Technical Service Bulletins

Accessories & Equipment
- All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
- Availability Of Non-Required Tools - April 2007 (ST-003/07)
- WDS PTU Battery Warranty And Order Information (ST-001/05)
- Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
- All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Gauge / Speedometer Replacement Guidelines (CAT. 09, NO. 006/02)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
Air Bag, SRS
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Non Genuine Accessories Affect On Air Bag Operation (CAT. T, NO. 023/96)
Anti-Theft Systems
- Service Information For Keyless Entry System (09-018/01)
- Keyless Remote Transmitter Battery Inspection PROC. (CAT. 09, NO. 010/00R)
- Keyless Remote Transmitter Battery Inspection Procedure (010/00R)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
Automatic Trans
- Automatic Transmission/Transaxle Cooler And Lines Flushing Procedure (05-012/10)
- Rattling Noise At 3000 Rpm - Tie-Strap Wire Harness (T011/98)
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
Auxiliary Emission Control Systems
- Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
- Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
- Mil Illuminates With DTC P0402 Stored In Memory (01-012/01)
- Year 2000 Compliance (01-018/99)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
Body Electrical
- "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
Body Interior
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
Brakes Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
Charging Systems
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
Clutch
- Rattling Noise From Engine (014/00R)
Cooling System (Mechanical)
- Reconditioned Anti-Freeze (CAT. E, NO. 002/96)
Cruise Control Systems
- Fluctuating Cruise Control Set Speed - Control Unit (CAT. 01, NO. 004/99)
Differentials & Drive Axles
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
Engine Control Systems
- "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
- Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
- Year 2000 Compliance (01-018/99)
- Block Heater Installation Cautions (CAT. M09, NO. 003/99)
- Engine Hard To Start - Excessive Cranking Time (CAT. M01, NO. 003/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
- Shipment Of Special Tools (CAT. ST, NO. 002/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
Entertainment Systems
- Multiple Models - Cd Module Malfunctions (CAT. 09, NO. 010/03)
- Cigarette Lighter Does Not Work Properly (09-007/00)
- ETR Operation - Cassette Changes Before Tape Ends (MT 0297-05)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
Exhaust
- Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
- Mil Illuminates With DTC P0402 Stored In Memory (01-012/01)
- Rattle Noise From Main Silencer - Replace Silencer (F011/98)
Exterior Body Panels
- Service Bumper Specification Change (09-022/09)
- Accessory Chrome Fuel Door Will Not Open (09-008/02)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Hard To Refuel - Replace The Non-Return Valve (01-008/99)
Frames, Subframes & Crossmembers
- Service Bumper Specification Change (09-022/09)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
Fuel System
- Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Multiple Models - Fuel Injector(S) Replacement Guidelines (01-013/02)
- Engine Hard To Start - Excessive Cranking Time (CAT. M01, NO. 003/99)
- Shipment Of Special Tools (CAT. ST, NO. 002/98)
- CALIFORNIA Reformulated Gasoline (Effect On Vehicle Performance And Fuel Economy) (CAT. F, NO. 014/96)
Fuses & Circuit Breakers
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Gauge / Speedometer Replacement Guidelines (CAT. 09, NO. 006/02)
- Power Window Switch Hole Cover Does Not Fit Flush (S013/98)
Heated Glass/Defoggers
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
HVAC Control Systems
- Air Conditioning Musty/Mildew Odor (07-006/07)
- Poor Blower Performance / Wet Passenger Floor (5768)
- Air Conditioning - Musty / Mildew Odor (CAT. 07, NO. 004/02)
- Heater Hose/Core Connector Dealer Hint (MT 0597-09)
- Use Of A/C Tracer Dye (U-008/97)
Identification
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
Ignition System
- Engine Hard To Start/Excessive Cranking Time (01-003/99)
- Spark Plug Installation / Removal Caution (01-036/06)
Infotainment
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
Interior/Exterior Trim
- Proper Usage Of Driver's Floor Mat (09-027/14)
- Leather Seat Trim Damage (CAT. 09, NO. 016/99)
- Accessory Chrome Fuel Door Will Not Open (09-008/02)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Soft Top Cover Comes Off Or Breaks - Replace Cover (09-007/99)
Manual Trans
- 6-Speed Manual Transmission Will Not Shift Into 5TH Or Reverse Gear (05-012/02)
- Rattling Noise At 3000 Rpm - Tie-Strap Wire Harness (T011/98)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Block Heater Installation Cautions (CAT. 09, NO. 003/99)
- Rattling Noise From Engine (014/00R)
- Rattling Noise From Engine (CAT. 01, NO. 014/00R)
- Rattling Noise From Eng - Replace Short/Partial Eng (01-010/99)
- Block Heater Installation Cautions (CAT. M09, NO. 003/99)
- Shipment Of Special Tools (CAT. ST, NO. 002/98)
Mechanical - Hydraulic
- Brake Rotor Machining And Replacement Criteria (CAT. P, NO. 001/96)
- Brake Judder Repair ACCU Industries National Account (CAT. ST, NO, 003/94)
Paint & Coatings
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Paint Damage By Trunk Rubber Cushion (S007/98)
- Paint Damage - Iron Particles / Industrial Fallout / Acid Rain (09-025/04)
Procedures
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
Restraints Control Systems
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
Seats
- Leather Seat Trim Damage (CAT. 09, NO. 016/99)
- Seat Belt Extenders Description/Ordering Info (S005/98)
- Power Window Switch Hole Cover Does Not Fit Flush (S013/98)
Starter
- 12 Volt Battery Test Procedure Requirements For Warranty (Using The COA-8000PM) (01-054/10)
- Battery Maintenance (01-029/06)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
- Special Service Equipment Distribution - November 2010 (ST-002/10)
- Engine Hard To Start/Excessive Cranking Time (01-003/99)
- Battery Charging Cautions (CAT. 01, NO. 012/99)
Steering Column
- Steering Wheel Slightly Off Center (CAT. N, NO. 001/98)
Steering Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
Sun Roof/T-Top/Convertible Top
- Soft Top Split (CAT. 09, NO. 003/03)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- White Stains On Inside Of Soft Top (09-010/99)
- Power Window Switch Hole Cover Does Not Fit Flush (S013/98)
Suspension Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
System
- "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
- Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
- Mil Illuminates With DTC P0402 Stored In Memory (01-012/01)
- Shipment Of MAZDA World Wide Diagnostic Tool During October 2000 (00-006/00)
- Year 2000 Compliance (01-018/99)
- Engine Hard To Start/Excessive Cranking Time (01-003/99)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
- Shipment Of Special Tools (CAT. ST, NO. 002/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Update Warnings On Ids (Laptop Pc) And PFM (PDS File Manager) For MAZDA Modular Diagnostic System (M-MDS) (01-028/06)
Transmission Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Rattling Noise At 3000 Rpm - Tie-Strap Wire Harness (T011/98)
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
- Transmission Control Module (TCM) Protector Pad Application (K011/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
Window Motors & Regulators
- Power Window Switch Hole Cover Does Not Fit Flush (S013/98)
- Windshield Fog Or Film (MT 0397-04)
- Rear Window Defroster Grid Line Diagnosis / Repair And Terminal Tab Repair (CAT. T, NO. 015/95)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Rattling Noise At 3000 Rpm - Tie-Strap Wire Harness (T011/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)