Technical Service Bulletins

A/C Compressor
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- A/C Malfunction Due To P/S Pump Pressure Switch (CAT. U, NO. 006/97)
- A/C O-Ring Replacement (U005/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
Accessories & Equipment
- All Models - WDS Ms-Can 5-Meter Cable (ST-003/04)
- Availability Of Non-Required Tools - April 2007 (ST-003/07)
- WDS PTU Battery Warranty And Order Information (ST-001/05)
- Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
- All Models - WDS Ms-Can 16-Pin Cable Shipment (ST001/03)
Accessories Control Systems
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
Air Bag, SRS
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Non Genuine Accessories Affect On Air Bag Operation (CAT. T, NO. 023/96)
Anti-Lock Brakes
- Abs Light On/Models With 4 Wheel Abs (MT 0997-04)
Anti-Theft Systems
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
Automatic Trans
- Automatic Transmission/Transaxle Cooler And Lines Flushing Procedure (05-012/10)
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Auxiliary Emission Control Systems
- Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
- Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
- Year 2000 Compliance (01-018/99)
- Mil Ill UMINATED W/DTC P0300 - ECM/Crank Sensor/Plate (F006/98)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Mil Illuminated W/DTC P0470 - EGR Service Kit (F007/98)
- OBD-II Procedure After Battery Charge/REPL-Pcm/REPL (MT 0797-09)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Axle Shafts
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Blowers, Superchargers & Turbochargers
- Mil Ill UMINATED W/DTC P0300 - ECM/Crank Sensor/Plate (F006/98)
Body Electrical
- "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
Body Interior
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
Brakes Control Systems
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Abs Light On/Models With 4 Wheel Abs (MT 0997-04)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Charging Systems
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
- Mil Ill UMINATED W/DTC P0300 - ECM/Crank Sensor/Plate (F006/98)
Clutch
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Cooling System (Mechanical)
- Reconditioned Anti-Freeze (CAT. E, NO. 002/96)
Differentials & Drive Axles
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Driveshaft & Universal Joints
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Engine Control Systems
- "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
- Ids / PDS Update For MAZDA Modular Diagnostic System (M-MDS) (01-014/06)
- Year 2000 Compliance (01-018/99)
- Mil Ill UMINATED W/DTC P0300 - ECM/Crank Sensor/Plate (F006/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
- Mil Illuminated W/DTC P0470 - EGR Service Kit (F007/98)
- OBD-II Procedure After Battery Charge/REPL-Pcm/REPL (MT 0797-09)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Entertainment Systems
- Radio Unlocking Codes (MT-002/22)
- Multiple Models - Cd Module Malfunctions (CAT. 09, NO. 010/03)
- Cigarette Lighter Does Not Work Properly (09-007/00)
- Power Antenna Relay Inspection Procedure (T004/98)
- ETR Operation - Cassette Changes Before Tape Ends (MT 0297-05)
- Headrest Speakers Cut Out At High Volume (T010/97)
Exhaust
- Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
- Tail Pipe Breakage - New Main Silencer (F015/97)
Exterior Body Panels
- Service Bumper Specification Change (09-022/09)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Thumping Or Popping Noise From Fuel Tank Area (S017/97)
- Side Sill Paint Damage Due To Scuff Plate (S011/96)
Exterior Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
Frames, Subframes & Crossmembers
- Service Bumper Specification Change (09-022/09)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
- Side Sill Paint Damage Due To Scuff Plate (S011/96)
Front Suspension
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Fuel System
- Sulfur Smell From Exhaust System (CAT. 01, NO. 029/02)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- Thumping Or Popping Noise From Fuel Tank Area (S017/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- CALIFORNIA Reformulated Gasoline (Effect On Vehicle Performance And Fuel Economy) (CAT. F, NO. 014/96)
Fuses & Circuit Breakers
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Speedometer Needle Fluctuates - Cable Bound By Wraps (MT 0497-04)
- Checking Points For Dead Battery - Dark Current Draw (G003/96)
Gauges & Instrument Panels
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
- Speedometer Needle Fluctuates - Cable Bound By Wraps (MT 0497-04)
Headlights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
HVAC Control Systems
- Use Of A/C Tracer Dye Service Info (CAT. U, NO. 008/97)
- Heater Hose/Core Connector Dealer Hint (MT 0597-09)
- A/C O-Ring Replacement (U005/97)
- Use Of R-12 Refrigerant Substitutes (CAT. U, NO. 009/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Use Of A/C Tracer Dye (U-008/97)
Identification
- Speedometer Replacement Procedure (CAT. AD, NO. 003/97)
Ignition System
- Spark Plug Wire Resistance Specifications (G006/97)
- Check Spark Plug Wire Resistance (MT 1097-04)
- Spark Plug Installation / Removal Caution (01-036/06)
Interior/Exterior Trim
- Proper Usage Of Driver's Floor Mat (09-027/14)
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- PREDELIVERY INSPECTI On Supplemental Instructions (AD005/96)
- Side Sill Paint Damage Due To Scuff Plate (S011/96)
Interior/Illumination Lights
- Room Lamp Does Not Illuminate - New Dome Light Bulb (CAT. T, NO. 016/97)
- Modified Interior Dome Light Bulb Application (MT 0897-05)
Manual Steering
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Manual Trans
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Special Service Tool Shipment - October 2011 (ST-002/11)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Mechanical - Hydraulic
- Brake Drum/Rotor Resurfacing Machinery Selection (MT 0897-06)
- Brake Rotor Machining And Replacement Criteria (CAT. P, NO. 001/96)
- Brake Judder Repair ACCU Industries National Account (CAT. ST, NO, 003/94)
Mirrors
- Power Antenna Relay Inspection Procedure (T004/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
Paint & Coatings
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Paint Damage By Trunk Rubber Cushion (S007/98)
- Pre-Painting Preparation For Front & Rear Bumpers (CAT. S, NO. 020/97)
- Environmental Fallout Repair Procedure (MT 0797-07)
Procedures
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
Rear Suspension
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Restraints Control Systems
- Parts Replacement After Airbag Deployment (CAT. T, NO. 007/97)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Seats
- Seat Belt Extenders Description/Ordering Info (S005/98)
- Power Antenna Relay Inspection Procedure (T004/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Seat Belt Extender Description/Ordering Info (CAT. S, NO. 032/96)
Starter
- 12 Volt Battery Test Procedure Requirements For Warranty (Using The COA-8000PM) (01-054/10)
- Battery Maintenance (01-029/06)
- Battery Test Procedure Requirements Using The Gr8-1291 (01-054-10)
- Special Service Equipment Distribution - November 2010 (ST-002/10)
- All Models Except B-Series And NAVAJO - Dead Battery (Inspecting For Back-Up Current) (CAT. G, NO. 001/98)
- OBD-II Procedure After Battery Charge/REPL-Pcm/REPL (MT 0797-09)
- Maintenance Free Battery-Revised Diag. & Charging (G001/97)
- Battery Charging Cautions (CAT. 01, NO. 012/99)
Steering Column
- Steering Wheel Slightly Off Center (CAT. N, NO. 001/98)
- Steering Wheel Slightly Off Center (CAT. N, NO. 001/96)
Steering Control Systems
- A/C Inoperative / Mil "On" DTC P0550 (CAT. 01, NO. 011/99)
- Year 2000 Compliance (01-018/99)
- A/C Inoperative - P/S Press Switch Terminal CORODED (07-001/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC P0550 Power Steering Switch Circuit (MT 1197-09)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- A/C Malfunction Due To P/S Pump Pressure Switch (CAT. U, NO. 006/97)
Steering Gear
- Checking Procedure For Power Steering Boot Leakage (CAT. N, NO. 004/97)
Sun Roof/T-Top/Convertible Top
- Damage - Iron Particle/Industrial Fallout/Acid Rain (CAT. 09, NO. 012/99)
- Short Carpet At Front Side Trim - Modify Carpet Pad (S017/98)
- Soft Top Boot Flaps Loose At High Speed (S016/97)
- PREDELIVERY INSPECTI On Supplemental Instructions (AD005/96)
Suspension Control Systems
- Year 2000 Compliance (01-018/99)
- A/C Inoperative - P/S Press Switch Terminal CORODED (07-001/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- DTC P0550 Power Steering Switch Circuit (MT 1197-09)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- A/C Malfunction Due To P/S Pump Pressure Switch (CAT. U, NO. 006/97)
System
- "Ten" Terminal On 17-Pin Diagnostic Connector (5809)
- Evaporative Emissions Cap And Receiver Adapters (ST-002/04)
- Shipment Of MAZDA World Wide Diagnostic Tool During October 2000 (00-006/00)
- Year 2000 Compliance (01-018/99)
- Mil Ill UMINATED W/DTC P0300 - ECM/Crank Sensor/Plate (F006/98)
- TAS (Throttle Adjustment Screw) Location/Adjustment (F014/98)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
- Mil Illuminated W/DTC P0470 - EGR Service Kit (F007/98)
- Spark Plug Wire Resistance Specifications (G006/97)
- Check Spark Plug Wire Resistance (MT 1097-04)
- OBD-II Procedure After Battery Charge/REPL-Pcm/REPL (MT 0797-09)
- Oil Pressure Switch Leakage -New Oil Pressure Switch (D003/96)
- Low Fuel Sensor Location/Diagnostic Information (MT 0697-07)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Thumping Or Popping Noise From Fuel Tank Area (S017/97)
- Vane Air Flow Meter Connector Handling (CAT. F, NO. 028/96)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- Update Warnings On Ids (Laptop Pc) And PFM (PDS File Manager) For MAZDA Modular Diagnostic System (M-MDS) (01-028/06)
Transmission Control Systems
- Year 2000 Compliance (01-018/99)
- Inspection Procedure For Test Lead Of NGS Tester (CAT. ST, NO. 006/98)
- Shipment Of Special Tools (CAT. ST, NO. 004/98)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
Wheels & Tire System
- Carb Regulation (CALIFORNIA Only) - Mandatory Tire Pressure Check (MT-015/10)
- Vehicle Shakes At High Speed (Q002/97)
- Wheel Balance Tips For Higher Precision Results (MT 0897-08)
- MAZDA Required Tool (MRT) Inventory List (CAT. ST, NO. 004/96)
- MAZDA Wheel Lock Installation - Service Tip (02-001/06)
Window Motors & Regulators
- Short Carpet At Front Side Trim - Modify Carpet Pad (S017/98)
- Power Window Troubleshooting & Repair (S015/98)
- Power Antenna Relay Inspection Procedure (T004/98)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- Soft Top Boot Flaps Loose At High Speed (S016/97)
- Residue On Glass (MT 0797-02)
- Windshield Fog Or Film (MT 0397-04)
- PREDELIVERY INSPECTI On Supplemental Instructions (AD005/96)
Wiper/Washer Systems
- Front Wiper Motor Operation/Inspection (CAT. T, NO. 013/97)
- Washer Fluid Leaking From Nozzle (S044/96 REV.)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Non Factory Accessory Installation Precautions (MT 0897-09)
- DTC Diagnostic Trouble Shooting Tips (MT 0597-07)
- Speedometer Needle Fluctuates - Cable Bound By Wraps (MT 0497-04)