Section 294 (Climate Control System - General Information (Hybrid))
WARNING: This page is about a different car, the 2016 Lincoln MKZ. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Description And Operation
- Climate Control System - 2.0L Duratec - Hybrid (96kW/130PS) - Component Location
- Climate Control System - 2.0L Duratec - Hybrid (96kW/130PS) - Overview
- Climate Control System - 2.0L Duratec - Hybrid (96kW/130PS), Vehicles With: Dual Automatic Temperature Control (DATC) - System Operation and Component Description
- System Operation
- System Diagram
- Network Message Chart
- The Refrigerant Cycle
- Control System Logic
- Controls and Compressor Operation
- Heating and Ventilation
- MyTemp
- PHEV Cabin Coolant Heater System
- Air Handling
- Auto
- Off
- Max Ac
- Panel
- Panel-Floor
- Floor
- Floor-Defrost
- MAX Defrost
- Remote Start - Message Center Set To Auto
- Remote Start - Message Center Set To Last User Settings
- Component Description
- FCIM - Dual Automatic Temperature Control (DATC)
- Exhaust Manifold and Catalytic Converter Assembly with Coolant Passages
- Evaporator Core
- Heater Core
- Heater Core and Evaporator Core Housing
- Blower Motor
- Blower Motor Speed Control
- Air Distribution Door Actuator
- Air Inlet Door Actuator
- Driver Side Temperature Door Actuator
- Passenger Side Temperature Door Actuator
- Evaporator Temperature Sensor
- In-Vehicle Temperature And Humidity Sensor
- Sunload Sensor
- Air Conditioning (A/C) Pressure Transducer
- Internal Heat Exchanger (IHX)
- A/C Electric Compressor
- A/C Condenser
- Receiver Drier
- Thermostatic Expansion Valve (TXV)
- Service Gauge Port Valves
- Refrigerant System Dye
- System Operation
- Diagnosis And Testing
- Climate Control System - 2.0L Duratec - Hybrid (96kW/130PS), Hybrid Electric Vehicle (HEV)
- DTC Charts
- Symptom Chart(s)
- Pinpoint Test(s)
- Pinpoint Test A : P0532, P0533
- Pinpoint Test B : P0562:00
- Pinpoint Test C : U0140:00 - Air Conditioning Control Module (ACCM)
- Pinpoint Test D : Unable To Duplicate The Customer Concern And No Diagnostic Trouble Codes (DTCS) Present
- Pinpoint Test E : The Air Inlet Door Is Inoperative
- Pinpoint Test F : Incorrect/Erratic Direction Of Airflow From Outlets
- Pinpoint Test G : Insufficient, Erratic, Or No Heat
- Pinpoint Test H : The Air Conditioning (A/C) Is Inoperative
- Pinpoint Test I : The Air Conditioning (A/C) Is Always On - Air Conditioning (A/C) Mode Always Commanded On
- Pinpoint Test J : The Temperature Control Is Inoperative Or Does Not Operate Correctly - Driver Side
- Pinpoint Test K : The Temperature Control Is Inoperative Or Does Not Operate Correctly - Passenger Side
- Pinpoint Test L : The Blower Motor Is Inoperative
- Pinpoint Test M : The Blower Motor Does Not Operate Correctly
- Pinpoint Test N : B10B3:11, B10B3:15, B10B4:11, B10B4:15, B10B5:11, B10B5:15, B10B6:11, B10B6:15
- Pinpoint Test O : B105A:12, B105A:14, B1A61:11, B1A61:15, B1A69:11, B1A69:15
- Pinpoint Test P : B1A63:11, B1A63:15, B1A64:11, B1A64:15
- Pinpoint Test Q : B1B71:11, B1B71:15
- Pinpoint Test R : U0293:00
- Pinpoint Test S : C1B14:11, C1B14:12
- Climate Control System - 2.0L Duratec - Hybrid (96kW/130PS), Hybrid Electric Vehicle (HEV)
- General Procedures
- Air Conditioning (A/C) Compressor Leak Detection
- Air Conditioning (A/C) Odor Treatment
- Air Conditioning (A/C) System Flushing
- Air Conditioning (A/C) System Recovery, Evacuation and Charging
- Condenser Core Leak Check
- Electronic Leak Detection
- Evaporator Core Leak Check
- Fluorescent Dye Leak Detection
- Heater Core Leak Check
- Refrigerant Identification Testing
- Refrigerant Oil Adding
- Refrigerant System Tests - 2.0L Duratec - Hybrid (96kW/130PS)
- Removal And Installation
- Air Conditioning (A/C) Compressor Inlet Line - 2.0L Duratec - Hybrid (96kW/130PS)
- Air Conditioning (A/C) Compressor Outlet Line - 2.0L Duratec - Hybrid (96kW/130PS)
- Air Conditioning (A/C) Electric Compressor - 2.0L Duratec - Hybrid (96kW/130PS)
- Air Conditioning (A/C) Pressure Transducer - 2.0L Duratec - Hybrid (96kW/130PS)
- Air Distribution Door Actuator - 2.0L Duratec - Hybrid (96kW/130PS)
- Air Inlet Door Actuator - 2.0L Duratec - Hybrid (96kW/130PS)
- Ambient Air Temperature Sensor - 2.0L Duratec - Hybrid (96kW/130PS)
- Blower Motor - 2.0L Duratec - Hybrid (96kW/130PS)
- Blower Motor Speed Control - 2.0L Duratec - Hybrid (96kW/130PS)
- Cabin Air Filter - 2.0L Duratec - Hybrid (96kW/130PS)
- Center Registers - 2.0L Duratec - Hybrid (96kW/130PS)
- Climate Control Housing - 2.0L Duratec - Hybrid (96kW/130PS)
- Condenser - 2.0L Duratec - Hybrid (96kW/130PS)
- Condenser Outlet Line - 2.0L Duratec - Hybrid (96kW/130PS)
- Driver Side Footwell Air Discharge Temperature Sensor - 2.0L Duratec - Hybrid (96kW/130PS)
- Driver Side Register - 2.0L Duratec - Hybrid (96kW/130PS)
- Driver Side Register Air Discharge Temperature Sensor - 2.0L Duratec - Hybrid (96kW/130PS)
- Driver Side Temperature Door Actuator - 2.0L Duratec - Hybrid (96kW/130PS)
- Evaporator - 2.0L Duratec - Hybrid (96kW/130PS)
- Evaporator Inlet and Outlet Manifold - 2.0L Duratec - Hybrid (96kW/130PS)
- Evaporator Temperature Sensor - 2.0L Duratec - Hybrid (96kW/130PS)
- Heater Core - 2.0L Duratec - Hybrid (96kW/130PS)
- Heating, Ventilation and Air Conditioning (HVAC) Control Module - 2.0L Duratec - Hybrid (96kW/130PS)
- In-Vehicle Temperature and Humidity Sensor - 2.0L Duratec - Hybrid (96kW/130PS)
- Passenger Side Footwell Air Discharge Temperature Sensor - 2.0L Duratec - Hybrid (96kW/130PS)
- Passenger Side Register - 2.0L Duratec - Hybrid (96kW/130PS)
- Passenger Side Register Air Discharge Temperature Sensor - 2.0L Duratec - Hybrid (96kW/130PS)
- Passenger Side Temperature Door Actuator - 2.0L Duratec - Hybrid (96kW/130PS)
- Receiver Drier Element - 2.0L Duratec - Hybrid (96kW/130PS)
- Sunload Sensor - 2.0L Duratec - Hybrid (96kW/130PS)
- Thermostatic Expansion Valve - 2.0L Duratec - Hybrid (96kW/130PS)