Technical Service Bulletins: Other Variant

WARNING: This page is about the MX-6 Base, Automatic, which is a different variant/trim than selected.

A/C Compressor
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- A/C O-Ring Replacement (U005/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
Accessories & Equipment
- All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
- All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- 4 CYL: Mil Illumination & DTC PO400 Or P1195 Stored (F025/97)
- Lack Of Power/Rough Idle - Exhaust/Injector/EGR Info (F026/97)
- 6 CYL: Mil Illumination & DTC PO400 Or P1195 Stored (F022/97)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- Data Link Connector Circuit Changes (MT 0597-05)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
Air Bag, SRS
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Air Bag Warning Light Troubleshooting (T014/96)
Anti-Lock Brakes
- Abs Light On/Models With 4 Wheel Abs (MT 0997-04)
Anti-Theft Systems
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Water Leak From The Door Mirror Area (MT 0297-02)
- Keyless Entry Inoperative\Intermittent - Battery (MT 1197-11)
- KES Transmitter - Programmings The Same As 96 Models (MT 0397-02)
- Power Door Lock Knob Malfunction (T022/96)
Automatic Trans
- INADVERTANT Disabling Of Brake Shift Interlock (04-005/02)
- La4AEL/GF4AEL Auto Trans Irregular 4-3/O'Drive Shift (K015/98)
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
- Oil Leak From Breather - Automatic Transmission (K006/97)
- La4A El Auto Trans Leaking Fluid From Filler (MT 0697-03)
- DTC P0741 - Torque Converter Clutch SYS. Performance (K002/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Auxiliary Emission Control Systems
- Year 2000 Compliance (01-018/99)
- Mil Illumination DTC P1407 - Reprogram Pcm (F015/98)
- Mil Illuminated W/DTC P0421 - Pcm Reprogram/Catalyst (F005/98)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- 4 CYL: Mil Illumination & DTC PO400 Or P1195 Stored (F025/97)
- Lack Of Power/Rough Idle - Exhaust/Injector/EGR Info (F026/97)
- Check Engine Light DTC P0505 (MT 1197-08)
- 6 CYL: Mil Illumination & DTC PO400 Or P1195 Stored (F022/97)
- OBD-II Procedure After Battery Charge/REPL-Pcm/REPL (MT 0797-09)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- Data Link Connector Circuit Changes (MT 0597-05)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- V-6 DTC P0441 - Pinched Purge Solenoid Vacuum Hose (MT 0597-01)
- New Pcm - Includes DTC For Power Steer Press. Switch (MT 0397-07)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Axle Shafts
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Body Electrical
- "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
- Electrical Connector And Terminal Replacement Part Availability (T004/97)
Body Interior
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- 4 CYL: Mil Illumination & DTC PO400 Or P1195 Stored (F025/97)
- Lack Of Power/Rough Idle - Exhaust/Injector/EGR Info (F026/97)
- 6 CYL: Mil Illumination & DTC PO400 Or P1195 Stored (F022/97)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- Data Link Connector Circuit Changes (MT 0597-05)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
Brakes Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Abs Light On/Models With 4 Wheel Abs (MT 0997-04)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Charging Systems
- Electrical Connector And Terminal Replacement Part Availability (T004/97)
- 2.0L Eng Revised Alternator Adjustment Bracket (MT 1197-07)
Clutch
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Cooling System (Mechanical)
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
Differentials & Drive Axles
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Driveshaft & Universal Joints
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Engine Control Systems
- "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
- Year 2000 Compliance (01-018/99)
- Mil Illumination DTC P1407 - Reprogram Pcm (F015/98)
- Mil Illuminated W/DTC P0421 - Pcm Reprogram/Catalyst (F005/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
- 4 CYL: Mil Illumination & DTC PO400 Or P1195 Stored (F025/97)
- Lack Of Power/Rough Idle - Exhaust/Injector/EGR Info (F026/97)
- Check Engine Light DTC P0505 (MT 1197-08)
- 6 CYL: Mil Illumination & DTC PO400 Or P1195 Stored (F022/97)
- OBD-II Procedure After Battery Charge/REPL-Pcm/REPL (MT 0797-09)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- Data Link Connector Circuit Changes (MT 0597-05)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- V-6 DTC P0441 - Pinched Purge Solenoid Vacuum Hose (MT 0597-01)
- New Pcm - Includes DTC For Power Steer Press. Switch (MT 0397-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Entertainment Systems
- Multiple Models - Cd Module Malfunctions (CAT. 09, NO. 010/03)
- ETR Operation - Cassette Changes Before Tape Ends (MT 0297-05)
- Cigarette Lighter Replacement (S018/97)
- Speaker Self Diagnostics Feature (MT 0697-04)
Exhaust
- Mil Illuminated W/DTC P0421 - Pcm Reprogram/Catalyst (F005/98)
Exterior Body Panels
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Trunk Water Leak - Seam Sealer Inspection (MT 0397-09)
Exterior Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
Frames, Subframes & Crossmembers
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
Front Suspension
- Stabilizer Bar Bushing Replacement Procedure (R001/97)
- Suspension Rattle - Sway Bar Control Link Socket (MT 0397-06)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Fuel System
- Lack Of Power/Rough Idle - Exhaust/Injector/EGR Info (F026/97)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Fuses & Circuit Breakers
- Lack Of Power/Rough Idle - Exhaust/Injector/EGR Info (F026/97)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Cigarette Lighter Replacement (S018/97)
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- Data Link Connector Circuit Changes (MT 0597-05)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Checking Points For Dead Battery - Dark Current Draw (G003/96)
Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Rattle Noise From Lower Console - Retaining Pin (MT 0697-01)
- Squeak/Rattle From Dash Defroster Area (MT 0597-03)
Headlights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
HVAC Control Systems
- Noise From Blower Motor Due To Foreign Substance (U013/97)
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- Heater Hose/Core Connector Dealer Hint (MT 0597-09)
- A/C O-Ring Replacement (U005/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Identification
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
Ignition System
- Spark Plug Wire Resistance Specifications (G006/97)
- Check Spark Plug Wire Resistance (MT 1097-04)
- Supporter & Bracket Of HIGHT Tension Leads (G004/97)
Interior/Exterior Trim
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Rattle Noise From Lower Console - Retaining Pin (MT 0697-01)
- Squeak/Rattle From Dash Defroster Area (MT 0597-03)
- Front Console Service Parts (S054/96)
- PREDELIVERY INSPECTI On Supplemental Instructions (AD005/96)
Interior/Illumination Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Modified Interior Dome Light Bulb Application (MT 0897-05)
Lubrication System
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
Manual Steering
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Manual Trans
- MTX Overhaul Information - Reverse Gate Spring Care (J003/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Piston Standardization Left & Right Bank REPLACEMANT (CAT. 01, NO. 015/99)
- Camshaft Friction Gear Noise - Modified REPL Process (B005/98)
- Clunk Noise/Vibration During ACCEL. On Left Turns (CAT. M, NO. 002/97)
- 2.0L Eng Revised Alternator Adjustment Bracket (MT 1197-07)
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
- Supporter & Bracket Of HIGHT Tension Leads (G004/97)
- Right CYL. Head/Cover & Timing Belt Cover Change (CAT. B, NO. 005/97)
- Tapping Noise When Engine Is Cold (B001/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Mechanical - Hydraulic
- Brake Drum/Rotor Resurfacing Machinery Selection (MT 0897-06)
- Brake Rotor Machining And Replacement Criteria (CAT. P, NO. 001/96)
- Brake Judder Repair ACCU Industries National Account (CAT. ST, NO, 003/94)
Mirrors
- Water Leak From The Door Mirror Area (MT 0297-02)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Power Door Lock Knob Malfunction (T022/96)
Paint & Coatings
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
- Environmental Fallout Repair Procedure (MT 0797-07)
- Trunk Water Leak - Seam Sealer Inspection (MT 0397-09)
Procedures
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
Rear Suspension
- Stabilizer Bar Bushing Replacement Procedure (R001/97)
- Suspension Rattle - Sway Bar Control Link Socket (MT 0397-06)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Restraints Control Systems
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- 4 CYL: Mil Illumination & DTC PO400 Or P1195 Stored (F025/97)
- Lack Of Power/Rough Idle - Exhaust/Injector/EGR Info (F026/97)
- 6 CYL: Mil Illumination & DTC PO400 Or P1195 Stored (F022/97)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- Data Link Connector Circuit Changes (MT 0597-05)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Seats
- Seat Belt Extenders Description/Ordering Info (S005/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Seat Belt Extender Description/Ordering Info (CAT. S, NO. 032/96)
- Power Door Lock Knob Malfunction (T022/96)
Starter
- All Models Except B-Series And NAVAJO - Dead Battery (Inspecting For Back-Up Current) (CAT. G, NO. 001/98)
- OBD-II Procedure After Battery Charge/REPL-Pcm/REPL (MT 0797-09)
- Maintenance Free Battery-Revised Diag. & Charging (G001/97)
Steering Column
- Steering Wheel Slightly Off Center (CAT. N, NO. 001/98)
- Tilt Steering Wheel Adjustment (MT 0297-01)
- Steering Wheel Slightly Off Center (CAT. N, NO. 001/96)
Steering Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC P0550 Power Steering Switch Circuit (MT 1197-09)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- New Pcm - Includes DTC For Power Steer Press. Switch (MT 0397-07)
Steering Gear
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
Sun Roof/T-Top/Convertible Top
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Rattle Noise From Sunroof (MT 0697-02)
- PREDELIVERY INSPECTI On Supplemental Instructions (AD005/96)
Suspension Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC P0550 Power Steering Switch Circuit (MT 1197-09)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- New Pcm - Includes DTC For Power Steer Press. Switch (MT 0397-07)
System
- "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
- Shipment Of MAZDA World Wide Diagnostic Tool During October 2000 (00-006/00)
- Year 2000 Compliance (01-018/99)
- Mil Illumination DTC P1407 - Reprogram Pcm (F015/98)
- Mil Illuminated W/DTC P0421 - Pcm Reprogram/Catalyst (F005/98)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
- 4 CYL: Mil Illumination & DTC PO400 Or P1195 Stored (F025/97)
- Lack Of Power/Rough Idle - Exhaust/Injector/EGR Info (F026/97)
- Check Engine Light DTC P0505 (MT 1197-08)
- Spark Plug Wire Resistance Specifications (G006/97)
- 6 CYL: Mil Illumination & DTC PO400 Or P1195 Stored (F022/97)
- Check Spark Plug Wire Resistance (MT 1097-04)
- Camshaft Friction Gear Noise - Friction Gear Spring (CAT. B, NO. 007/95)
- Supporter & Bracket Of HIGHT Tension Leads (G004/97)
- OBD-II Procedure After Battery Charge/REPL-Pcm/REPL (MT 0797-09)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- Data Link Connector Circuit Changes (MT 0597-05)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- V-6 DTC P0441 - Pinched Purge Solenoid Vacuum Hose (MT 0597-01)
- New Pcm - Includes DTC For Power Steer Press. Switch (MT 0397-07)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Transmission Control Systems
- INADVERTANT Disabling Of Brake Shift Interlock (04-005/02)
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
- Data Link Connector Circuit Changes (MT 0597-05)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- Wheel Balance Tips For Higher Precision Results (MT 0897-08)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
Window Motors & Regulators
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Residue On Glass (MT 0797-02)
- Windshield Fog Or Film (MT 0397-04)
- PREDELIVERY INSPECTI On Supplemental Instructions (AD005/96)
- Power Door Lock Knob Malfunction (T022/96)
Wiper/Washer Systems
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Lack Of Power/Rough Idle - Exhaust/Injector/EGR Info (F026/97)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Data Link Connector Circuit Changes (MT 0597-05)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)