Where VMI Shows CANADA BLUETEC II Field Measure Or Vehicle Is Registered In CANADA (LI49.20-N-073931)
- My10-12 906 Sprinter: Maximum Vehicle Speed Limit Changed After Approved Emission Modification (AEM) Campaign (LI30.36-N-073937)
- Emissions Campaign 2021090009 - Modification To The Emissions Control System (2021090009)
- Approved Emission Modification Campaign 2020040001, 2020040002, Or 2020040003 Special Procedure In XENTRY Does Not Complete Due To CDI Software (LI07.08-N-072747)
- Engine Oil Level Above Max, Oil Indicator Light On (LI18.00-N-054809)
- CEL With Multiple Control Modules Exhibiting Numerous Can Codes (TT 06/16-D)
- DTC: P15FF00 "The Signal Line Of Component "B28/20 (Diesel Particulate Filter Differential Pressure Sensor)" Has A Short To Ground" (TT 05/16-C)
- CEL With DTC P178200 (TT 30/16-A)
- Engine In Limp-Home Mode, FC123900 (LI09.00-N-054723)
- Engine Power Insufficient, Engine Diagnosis Indicator Lamp Lights Up And Differential Pressure Sensor Fault Codes Current And/Or Stored In CDI Control Unit (LI07.04-N-056999)
- Mechanical Fault In NOX Sensors With Fault Codes Stored-Current In Engine Control Unit (LI47.50-N-057830)
- Error Code 8.6.00 On Display Of Multiplexer And "Ignition On Signal" Is Not Recognized When Trying To Use DAS On A XENTRY Vehicle (TT 01/16-A)
- Check Engine Light On With One Or More Of The Following DTCS P147600, P147700, P149D00, P153800 (LI14.40-N-062147)
- Check Engine Light On With One Or More Of The Following DTCS P18B800, P18B900 (LI14.40-N-061091)
- Check Engine Light On With One Or More Of The Following DTCS P18BC00, P18BD00 (LI14.40-N-060212)
- Vehicle On-Board Diagnostic Systems And Emissions Control Tampering (V-B-00.00/09)
- SCR Testing Notes (TT 12/15-B)
- ADBLUE Tank Heated Line Leaking / Melted With CEL On And Fault Codes P20B914 And P20BA1A (TT 11/15-E)
- XENTRY ADBLUE Dosing Valve Testing (TT 11/15-C)
- ADBLUE Tank Was Run Empty - Engine And/Or ADBLUE® Indicator Lamp Or "Check ADBLUE®" Indicator And/Or "No Start In XXX Km" Is Activated In The Instrument Cluster And Is Not Deactivated After Refilling With ADBLUE® (LI14.40-N-061956)
- DPF Filter Cracked / Broken (LI49.10-N-059066)
- Vehicle Will Not Go Over 5MPH (8KM/H); Not Related To Countdown Mode (TT 09/15-J)
- ADBLUE Fluid Testing (TT 08/15-J)
- Dosing / Metering Valve Test (TT 08/15-K)
- New EGR Valve Resists Against Moisture Ingress (TT 08/15-I)
- Check Engine Light On, DTCS P15B700, P18B400, P178100, P15E100 (LI14.00-N-061960)
- Vehicle Will Not Go Over 5MPH (8KM/H) Not Related To Countdown Mode (LI07.00-N-061850)
- Om642 - CEL With DTC 20B811, 208B77, 20BD11, 20BE1B - ADBLUE Tank Heater Coating (TT 07/15-D)
- Sprinter III SCR Testing Using 05/15 XENTRY SW (TT 06/15-D)
- CEL With DTC P178200 & P18D300 (TT 05/15-C)
- Engine In Limp-Home Mode, CEL Lights Up (TT 05/15-D)
- Road Test Procedure To Reset Tampering (TT 05/15-E)
- NOX Sensor Replacement Tip (TT 04/15-C)
- Electrical Testing At The CDI Module (TT 03/15-A)
- Engine Sensor Replacement (TT 03/15-B)
- ADBLUE Delivery Modules - Broken Nipples (TT 02/15-H)
- Engine May Be In Limp-Home Mode And/Or Engine Indicator Lamp Lights Up, Various Fault Codes Present In Area Of Exhaust Gas RECIRCULATION (EGR System) Or In Charge Air System (LI14.20-N-058842)
- ADBLUE Replacement Pumps Not Working (TT 11/14-B)
- ADBLUE Tank Gen. 1 Versus Gen. 2 (TT 11/14-C)
- Return Of Diagnostic Data In Event Of Faults In Exhaust After-Treatment System (V-B-14.40/03)
- Fault Relating To SCR ADBLUE Warning Strategy (LI14.40-N-060049)
- ADBLUE Test Cycle (TT 05/14-I)
- Exhaust Back Pressure Sensor (TT 05/14-C)
- Performing Stationary Regeneration Of DPF On Vehicles With Automatic Idle Shut-Down (TT 05/14-D)
- ENGINE AND/OR ADBLUE® INDICATOR LAMP LIGHTS UP "CHECK AD-BLUE®" AND/or "NO START IN XXX" APPEARS IN INSTRUMENT CLUSTER (LI49.20-N-058621)
- Noises During Engine Run-On/EGR Valve Cleaning Function (LI14.20-N-048802)
- UPFITTER Bulletin - Chassis Cab Bulletin (08/20/2013)
- I/M 240 Emissions Testing On Dynamometer (14.00/31)
- Check Engine Light DTC 20B811 (TT 12/11-G)
- Def Light Stays On (TT 12/11-F)
- Programming Control Units (V-B-54.21/09)
- Axle Shafts
- Noise From Propeller Shaft Intermediate Bearing(S) In All Rotational Speed And Vehicle Speed Ranges (LI41.10-N-073814)
- Humming, Droning From The Drivetrain On Sprinter 2500 With All-Wheel Drive (4X4) (LI35.00-N-060958)
- Cleaning Axle Hubs When Installing Brake Discs (42.10/123A)
- Rattling Noises At The Front Axle (LI42.10-N-049556)
- Vibrations In Drive Train (LI41.10-N-038141)
- Vibrations, Sometimes Accompanied By Noises From The Drivetrain/Propeller Shaft (LI41.10-N-057116)
- Check Front Axle Ball Joints (V-B-33.20/01)
- Blowers, Superchargers & Turbochargers
- Repair Guidelines For Turbocharger Failures (LI09.40-N-063089)
- Repair Guidelines For Turbocharger Failures (LI09.40-N-075799)
- Coolant/Vacuum/Temperature Fault Codes - Check Engine Light With DTCS P003313, P0299FA, P0299FB, P226100, P261F71, P012800, Or P012809 (LI07.09-P-070016)
- Traces Of Oil In Area Around Oil/Water Heat EXCHANGER (Inner V) On Engine 642 (LI18.30-N-056338)
- Turbo Inlet Seal (TT 06/16-A)
- Turbocharger Damage (TT 06/16-E)
- Engine In Limp-Home Mode, FC123900 (LI09.00-N-054723)
- CEL On; Air Cleaner Housing Damaged (TT 02/16-B)
- Turbo Charger Replacement (TT 12/15-A)
- Turbo Inlet Seal: V-B-09.00/01 (TT 10/15-B)
- Charge Air Cooler Inspection (TT 03/15-C)
- Any Repairs Performed In The "Clean Air Line" Area On Top Of Engine (TT 01/15-A)
- Engine Switches To Limp-Home Mode Or Has Insufficient Output (LI14.10-N-049797)
- Operations In Clean Air Line Area (V-B-09.00/01)
- Body Electrical
- Wiring Damage On More Than 10 Wires (LI54.18-P-072022)
- CEL With DTC: P11C300 Stored In CDI (TT 07/16-D)
- SRS System Wiring Repairs (TT 07/16-B)
- CEL With Multiple Control Modules Exhibiting Numerous Can Codes (TT 06/16-D)
- Error Code 8.6.00 On Display Of Multiplexer And "Ignition On Signal" Is Not Recognized When Trying To Use DAS On A XENTRY Vehicle (TT 01/16-A)
- Electrical Testing At The CDI Module (TT 03/15-A)
- UPFITTER Bulletin - Trailer Brake Control Prep (Green 4-Pin Connector) (09/26/2013)
- UPFITTER Bulletin - Electrical Connectors For Body Builders [EK1] (My '07-'13) (08/20/2013)
- UPFITTER Bulletin - Sprinter Electrical Info (My '07 - '13) (08/20/2013)
- UPFITTER Bulletin - Sprinter Ground Terminals (08/20/2013)
- Repair Kits For Frame Wiring Harness (LI54.18-N-050405)
- Body Interior
- Unsuccessful Control Unit Programming Session Or Sporadic Malfunction Of Systems (LI00.19-N-075749)
- Malfunctions In The Vehicle In Connection With The PARAMETERIZABLE Special Module (PSM) (LI54.21-N-071993)
- Fuel GUAGE Jumps From 3 Bars To 1 (LI54.30-N-066583)
- CEL With Multiple Control Modules Exhibiting Numerous Can Codes (TT 06/16-D)
- Interior Lamp Inoperative When Opening Door (Bulb Working) (LI82.20-N-054617)
- Software-Based Retrofits (V-B-00.00/08)
- UPFITTER Bulletin - PSM Information (PSM INFO.)
- UPFITTER Bulletin - PSM - Program Loading (09/26/2013)
- UPFITTER Bulletin - Retrofitting Equipment Codes (06/24/2013)
- UPFITTER Bulletin - PSM - Parametric Special Module (02/26/2013)
- Brakes Control Systems
- Indicator Lamps For Brake System Light Up (LI42.45-N-048724)
- Esp Indicator Lamp Active, Fault Code C007500 In Esp Control Unit (LI54.25-N-061756)
- Esp Indicator Lamp Lights Up While Driving, Esp Fault 441A Or 445A (LI42.45-N-053055)
- CEL With Multiple Control Modules Exhibiting Numerous Can Codes (TT 06/16-D)
- Brake Warning Lamp Illuminates About 5 Seconds After Every Start-Up And Stays Lit; No DTCS (TT 10/14-Q)
- UPFITTER Bulletin - Trailer Brake Control Prep (Green 4-Pin Connector) (09/26/2013)
- Brake Lamps Inoperative (LI82.10-N-052274)
- Programming Control Units (V-B-54.21/09)
- Perform SCN Coding In Electronic Stability Program (Esp) When Retrofitting Retarder And Wheelbase Extension (V-B-42.45/01)
- Charging Systems
- Vehicles With SCR Generation 4: SCR/ADBLUE® Warning Message Cannot Be Reset With Fault Code P13DF00 Or P300685 (VERSION 3)
- Unsuccessful Control Unit Programming Session Or Sporadic Malfunction Of Systems (LI00.19-N-075749)
- Drive Belt Chatter At Idle/Power Steering Complaints/Vehicle Runs Hot/CEL With DTCS P13BA00 - P13BF00 Or P13C000 - P13C500 (LI13.20-N-066706)
- Excessive Belt Vibration And/Or CEL With DTCS: 13BA00, 13BB00, 13BC00, 13BD00, 13BE00, 13BF00 "Maximum Actuation Duration For Zero Quantity Calibration For Fuel Injector Of Cylinder X Exceeded" (TT 05/16-E)
- Poly-V Belt For Roof Air Conditioning (H08) Or Second Level Alternator (N62) Or Front Power Take-Off (N63) Torn (TT 09/15-K)
- Additional Poly-V Belt For Roof Air Conditioning Or Front Power Take-Off Torn (LI13.20-N-054722)
- P13CX00 "Minimum Actuation Duration For Zero Quantity Calibration For Injector Of X Not Reached" (TT 05/15-A)
- UPFITTER Bulletin - Alternator Info (220 Amp) (08/20/2013)
- Battery Maintenance (V-B-54.10/02)
- Collision/Avoidance
- DISTRONIC And/Or Active Brake Assist Inoperative After Driving For An Extended Period (LI54.71-N-075673)
- Blind Spot Assist Inoperative (LI54.71-P-056477)
- PARKTRONIC Indicator, Signal Tone Too Quiet (LI54.65-N-048717)
- Brake Light Switch (V-B-82.10/02)
- PARKTRONIC Sensor Replacement (V-B-54.65/07)
- Complaints Connected With The Rain/Light Sensor (LI82.30-N-048714)
- Communication Devices
- COMAND Download Manager (DLM): Download Aborted, Does Not Load To Selected USB Drive (LI82.85-P-071912)
- The Mobile Phone Address Book Is Not Transferred Completely (LI82.70-N-071004)
- Garage Door Opener Led Light On Bottom Of Inside Rearview Mirror Pushed In And No Longer Visible (TT 10/14-F)
- PHONEBOOK Does Not Completely Download To Head Units, Cannot Save NAVI Destinations (LI82.85-P-052185)
- Cooling Fan
- Cooling Fan Broken / Breaks (LI20.40-N-067705)
- CEL With DTCS 124700, 11A300, 11C500, 108800 (TT 01/16-E)
- Check Engine Light On With One Or More Of The Following DTCS 108800, 11A300, 11C500, 124700 (LI20.40-N-062876)
- Engine Fan And/Or Fan Cowl Makes Noises And May Be Damaged (TT 11/24-A)
- Engine Fan And Fan Cowl Make Noises (LI20.40-N-053150)
- Cooling System (Mechanical)
- ALS Engine Oil, Diesel Fuel, And Coolant Analysis Information (LI01.00-N-077592)
- Coolant/Vacuum/Temperature Fault Codes - Check Engine Light With DTCS P003313, P0299FA, P0299FB, P226100, P261F71, P012800, Or P012809 (LI07.09-P-070016)
- Engine Oil In Coolant Circuit (LI20.30-P-069996)
- Procedure For When The Cooling System Is Filled With Incorrect Fluid (LI20.00-N-062976)
- All New Red/Pink Coolant Versus Blue Coolant (TT 05/14-F)
- UPFITTER Bulletin - Sprinter Block Heater Mock-Up (3.0L V6 Om642) (08/20/2013)
- Engine Fan And Fan Cowl Make Noises (LI20.40-N-053150)
- Coolant Expansion Reservoir (V-B-20.30/01)
- Differentials & Drive Axles
- Lubricating Oil Analysis Information (LI01.00-P-068886)
- Howling, Humming, Droning, Vibrations From Drivetrain (LI35.31-P-056961)
- Noise Due To Water Entry At Rear Axle Drive Flange (LI35.31-N-070296)
- 906 Front Differential/Axle Noise (LI33.25-N-068472)
- Oil Residues On Rear Axle In Area Of Drive Pinion Bearing Seal (LI35.31-N-048694)
- Humming, Droning From The Drivetrain On Sprinter 2500 With All-Wheel Drive (4X4) (LI35.00-N-060958)
- Rear Axle Load Change Noise/No Power Flow (LI35.30-N-049982)
- Whistling Noises From Drive Train/Propeller Shaft Center Support Bearing During Driving Operation (LI41.00-N-048687)
- Temporary Rattling Or Squealing Noises From The Drivetrain (LI41.00-N-048688)
- Vibrations In Drive Train (LI41.10-N-038141)
- Vibrations, Sometimes Accompanied By Noises From The Drivetrain/Propeller Shaft (LI41.10-N-057116)
- Removal And Installation Of The Drive Shaft (V-B-41.10/02)
- Use Of Modified Propeller Shaft Center Support Bearing With Protective Caps (V-B-41.10/01A)
- Vibrations, Sometimes Accompanied By Noises From The Drivetrain/Propeller Shaft. (LI41.10-N-049335)
- Driveshaft & Universal Joints
- Droning Noise Around 73MPH On 907 Long Wheel Base (170") With ZG3 4X4 (LI41.00-N-075339)
- Howling, Humming, Droning, Vibrations From Drivetrain (LI35.31-P-056961)
- Ball Joint Check On Front Axle (LI33.00-N-066643)
- Humming, Droning From The Drivetrain On Sprinter 2500 With All-Wheel Drive (4X4) (LI35.00-N-060958)
- Whistling Noises From Drive Train/Propeller Shaft Center Support Bearing During Driving Operation (LI41.00-N-048687)
- Vibrations In Vehicle (LI40.10-N-048690)
- Temporary Rattling Or Squealing Noises From The Drivetrain (LI41.00-N-048688)
- Vibrations In Drive Train (LI41.10-N-038141)
- Vibrations, Sometimes Accompanied By Noises From The Drivetrain/Propeller Shaft (LI41.10-N-057116)
- Removal And Installation Of The Drive Shaft (V-B-41.10/02)
- Use Of Modified Propeller Shaft Center Support Bearing With Protective Caps (V-B-41.10/01A)
- Vibrations, Sometimes Accompanied By Noises From The Drivetrain/Propeller Shaft. (LI41.10-N-049335)
- Electronic Steering
- Engine Control Systems
- Vehicles With SCR Generation 4: SCR/ADBLUE® Warning Message Cannot Be Reset With Fault Code P13DF00 Or P300685 (VERSION 3)
- Check Engine Light Active - Fault P3007-F1, P3007-F2, P300C-A8, Or P300C-A9 Present In CDI Control Unit (V5)
- Check Engine Light With Fault Code P300-EB In The CDI Control Unit CDI (N3/28) (VERSION 3)
- Vehicles With SCR Generation 4: SCR/ADBLUE® Warning Message Cannot Be Reset P13DF00 (LI49.20-N-075995)
- Repair Guidelines For Turbocharger Failures (LI09.40-N-063089)
- Unsuccessful Control Unit Programming Session Or Sporadic Malfunction Of Systems (LI00.19-N-075749)
- Engine Running Rough, Engine Diagnosis Indicator Lamp Lights Up, Fault Code P11C300 Or P019185 Present In CDI Control Unit (LI07.04-N-060527)
- Working Speed Control Inoperative After Programming Of Common Rail Diesel Injection System (CDI) Control Unit (LI54.21-N-066783)
- PSM Or AAG (Trailer Connection Unit) Cannot Be Activated (LI54.21-N-048716)
- Engine Oil Level Above Max (LI18.40-P-066105)
- CEL With DTC: P11C300 Stored In CDI (TT 07/16-D)
- CEL With Multiple Control Modules Exhibiting Numerous Can Codes (TT 06/16-D)
- CEL And Engine In Limp Home Mode With DTC P11C300 "The Upper Limit Of Component B4/17 (Rail Pressure Sensor) Has Been Exceeded" (TT 05/16-B)
- DTC: P15FF00 "The Signal Line Of Component "B28/20 (Diesel Particulate Filter Differential Pressure Sensor)" Has A Short To Ground" (TT 05/16-C)
- Excessive Belt Vibration And/Or CEL With DTCS: 13BA00, 13BB00, 13BC00, 13BD00, 13BE00, 13BF00 "Maximum Actuation Duration For Zero Quantity Calibration For Fuel Injector Of Cylinder X Exceeded" (TT 05/16-E)
- Automatic Engine Start To Maintain Refrigeration Temperature (TT 04/16-E)
- Poor Engine Starting After Long Period Out Of Use Li15.20-N-057008 (TT 04/16-B)
- Proper Fuel Filter Replacement (TT 04/16-C)
- ALS Diesel Fuel Test Information (LI47.00-N-062649)
- CEL With DTC P178200 (TT 30/16-A)
- Engine In Limp-Home Mode, FC123900 (LI09.00-N-054723)
- Engine Power Insufficient, Engine Diagnosis Indicator Lamp Lights Up And Differential Pressure Sensor Fault Codes Current And/Or Stored In CDI Control Unit (LI07.04-N-056999)
- Engine In Limp-Home Mode, FC150100, 150200 Or 150300 (LI09.00-N-056517)
- Mechanical Fault In NOX Sensors With Fault Codes Stored-Current In Engine Control Unit (LI47.50-N-057830)
- Check Engine Light With DTC P15FF00 (TT 02/16-A)
- CEL With DTCS 124700, 11A300, 11C500, 108800 (TT 01/16-E)
- Error Code 8.6.00 On Display Of Multiplexer And "Ignition On Signal" Is Not Recognized When Trying To Use DAS On A XENTRY Vehicle (TT 01/16-A)
- Check Engine Light On With One Or More Of The Following DTCS 108800, 11A300, 11C500, 124700 (LI20.40-N-062876)
- Check Engine Light On With One Or More Of The Following DTCS P147600, P147700, P149D00, P153800 (LI14.40-N-062147)
- Check Engine Light On With One Or More Of The Following DTCS P18B800, P18B900 (LI14.40-N-061091)
- Check Engine Light On With One Or More Of The Following DTCS P18BC00, P18BD00 (LI14.40-N-060212)
- ADBLUE Tank Heated Line Leaking / Melted With CEL On And Fault Codes P20B914 And P20BA1A (TT 11/15-E)
- ADBLUE Tank Was Run Empty - Engine And/Or ADBLUE® Indicator Lamp Or "Check ADBLUE®" Indicator And/Or "No Start In XXX Km" Is Activated In The Instrument Cluster And Is Not Deactivated After Refilling With ADBLUE® (LI14.40-N-061956)
- Vehicle Stalls When Driving / Will Not Crank Or Restart (TT 10/15-A)
- DPF Filter Cracked / Broken (LI49.10-N-059066)
- SCERF - Stationary Continues Engine Running Feature (TT 09/15-L)
- Vehicle Will Not Go Over 5MPH (8KM/H); Not Related To Countdown Mode (TT 09/15-J)
- New EGR Valve Resists Against Moisture Ingress (TT 08/15-I)
- Check Engine Light On, DTCS P15B700, P18B400, P178100, P15E100 (LI14.00-N-061960)
- Vehicle Will Not Go Over 5MPH (8KM/H) Not Related To Countdown Mode (LI07.00-N-061850)
- Om642 - CEL With DTC 20B811, 208B77, 20BD11, 20BE1B - ADBLUE Tank Heater Coating (TT 07/15-D)
- Vehicle Will Not Start Or Loud Noise From Exhaust System (TT 07/15-B)
- Sprinter III SCR Testing Using 05/15 XENTRY SW (TT 06/15-D)
- CEL With DTC P178200 & P18D300 (TT 05/15-C)
- Engine In Limp-Home Mode, CEL Lights Up (TT 05/15-D)
- High Pressure Pump Removal And Installation (TT 05/15-B)
- P13CX00 "Minimum Actuation Duration For Zero Quantity Calibration For Injector Of X Not Reached" (TT 05/15-A)
- Road Test Procedure To Reset Tampering (TT 05/15-E)
- Software-Based Retrofits (V-B-00.00/08)
- Fuel Filter Heater Fuse Location (F79) (TT 04/15-D)
- NOX Sensor Replacement Tip (TT 04/15-C)
- CDI Ecu Will Not Learn The CMP Sensors Due To Timing Chain Stretch (TT 04/15-E)
- Electrical Testing At The CDI Module (TT 03/15-A)
- Engine Sensor Replacement (TT 03/15-B)
- Winter Operation Using Diesel Fuels (V-B-00.00/06)
- Fuel Filter Replacement (TT 02/15-B)
- Fuel Pump Pressure Test (TT 02/15-C)
- Engine May Be In Limp-Home Mode And/Or Engine Indicator Lamp Lights Up, Various Fault Codes Present In Area Of Exhaust Gas RECIRCULATION (EGR System) Or In Charge Air System (LI14.20-N-058842)
- ADBLUE Replacement Pumps Not Working (TT 11/14-B)
- ADBLUE Tank Gen. 1 Versus Gen. 2 (TT 11/14-C)
- Lack Of Power Going Up A Hill Or From A Stop But OK When Driving (TT 10/14-P)
- Return Of Diagnostic Data In Event Of Faults In Exhaust After-Treatment System (V-B-14.40/03)
- Aftermarket Remote Start Kits (TT 09/14-C)
- Biodiesel Information For MERCEDES-BENZ Vehicles 2014 Edition (5/20/14)
- Exhaust Back Pressure Sensor (TT 05/14-C)
- ENGINE AND/OR ADBLUE® INDICATOR LAMP LIGHTS UP "CHECK AD-BLUE®" AND/or "NO START IN XXX" APPEARS IN INSTRUMENT CLUSTER (LI49.20-N-058621)
- Signs Of Incorrect Installation Of High Pressure Fuel Pump (TT 03/14-B)
- Procedure For When Diesel Fuel Tank Is Filled With Incorrect Fuel Type (V-B-47.10/01B)
- UPFITTER Bulletin - PSM - Program Loading (09/26/2013)
- Engine Switches To Limp-Home Mode Or Has Insufficient Output (LI14.10-N-049797)
- Automatic Transmission Fluid Burnt, Shavings In Fluid, Automatic Transmission Stalls Engine (Only 5-Speed Automatic Transmission SA G40) (LI27.00-N-048695)
- Diesel Odor, High-Pressure Pump Leaking (LI07.02-N-048800)
- UPFITTER Bulletin - Retrofit High Idle Control On 906.XXX (06/24/2013)
- Information On Low-Pressure Fuel Hoses (V-B-47.25/02)
- Vehicle Does Not Start Or Starter Does Not Turn. Fault Code 155700, Fuse F28 Blown (LI15.30-N-056339)
- UPFITTER Bulletin - PSM - Parametric Special Module (02/26/2013)
- CEL With DTC 18B400 & Or 186A00 "Unknown Fault Type" With No Diagnostic Steps (LI07.16-N-055099)
- Stalling Due To Lack Of Fuel - Fuel Not Transferring In Saddle Tank (TT 03/11-B)
- Programming Control Units (V-B-54.21/09)
- Engine In Limp-Home Mode And Engine Diagnosis Indicator Lamp Lights Up (LI07.08-N-048806)
- Entertainment Systems
- COMAND Download Manager (DLM): Download Aborted, Does Not Load To Selected USB Drive (LI82.85-P-071912)
- Message "A Data Plan For Internet Services From MERCEDES Me Portal Is Needed To Use This Service" In The Head Unit (LI82.85-P-069515)
- Navigation Destinations Cannot Be Found In Poi Download/"Send2BENZ" Service Inoperative (LI82.85-P-068210)
- Poor Sound Quality Of Speakers When Using An External Data Source Via Aux Jack (LI82.62-N-057377)
- Cd/DVD Is No Longer Ejected (LI82.60-P-053573)
- PHONEBOOK Does Not Completely Download To Head Units, Cannot Save NAVI Destinations (LI82.85-P-052185)
- Exhaust
- Check Engine Light With Fault Code P300-EB In The CDI Control Unit CDI (N3/28) (VERSION 3)
- Om642 Exhaust Bracket Cracking (LI49.10-N-067486)
- Engine In Limp-Home Mode, FC123900 (LI09.00-N-054723)
- DPF Filter Cracked / Broken (LI49.10-N-059066)
- ADBLUE Fluid Testing (TT 08/15-J)
- Dosing / Metering Valve Test (TT 08/15-K)
- Om642 - CEL With DTC 20B811, 208B77, 20BD11, 20BE1B - ADBLUE Tank Heater Coating (TT 07/15-D)
- Vehicle Will Not Start Or Loud Noise From Exhaust System (TT 07/15-B)
- ADBLUE Delivery Modules - Broken Nipples (TT 02/15-H)
- Fault Relating To SCR ADBLUE Warning Strategy (LI14.40-N-060049)
- ADBLUE Test Cycle (TT 05/14-I)
- Performing Stationary Regeneration Of DPF On Vehicles With Automatic Idle Shut-Down (TT 05/14-D)
- Engine Switches To Limp-Home Mode Or Has Insufficient Output (LI14.10-N-049797)
- CEL With DTC 18B400 & Or 186A00 "Unknown Fault Type" With No Diagnostic Steps (LI07.16-N-055099)
- Def Light Stays On (TT 12/11-F)
- Exterior Body Panels
- Fuel Filler Door Difficult To Open (VERSION 4)
- Identification Of Noise Complaints Of The Vehicle Body-In-White (LI60.00-P-075851)
- Front Door Holder Loose/Makes Noises (LI72.00-N-048943)
- Cable Track Of Load Compartment Sliding Door Has Excessive Resistance/Is Cracked/Makes Noises (LI72.16-N-048764)
- Heat Shield On Fuel Tank (LI47.10-N-063943)
- ADBLUE Replacement Pumps Not Working (TT 11/14-B)
- ADBLUE Tank Gen. 1 Versus Gen. 2 (TT 11/14-C)
- Paint Damage On Bead Underneath End Cap Of Load Compartment Sliding Door Rail (LI98.00-N-048765)
- UPFITTER Bulletin - Bolted Connections On Rigid Bodies (08/20/2013)
- UPFITTER Bulletin - Cutting Cab Roof And B-Pillar Roof Bow (08/20/2013)
- UPFITTER Bulletin - Option Code Fa1 - Low Roof (06/24/2013)
- A-Pillar Crack Repair In Door Hinge Area (LI63.20-N-055922)
- Center Interior Trim Of Sliding Door Loose (LI72.16-N-055598)
- Cleaning Tin-Plated Surfaces (98.00/31)
- Stalling Due To Lack Of Fuel - Fuel Not Transferring In Saddle Tank (TT 03/11-B)
- Gap Dimensions On Sliding And Rear-End Door (V-B-72.00/02)
- Platform Side Board Latch Jams/Has Excessive Resistance (LI60.30-N-051223)
- Introduction Of Replacement Parts With Seam Seal (V-B-97.00/02)
- Load Compartment Sliding Door Arrester Inoperative (LI72.16-N-048763)
- Side Wall Seam Above Rear Lamps Cracked (LI64.30-N-048760)
- Exterior Lights
- Turn Signal Lamps On Trailer Flash Too Quickly (LI31.19-N-057118)
- Headlamps And Lamps Fogged And/Or Leaking (LI82.10-N-048712)
- UPFITTER Bulletin - Aftermarket Tail/Marker Light Adaption (Cc, My '07 - '13) (08/20/2013)
- Repair Kits For Frame Wiring Harness (LI54.18-N-050405)
- Condensation In The Headlamps (LI82.10-N-056996)
- Low Beams Inoperative (LI82.10-N-056666)
- NAFTA Marker Lamp L49 Leaking/Cracked (LI82.10-N-056460)
- Lamp Unit Fogged (LI82.10-N-053535)
- Brake Light Switch (V-B-82.10/02)
- Brake Lamps Inoperative (LI82.10-N-052274)
- UPRATED H7 Bulbs (V-B-82.10/01)
- Side Wall Seam Above Rear Lamps Cracked (LI64.30-N-048760)
- Complaints Connected With The Rain/Light Sensor (LI82.30-N-048714)
- Frames, Subframes & Crossmembers
- Interior Transverse Support Ribs SEPERATING From Roof Skin/Structural Adhesive Seeping (LI65.10-N-068734)
- Odor In Passenger Compartment (LI00.00-P-066046)
- Rattling Noises From Electric Step When Retracted (LI88.30-N-060760)
- Front Door Holder Loose/Makes Noises (LI72.00-N-048943)
- Accessories Of Any Kind Mounted To The Front End Prohibited; Frame Or Bumper (TT 07/16-A)
- UPFITTER Bulletin - Trailer Brake Control Prep (Green 4-Pin Connector) (09/26/2013)
- UPFITTER Bulletin - Bolted Connections On Rigid Bodies (08/20/2013)
- UPFITTER Bulletin - Chassis Cab Bulletin (08/20/2013)
- UPFITTER Bulletin - Cutting Cab Roof And B-Pillar Roof Bow (08/20/2013)
- A-Pillar Crack Repair In Door Hinge Area (LI63.20-N-055922)
- Throbbing/Droning Noises From Load Compartment While Driving, Inner Side Wall Panel Loose. (LI63.10-N-054112)
- Platform Side Board Latch Jams/Has Excessive Resistance (LI60.30-N-051223)
- Introduction Of Replacement Parts With Seam Seal (V-B-97.00/02)
- Load Compartment Sliding Door Arrester Inoperative (LI72.16-N-048763)
- Side Wall Seam Above Rear Lamps Cracked (LI64.30-N-048760)
- Front Suspension
- Ball Joint Check On Front Axle (LI33.00-N-066643)
- Creaking Noises At Front Spring At Low Outside Temperatures (LI32.20-N-066562)
- Noises At The Front Axle And At The Strut (LI32.00-N-049557)
- Ball Joint Lower Arm Rattling Noise (TT 11/15-D)
- Oil Loss At Front Suspension Strut (LI32.25-N-054643)
- Replacing Torsion Bar Mounts (V-B-32.20/01)
- Check Front Axle Ball Joints (V-B-33.20/01)
- Supporting Ball Joint Check (GI33.00-N-039932)
- Creaking Noises At Front Spring At Low Outside Temperatures (GI32.20-N-039931)
- Fuel System
- Procedure For When Diesel Fuel Tank Is Filled With Incorrect Fuel Type (VERSION 1)
- Rattling/Clattering Engine Noise (LI07.16-N-070308)
- Diesel Fuel Testing Information (LI47.00-N-068778)
- Engine Oil Level Above Max, Oil Indicator Light On (LI18.00-N-054809)
- Turbocharger Damage (TT 06/16-E)
- CEL And Engine In Limp Home Mode With DTC P11C300 "The Upper Limit Of Component B4/17 (Rail Pressure Sensor) Has Been Exceeded" (TT 05/16-B)
- DTC: P15FF00 "The Signal Line Of Component "B28/20 (Diesel Particulate Filter Differential Pressure Sensor)" Has A Short To Ground" (TT 05/16-C)
- Proper Fuel Filter Replacement (TT 04/16-C)
- ALS Diesel Fuel Test Information (LI47.00-N-062649)
- Engine In Limp-Home Mode, FC123900 (LI09.00-N-054723)
- Engine In Limp-Home Mode, FC150100, 150200 Or 150300 (LI09.00-N-056517)
- Vehicle Stalls When Driving / Will Not Crank Or Restart (TT 10/15-A)
- High Pressure Pump Removal And Installation (TT 05/15-B)
- P13CX00 "Minimum Actuation Duration For Zero Quantity Calibration For Injector Of X Not Reached" (TT 05/15-A)
- Fuel Filter Heater Fuse Location (F79) (TT 04/15-D)
- Charge Air Cooler Inspection (TT 03/15-C)
- Winter Operation Using Diesel Fuels (V-B-00.00/06)
- Fuel Filter Replacement (TT 02/15-B)
- Fuel Pump Pressure Test (TT 02/15-C)
- Any Repairs Performed In The "Clean Air Line" Area On Top Of Engine (TT 01/15-A)
- ADBLUE Replacement Pumps Not Working (TT 11/14-B)
- ADBLUE Tank Gen. 1 Versus Gen. 2 (TT 11/14-C)
- Biodiesel Information For MERCEDES-BENZ Vehicles 2014 Edition (5/20/14)
- Signs Of Incorrect Installation Of High Pressure Fuel Pump (TT 03/14-B)
- Procedure For When Diesel Fuel Tank Is Filled With Incorrect Fuel Type (V-B-47.10/01B)
- Diesel Odor, High-Pressure Pump Leaking (LI07.02-N-048800)
- Information On Low-Pressure Fuel Hoses (V-B-47.25/02)
- Operations In Clean Air Line Area (V-B-09.00/01)
- Stalling Due To Lack Of Fuel - Fuel Not Transferring In Saddle Tank (TT 03/11-B)
- Fuel Level Indicator Sticks (LI47.50-N-050487)
- Common Rail Leak Oil Line (V-B-07.16/01)
- Engine Does Not Start At Low Outside Temperatures (LI47.00-N-048803)
- Engine In Limp-Home Mode And Engine Diagnosis Indicator Lamp Lights Up (LI07.08-N-048806)
- Effects Of Admixtures In Diesel Fuel On Common-Rail (GI07.10-N-003037)
- Fuses & Circuit Breakers
- Wiring Damage On More Than 10 Wires (LI54.18-P-072022)
- Fault Code 43C0 Esp Control Unit - The Supply Voltage Is Too Low (LI54.15-N-064960)
- Fuel Filter Heater Fuse Location (F79) (TT 04/15-D)
- Brake Warning Lamp Illuminates About 5 Seconds After Every Start-Up And Stays Lit; No DTCS (TT 10/14-Q)
- Vehicle Does Not Start Or Starter Does Not Turn. Fault Code 155700, Fuse F28 Blown (LI15.30-N-056339)
- Fuse And Relay Box (V-B-54.15/08)
- Gauges & Instrument Panels
- Warning Lamp "Washer Fluid Empty" Yet Reservoir Is Not Empty (VERSION 1)
- Smog/Emissions Test Fail Due To One Or More Readiness Monitors Not Set (VERSION 2)
- Instrument Cluster Bevel And Lens Crack In Cold Weather (LI54.30-N-067702)
- Fuel GUAGE Jumps From 3 Bars To 1 (LI54.30-N-066583)
- Fuel Gauge Not Reading Correctly On Vehicles W/ Additional Generators Using Vehicle's Fuel Supply (TT 02/15-E)
- Brake Warning Lamp Illuminates About 5 Seconds After Every Start-Up And Stays Lit; No DTCS (TT 10/14-Q)
- Instrument Cluster Display Message "La 13" (LI54.30-N-048713)
- Warning Lamp Indicates "Air Filter Fouled" (LI54.30-N-056978)
- Time Cannot Be Adjusted In Instrument Cluster (LI54.30-N-051765)
- Instrument Cluster Message "Replace Key Battery" (80.61/61A)
- Illumination Of Heater Control Panel Flickers (LI83.30-N-051419)
- Fuel Level Indicator Sticks (LI47.50-N-050487)
- Warning Lamp Indicates "Air Filter Fouled" (LI54.30-N-048758)
- Warning Lamp Indicates "Air Filter Fouled" (GI54.30-N-040949)
- Headlights
- Headlamps And Lamps Fogged And/Or Leaking (LI82.10-N-048712)
- Repair Kits For Frame Wiring Harness (LI54.18-N-050405)
- Condensation In The Headlamps (LI82.10-N-056996)
- Low Beams Inoperative (LI82.10-N-056666)
- Lamp Unit Fogged (LI82.10-N-053535)
- UPRATED H7 Bulbs (V-B-82.10/01)
- Complaints Connected With The Rain/Light Sensor (LI82.30-N-048714)
- HVAC Control Systems
- Air Conditioning System Inoperative, Magnetic Clutch On Refrigerant Compressor Makes Noises, Is Damaged (LI83.55-N-059903)
- Condensation Entering Vehicle Interior Through Air Vents Roof Air Conditioning Unit (LI83.50-N-064932)
- Odor In Passenger Compartment (LI00.00-P-066046)
- Customer Feels The Runtime Of The Auxiliary Heater Is Too Short (Heating Duration Changed) (LI83.70-N-059145)
- Water Ingress Into Vehicle Interior Via Roof Air Conditioning (LI83.50-N-059306)
- Blower Motor Noisy (LI83.00-N-064573)
- Heater Does Not Blow Hot (TT 01/16-D)
- Heater Control Inoperative (LI83.00-N-062490)
- Rear HVAC (H08) - Water Ingress (TT 08/15-L)
- Rear HVAC (H08) - Water Ingress Issue (TT 07/15-C)
- Heater - Auxiliary Rear H13 (TT 02/15-F)
- Insufficient Heat Output Or Cooling Output At Front Of The Vehicle (LI83.00-N-059058)
- Stationary Heater, Auxiliary Heater And Heater Booster Service Information (V-B-83.70/06)
- Condensation Entering Vehicle Interior Through Air Vents Of Roof Air Conditioning (LI83.50-N-057649)
- Water Entry Via Roof Air Conditioning (HH7/H08) (LI83.50-N-048689)
- Air Conditioning Inoperative (LI83.30-N-055607)
- Noise Complaint At Refrigerant Compressor/Belt Drive With Air Conditioning Activated And Deactivated (LI83.55-P-056349)
- Stationary Heater Makes Noises (LI83.70-N-053462)
- Rattling Noise In Area Of Belt Pulley Of Refrigerant Compressor With Air Conditioning Deactivated (LI83.55-P-053157)
- No Cooling Output/Refrigerant Compressor Defective (LI83.55-P-052743)
- Auxiliary Heater With Ceramic Glow Plugs (V-B-83.70/04)
- Filling Quantity Information On Vehicle Sticker (V-B-83.30/02)
- Air Conditioning (V-B-83.00/01)
- Auxiliary Air Heater (H11) Shuts Down Prematurely After Operating For A Short Time. (LI83.70-N-048692)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Infotainment
- COMAND Download Manager (DLM): Download Aborted, Does Not Load To Selected USB Drive (LI82.85-P-071912)
- Message "A Data Plan For Internet Services From MERCEDES Me Portal Is Needed To Use This Service" In The Head Unit (LI82.85-P-069515)
- Navigation Destinations Cannot Be Found In Poi Download/"Send2BENZ" Service Inoperative (LI82.85-P-068210)
- Interior/Exterior Trim
- Condensation Entering Vehicle Interior Through Air Vents Roof Air Conditioning Unit (LI83.50-N-064932)
- Instrument Cluster Bevel And Lens Crack In Cold Weather (LI54.30-N-067702)
- Water Ingress Into Vehicle Interior Via Roof Air Conditioning (LI83.50-N-059306)
- License Plate Bracket On Rear-End Door Does Not (LI88.00-N-063976)
- Throbbing/Droning Noises From Load Compartment While Driving; Inner Side Wall Panel Loose (TT 12/15-C)
- Step Does Not Extend/Retract Completely Or Is Sluggish (LI88.00-N-062142)
- Rear HVAC (H08) - Water Ingress (TT 08/15-L)
- Rear HVAC (H08) - Water Ingress Issue (TT 07/15-C)
- Installation Of Partition Wall (V-B-68.70/01)
- Cover Of Storage Slot At Front Under Roof Liner (Ff8) Not Fitting (LI68.30-N-059117)
- Windshield Trim Frame Loose (LI67.10-N-057147)
- Pilling Formation (Small Fiber Knobs) On The Seat Covers (LI91.18-N-048773)
- Wooden Floor Panels Not Flush With Each Other (LI68.80-N-049528)
- UPFITTER Bulletin - Removal & Reinstallation Of B-Pillar Cover (08/20/2013)
- Center Interior Trim Of Sliding Door Loose (LI72.16-N-055598)
- C-Pillar In Area Of Stop Buffers For Load Compartment Sliding Door Deformed (LI72.16-N-055303)
- Illumination Of Heater Control Panel Flickers (LI83.30-N-051419)
- Replace The Clips On The Protective Strips (V-B-88.80/01)
- Stop Plugs In Roof (LI65.00-N-048761)
- Interior/Illumination Lights
- Lubrication System
- Lubricating Oil Analysis Information (LI01.00-P-068886)
- ALS Engine Oil, Diesel Fuel, And Coolant Analysis Information (LI01.00-N-077592)
- Procedure In Case Of Oil Loss From Engine Compartment Or Visible Traces Of Oil (LI01.00-N-074210)
- Lubricating Oil Analysis Information (LI01.00-N-068885)
- Transmission Leak In Area Of Oil Pump (LI27.00-N-066833)
- Engine Oil Level Above Max, Oil Indicator Light On (LI18.00-N-054809)
- Engine Oil Level Above Max (LI18.40-P-066105)
- Traces Of Oil In Area Around Oil/Water Heat EXCHANGER (Inner V) On Engine 642 (LI18.30-N-056338)
- Rear Engine Cover (TT 06/15-A)
- Crankshaft Main Bearing Failure Following Oil Cooler Seal Replacements (TT 11/14-L)
- Common Rail Leak Oil Line (V-B-07.16/01)
- Engine Oil Extraction Probe 1000MM (V-B-18.00/01)
- Manual Steering
- Evaluating Play In Rack-And-Pinion Steering (LI46.20-P-071904)
- Power Steering Hose Updated Repair Method (LI46.00-N-069137)
- Power Steering Hose Repair/Inspection/Correction (LI46.00-N-068838)
- Clicking Noises In Rack-And-Pinion Steering (LI46.25-N-051661)
- Processing Of Steering System Complaints (V-B-46.25/01)
- Mechanical
- Engine Does Not Start, Left Engine Mount Bolt Deformed Or Broken (LI22.10-N-071666)
- Engine Oil In Coolant Circuit (LI20.30-P-069996)
- Odor In Passenger Compartment (LI00.00-P-066046)
- Transmission Leak In Area Of Oil Pump (LI27.00-N-066833)
- Carrier For Power Take-Off With Codes N62, N63 And H08, Breaks (LI83.55-N-048691)
- Traces Of Oil In Area Around Oil/Water Heat EXCHANGER (Inner V) On Engine 642 (LI18.30-N-056338)
- Cam Timing Information (TT 07/16-C)
- Turbo Inlet Seal (TT 06/16-A)
- Turbocharger Damage (TT 06/16-E)
- Excessive Belt Vibration And/Or CEL With DTCS: 13BA00, 13BB00, 13BC00, 13BD00, 13BE00, 13BF00 "Maximum Actuation Duration For Zero Quantity Calibration For Fuel Injector Of Cylinder X Exceeded" (TT 05/16-E)
- Crankshaft Main Bearing Shell Size Identification (TT 04/16-A)
- Engine In Limp-Home Mode, FC123900 (LI09.00-N-054723)
- Engine In Limp-Home Mode, FC150100, 150200 Or 150300 (LI09.00-N-056517)
- CEL On; Air Cleaner Housing Damaged (TT 02/16-B)
- Poly-V Belt For Roof Air Conditioning (H08) Or Second Level Alternator (N62) Or Front Power Take-Off (N63) Torn (TT 09/15-K)
- Additional Poly-V Belt For Roof Air Conditioning Or Front Power Take-Off Torn (LI13.20-N-054722)
- Rear Engine Cover (TT 06/15-A)
- CDI Ecu Will Not Learn The CMP Sensors Due To Timing Chain Stretch (TT 04/15-E)
- Charge Air Cooler Inspection (TT 03/15-C)
- Any Repairs Performed In The "Clean Air Line" Area On Top Of Engine (TT 01/15-A)
- Crankshaft Main Bearing Failure Following Oil Cooler Seal Replacements (TT 11/14-L)
- Noise After Start (TT 11/14-K)
- UPFITTER Bulletin - Sprinter Block Heater Mock-Up (3.0L V6 Om642) (08/20/2013)
- Engine Makes Noise, Ticking/Crackling (LI03.20-N-056658)
- Operations In Clean Air Line Area (V-B-09.00/01)
- Belt Drive Alignment With Auxiliary A/C Compressor Causing Abnormal Belt Wear (TT 05/12-D)
- Engine HYDROLOCK Repairs / Diagnosis (TT 02/11-B)
- Drive Plate (V-B-03.30/01)
- Engine Oil Extraction Probe 1000MM (V-B-18.00/01)
- Warning Lamp Indicates "Air Filter Fouled" (LI54.30-N-048758)
- Warning Lamp Indicates "Air Filter Fouled" (GI54.30-N-040949)
- Mechanical - Hydraulic
- Noises At The Front Axle And At The Strut (LI32.00-N-049557)
- Diagnosing Complaints Of Brake Pulsation (TT 06/15-O)
- Brake Noises (Squeaking) At The Front Axle (LI42.10-N-048721)
- Cleaning Axle Hubs When Installing Brake Discs (42.10/123A)
- Grinding Noise At Rear Axle Brake (LI42.10-N-048723)
- Rattling Noises At The Front Axle (LI42.10-N-049556)
- Brake Noises (Squeaking) At The Front Axle (LI42.10-N-056461)
- Brake Caliper (V-B-42.10/02)
- Parts Identification Of Parts Scope For Brake Pads In The Electronic Parts Catalog (EPC-Net) (V-B-42.10/03A)
- Mirrors
- Passive Restraints
- Power Takeoff
- Procedures
- Vehicle Registration Failure In The State Of CALIFORNIA Due To Arb Adoption Of Bar-OIS Modified Software Regulations (LI07.61-P-073379)
- Approved Emission Modification Campaign 2020040001, 2020040002, Or 2020040003 Special Procedure In XENTRY Does Not Complete Due To CDI Software (LI07.08-N-072747)
- New Required Replacement MIDTRONICS Battery Tester; Special Tool: 165-Exp 717 Kit (V-B-58.20/01)
- Rear Suspension
- Restraints Control Systems
- Seats
- Easy Entry/Exit Feature And Automatic Seat Positioning To Size Of Driver Inoperative (LI91.10-P-073267)
- Vibration When Adjusting Seat (LI91.10-P-073256)
- Seat Belt Does Not Roll Up Correctly (LI91.40-N-062773)
- Splitting Of Seat Covers (LI91.10-P-063393)
- Seat Belt Does Not Roll Up Correctly (LI91.40-N-051128)
- AMG Ornamental Molding Piece On Seats (LI91.18-P-065627)
- Backrest Of Last Seat Row Chafes Against Rear-End Door (LI91.21-N-061656)
- SRS Indicator Lamp On (LI91.40-N-054521)
- Pilling Formation (Small Fiber Knobs) On The Seat Covers (LI91.18-N-048773)
- UPFITTER Bulletin - Removal & Reinstallation Of B-Pillar Cover (08/20/2013)
- UPFITTER Bulletin - Remove 4 Passenger Bench (08/20/2013)
- Seat Belt Wet, SRS Light On (LI91.40-N-056663)
- Starter
- Engine Starts With A Delay In Cold Ambient Temperatures (LI07.16-N-070307)
- Automatic Engine Start To Maintain Refrigeration Temperature (TT 04/16-E)
- Vehicle Stalls When Driving / Will Not Crank Or Restart (TT 10/15-A)
- Vehicle Will Not Start Or Loud Noise From Exhaust System (TT 07/15-B)
- Aftermarket Remote Start Kits (TT 09/14-C)
- UPFITTER Bulletin - Aux Battery Retrofit Guideline (My '07 - '13) (08/20/2013)
- Vehicle Does Not Start Or Starter Does Not Turn. Fault Code 155700, Fuse F28 Blown (LI15.30-N-056339)
- New Required Replacement MIDTRONICS Battery Tester; Special Tool: 165-Exp 717 Kit (V-B-58.20/01)
- AGM Battery Cannot Be Charged (LI54.10-N-050322)
- Battery Maintenance (V-B-54.10/02)
- Steering Column
- Creaking/Humming During Steering Column Adjustment (Height/Longitudinal Adjustment) (LI46.15-P-076223)
- Steering Wheel Vibrations In Vehicle Speed Range Between 70 - 80 Mph (LI40.10-N-070401)
- Steering Column Clicking Or Cracking Noise (LI46.10-N-058722)
- Steering Lock Does Not Disengage, Vehicle Cannot Be Started (LI46.10-N-048844)
- Steering Wheel Vibrations In Vehicle Speed Range Between 70 - 80 Mph (LI40.10-N-048693)
- Cracking Noises In Steering Column (LI46.10-N-056993)
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- System
- Repair Guidelines For Turbocharger Failures (LI09.40-N-063089)
- Engine Power Output Is Reduced And/Or Engine Indicator Lamp Lights Up, Various Fault Codes Present In Area Of Exhaust Gas RECIRCULATION (EGR System) Or In Charge Air System (LI14.20-N-071638)
- Check Engine Light On With Fault Codes P203B31, P203B49, P206B31, P13DF00 Present In The SCR Control Unit (LI49.20-N-071225)
- Engine Starts With A Delay In Cold Ambient Temperatures (LI07.16-N-070307)
- Poor Engine Starting After Long Period Out Of Use (LI15.20-N-057008)
- Engine Running Rough, Engine Diagnosis Indicator Lamp Lights Up, Fault Code P11C300 Or P019185 Present In CDI Control Unit (LI07.04-N-060527)
- Carrier For Power Take-Off With Codes N62, N63 And H08, Breaks (LI83.55-N-048691)
- CEL With DTC: P11C300 Stored In CDI (TT 07/16-D)
- CEL With Multiple Control Modules Exhibiting Numerous Can Codes (TT 06/16-D)
- Turbocharger Damage (TT 06/16-E)
- CEL And Engine In Limp Home Mode With DTC P11C300 "The Upper Limit Of Component B4/17 (Rail Pressure Sensor) Has Been Exceeded" (TT 05/16-B)
- DTC: P15FF00 "The Signal Line Of Component "B28/20 (Diesel Particulate Filter Differential Pressure Sensor)" Has A Short To Ground" (TT 05/16-C)
- Excessive Belt Vibration And/Or CEL With DTCS: 13BA00, 13BB00, 13BC00, 13BD00, 13BE00, 13BF00 "Maximum Actuation Duration For Zero Quantity Calibration For Fuel Injector Of Cylinder X Exceeded" (TT 05/16-E)
- Automatic Engine Start To Maintain Refrigeration Temperature (TT 04/16-E)
- Poor Engine Starting After Long Period Out Of Use Li15.20-N-057008 (TT 04/16-B)
- Proper Fuel Filter Replacement (TT 04/16-C)
- ALS Diesel Fuel Test Information (LI47.00-N-062649)
- CEL With DTC P178200 (TT 30/16-A)
- Engine In Limp-Home Mode, FC123900 (LI09.00-N-054723)
- Engine Power Insufficient, Engine Diagnosis Indicator Lamp Lights Up And Differential Pressure Sensor Fault Codes Current And/Or Stored In CDI Control Unit (LI07.04-N-056999)
- Engine In Limp-Home Mode, FC150100, 150200 Or 150300 (LI09.00-N-056517)
- Mechanical Fault In NOX Sensors With Fault Codes Stored-Current In Engine Control Unit (LI47.50-N-057830)
- CEL On; Air Cleaner Housing Damaged (TT 02/16-B)
- Check Engine Light With DTC P15FF00 (TT 02/16-A)
- CEL With DTCS 124700, 11A300, 11C500, 108800 (TT 01/16-E)
- Error Code 8.6.00 On Display Of Multiplexer And "Ignition On Signal" Is Not Recognized When Trying To Use DAS On A XENTRY Vehicle (TT 01/16-A)
- Check Engine Light On With One Or More Of The Following DTCS 108800, 11A300, 11C500, 124700 (LI20.40-N-062876)
- Check Engine Light On With One Or More Of The Following DTCS P147600, P147700, P149D00, P153800 (LI14.40-N-062147)
- Check Engine Light On With One Or More Of The Following DTCS P18B800, P18B900 (LI14.40-N-061091)
- Check Engine Light On With One Or More Of The Following DTCS P18BC00, P18BD00 (LI14.40-N-060212)
- Vehicle On-Board Diagnostic Systems And Emissions Control Tampering (V-B-00.00/09)
- SCR Testing Notes (TT 12/15-B)
- ADBLUE Tank Heated Line Leaking / Melted With CEL On And Fault Codes P20B914 And P20BA1A (TT 11/15-E)
- XENTRY ADBLUE Dosing Valve Testing (TT 11/15-C)
- ADBLUE Tank Was Run Empty - Engine And/Or ADBLUE® Indicator Lamp Or "Check ADBLUE®" Indicator And/Or "No Start In XXX Km" Is Activated In The Instrument Cluster And Is Not Deactivated After Refilling With ADBLUE® (LI14.40-N-061956)
- Vehicle Stalls When Driving / Will Not Crank Or Restart (TT 10/15-A)
- DPF Filter Cracked / Broken (LI49.10-N-059066)
- SCERF - Stationary Continues Engine Running Feature (TT 09/15-L)
- Vehicle Will Not Go Over 5MPH (8KM/H); Not Related To Countdown Mode (TT 09/15-J)
- ADBLUE Fluid Testing (TT 08/15-J)
- Dosing / Metering Valve Test (TT 08/15-K)
- New EGR Valve Resists Against Moisture Ingress (TT 08/15-I)
- Check Engine Light On, DTCS P15B700, P18B400, P178100, P15E100 (LI14.00-N-061960)
- Vehicle Will Not Go Over 5MPH (8KM/H) Not Related To Countdown Mode (LI07.00-N-061850)
- Om642 - CEL With DTC 20B811, 208B77, 20BD11, 20BE1B - ADBLUE Tank Heater Coating (TT 07/15-D)
- Vehicle Will Not Start Or Loud Noise From Exhaust System (TT 07/15-B)
- Sprinter III SCR Testing Using 05/15 XENTRY SW (TT 06/15-D)
- CEL With DTC P178200 & P18D300 (TT 05/15-C)
- Engine In Limp-Home Mode, CEL Lights Up (TT 05/15-D)
- High Pressure Pump Removal And Installation (TT 05/15-B)
- P13CX00 "Minimum Actuation Duration For Zero Quantity Calibration For Injector Of X Not Reached" (TT 05/15-A)
- Road Test Procedure To Reset Tampering (TT 05/15-E)
- Software-Based Retrofits (V-B-00.00/08)
- Fuel Filter Heater Fuse Location (F79) (TT 04/15-D)
- NOX Sensor Replacement Tip (TT 04/15-C)
- CDI Ecu Will Not Learn The CMP Sensors Due To Timing Chain Stretch (TT 04/15-E)
- Charge Air Cooler Inspection (TT 03/15-C)
- Electrical Testing At The CDI Module (TT 03/15-A)
- Engine Sensor Replacement (TT 03/15-B)
- Winter Operation Using Diesel Fuels (V-B-00.00/06)
- Fuel Filter Replacement (TT 02/15-B)
- Fuel Pump Pressure Test (TT 02/15-C)
- ADBLUE Delivery Modules - Broken Nipples (TT 02/15-H)
- Any Repairs Performed In The "Clean Air Line" Area On Top Of Engine (TT 01/15-A)
- Engine May Be In Limp-Home Mode And/Or Engine Indicator Lamp Lights Up, Various Fault Codes Present In Area Of Exhaust Gas RECIRCULATION (EGR System) Or In Charge Air System (LI14.20-N-058842)
- ADBLUE Replacement Pumps Not Working (TT 11/14-B)
- ADBLUE Tank Gen. 1 Versus Gen. 2 (TT 11/14-C)
- Lack Of Power Going Up A Hill Or From A Stop But OK When Driving (TT 10/14-P)
- Return Of Diagnostic Data In Event Of Faults In Exhaust After-Treatment System (V-B-14.40/03)
- Fault Relating To SCR ADBLUE Warning Strategy (LI14.40-N-060049)
- Aftermarket Remote Start Kits (TT 09/14-C)
- Biodiesel Information For MERCEDES-BENZ Vehicles 2014 Edition (5/20/14)
- ADBLUE Test Cycle (TT 05/14-I)
- Exhaust Back Pressure Sensor (TT 05/14-C)
- Performing Stationary Regeneration Of DPF On Vehicles With Automatic Idle Shut-Down (TT 05/14-D)
- ENGINE AND/OR ADBLUE® INDICATOR LAMP LIGHTS UP "CHECK AD-BLUE®" AND/or "NO START IN XXX" APPEARS IN INSTRUMENT CLUSTER (LI49.20-N-058621)
- Signs Of Incorrect Installation Of High Pressure Fuel Pump (TT 03/14-B)
- Procedure For When Diesel Fuel Tank Is Filled With Incorrect Fuel Type (V-B-47.10/01B)
- UPFITTER Bulletin - PSM - Program Loading (09/26/2013)
- ESM (Electronic Selector Lever Module) Fault 0002 "UNDERVOLTAGE" (LI27.60-N-048766)
- Engine Switches To Limp-Home Mode Or Has Insufficient Output (LI14.10-N-049797)
- Noises During Engine Run-On/EGR Valve Cleaning Function (LI14.20-N-048802)
- UPFITTER Bulletin - Chassis Cab Bulletin (08/20/2013)
- Automatic Transmission Fluid Burnt, Shavings In Fluid, Automatic Transmission Stalls Engine (Only 5-Speed Automatic Transmission SA G40) (LI27.00-N-048695)
- Diesel Odor, High-Pressure Pump Leaking (LI07.02-N-048800)
- UPFITTER Bulletin - Retrofit High Idle Control On 906.XXX (06/24/2013)
- Information On Low-Pressure Fuel Hoses (V-B-47.25/02)
- Vehicle Does Not Start Or Starter Does Not Turn. Fault Code 155700, Fuse F28 Blown (LI15.30-N-056339)
- Operations In Clean Air Line Area (V-B-09.00/01)
- UPFITTER Bulletin - PSM - Parametric Special Module (02/26/2013)
- Check Engine Light DTC 20B811 (TT 12/11-G)
- Def Light Stays On (TT 12/11-F)
- Stalling Due To Lack Of Fuel - Fuel Not Transferring In Saddle Tank (TT 03/11-B)
- Engine Does Not Start At Low Outside Temperatures (LI47.00-N-048803)
- Warning Lamp Indicates "Air Filter Fouled" (LI54.30-N-048758)
- Towing
- Towing Systems
- Transmission Control Systems
- Working Speed Control Inoperative After Programming Of Common Rail Diesel Injection System (CDI) Control Unit (LI54.21-N-066783)
- EEPROM (TT 01/15-J)
- EHS Number (TT 01/15-K)
- ESM (Electronic Selector Lever Module) Fault 0002 "UNDERVOLTAGE" (LI27.60-N-048766)
- Automatic Transmission Fluid Burnt, Shavings In Fluid, Automatic Transmission Stalls Engine (Only 5-Speed Automatic Transmission SA G40) (LI27.00-N-048695)
- Gear Range Cannot Be Engaged / No Power Flow (LI27.60-N-048889)
- Nag2 With DTC XXXX And Corresponding Code Description "Component Y3/8N4 (Fully Integrated Transmission Control (VGS) Control Unit) Is Defective" (LI27.35-P-051683)
- Programming Control Units (V-B-54.21/09)
- Warning Systems
- Wheel Hubs
- Wheels & Tire System
- Steel Wheels Cracked/Rusted Leaking Air (LI40.10-N-065034)
- Cleaning Axle Hubs When Installing Brake Discs (42.10/123A)
- Steering Wheel Vibrations In Vehicle Speed Range Between 70 - 80 Mph (LI40.10-N-048693)
- Vibrations In Vehicle (LI40.10-N-048690)
- Approved Alkaline MB Wheel Cleaner For Light Alloy Disk Wheel (V-B-40.10/02)
- Radial Crack In Light Alloy Disk Wheel (V-B-40.10/03)
- TPMS System (Tire Pressure Monitor, Special Equipment Code Ry2) Nonfunctional - After Installation Of Complete Wheels Without Wheel Sensors. (LI40.15-N-040597)
- Window Motors & Regulators
- Wiper/Washer Systems
- Warning Lamp "Washer Fluid Empty" Yet Reservoir Is Not Empty (VERSION 1)
- Washer Fluid Indicator In Instrument Cluster Is Not Correct, And In Model Series 166: Fault Entry B23267B In Front SAM (LI82.35-P-048244)
- Replace Spray Nozzle (V-B-82.35/03)
- Complaints Connected With The Rain/Light Sensor (LI82.30-N-048714)
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- CEL With DTC: P11C300 Stored In CDI (TT 07/16-D)
- SRS System Wiring Repairs (TT 07/16-B)
- CEL With Multiple Control Modules Exhibiting Numerous Can Codes (TT 06/16-D)
- Error Code 8.6.00 On Display Of Multiplexer And "Ignition On Signal" Is Not Recognized When Trying To Use DAS On A XENTRY Vehicle (TT 01/16-A)
- Electrical Testing At The CDI Module (TT 03/15-A)
- UPFITTER Bulletin - Trailer Brake Control Prep (Green 4-Pin Connector) (09/26/2013)
- UPFITTER Bulletin - Electrical Connectors For Body Builders [EK1] (My '07-'13) (08/20/2013)
- UPFITTER Bulletin - Sprinter Electrical Info (My '07 - '13) (08/20/2013)
- UPFITTER Bulletin - Sprinter Ground Terminals (08/20/2013)
- Repair Kits For Frame Wiring Harness (LI54.18-N-050405)