Technical Service Bulletins
- A/C Compressor
- Climate Control - A/C Service Tech Tips (02-20-8)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- 4.6L - Squeal From FEAD At Temps Below -7 Degrees C (96-14-8)
- R-134A Tracer Dye Installed In The A/C System - Tip (95-21-4)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- Release Of R-134A Fluorescent Tracer Dye (94-26-6)
- Refrigerant Oil Visible At Spring Lock Couplers (94-20-6)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- Accessories Control Systems
- Electrical - Revised Mechanical Hood Lamp Switch To Replace Old Style Mercury Hood Lamp Switch (01-21-6)
- Fuel Gauge Does Not Read Full And/Or Empty (95-17-6)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- Inconsistent/Inaccurate Fuel Reading:New Card/Sender (93-26-10)
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Remote Keyless Entry (RKE) - Service Tips (03-18-1)
- Interior Trim - Door Trim Panel Replacement (99-8-15)
- Remote Keyless Entry Diagnostic Service Tips (97-24-13)
- Anti-Theft Protection System - Recap Of TSB'S - Tips (94-25-5)
- Doors Stick Or Difficult To Open (94-19-2)
- Remote Keyless Entry System Service Tips (94-4-3)
- Smears On Door Glass When Rolled Up:New Weatherstrip (94-1-1)
- Remote Keyless Entry System - Service Information (93-4-3)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- 4R70W - New Service Part - Number 5 Needle Bearing And Race Kit (03-26-1)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- 4R70W - Delayed Or No 2-3 Upshift - FQR Trans. Only (99-9-6)
- AODE/4R70W - Forward Clutch Service Kit (98-10-8)
- AODE/4R70W - Shudder On Acceleration In 3RD/4TH Gear (98-8-7)
- Transmission Fluid Usage Chart (98-8-8)
- AODE/4R70W - Main Control & Case Usage For Prior Mod (97-16-7)
- 4R70W/AODE - Erratic Or Prolonged 1-2 Shift (97-11-11)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- AODE/4R70W - Shudder Under Light Acceleration (96-25-17)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- AODE/4R70W - Shift And/Or Engagement Concerns - DTC (95-3-13)
- AODE/4R7OW Shudder Or Vibration (95-23-4)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- AODE/4R70W Reusable Oil Pan Gasket (95-8-4)
- AODE/4R70W Loss Of Torque During/After 3-4 Upshift (95-5-15)
- AODE/4R70W Delayed Or No Forward/Reverse Engagement (94-26-9)
- AODE/4R70W Eng. Rpm High On 1-2 Upshift/No 2ND Gear (94-6-6)
- Auxiliary Emission Control Systems
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Exhaust - Heated Oxygen Sensor Application Chart (94-16-9)
- Revised Ignition Control Module (ICM) Connector (94-7-8)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Blowers, Superchargers & Turbochargers
- Body Interior
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Air Conditioning - EATC Service Tips (97-8-8)
- EATC/SATC Display Flickers With AUTOLAMP Set On Low (96-14-5)
- Fuel Gauge Does Not Read Full And/Or Empty (95-17-6)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- Cold Engine Lockout/Thermal Blower Lockout Operation (94-11-5)
- Inconsistent/Inaccurate Fuel Reading:New Card/Sender (93-26-10)
- EATC Blower Speed Control Enhancement And Changes (93-23-12)
- Water Drips From Floor Duct - Stratified Air Flow (93-21-4)
- Brakes Control Systems
- Charging Systems
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Engine Cooling Fan - Module Component Service Info. (97-10-4)
- Use Of Recycled Coolant - Service Tip (95-18-2)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Cooling System - Radiator - New Manufacturing PROCES (95-2-4)
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Fuel Pressure Specifications Revised - Manual Update (94-24B-1)
- Revised Ignition Control Module (ICM) Connector (94-7-8)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Sheet Molding Composite - Cosmetic Damage Repair (97-17-1)
- WINDNOISE Emanating From Moonroof (97-12-1)
- Fuel Gauge Does Not Read Full And/Or Empty (95-17-6)
- Service Part - Return Of OSSOLETE Fuel Tank Assembly (95-1-4)
- Doors Stick Or Difficult To Open (94-19-2)
- Front Seat Loose/Clunks When Accelerating Or Braking (94-18-12)
- Fuel Spit-Back When Filling Tank: New Filler Pipe (93-26-7)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Front Suspension Height Sensor Mount Replacement (97-5-4)
- Growl Noise From Steering Column When Turning (96-12-2)
- Hum Noise From Air Suspension Compressor (94-21-2)
- Steering Drift/Pull To Right: Vibration Above 45 Mph (94-4-2)
- Power Steering Noise: Purging Air From System (93-7-3)
- Steering Wheel Grunt Noise After Full Lock Position (93-22-3)
- Fuel System
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Accelerator Cable Diagnostic Procedure (95-1-2)
- Fuel Pressure Specifications Revised - Manual Update (94-24B-1)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- WINDNOISE Emanating From Moonroof (97-12-1)
- Fuel Gauge Does Not Read Full And/Or Empty (95-17-6)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- Front Seat Loose/Clunks When Accelerating Or Braking (94-18-12)
- Inconsistent/Inaccurate Fuel Reading:New Card/Sender (93-26-10)
- Heated Glass/Defoggers
- HVAC Control Systems
- Climate Control - A/C Service Tech Tips (02-20-8)
- Climate Control - Repeat Heater Core Failure (01-15-6)
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- Blower Motor Chirp Or Squeak At Low Speeds (97-6-10)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- EATC/SATC Display Flickers With AUTOLAMP Set On Low (96-14-5)
- R-134A Tracer Dye Installed In The A/C System - Tip (95-21-4)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C Evaporator Core On-Vehicle Leak Test Procedure (95-13-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- Release Of R-134A Fluorescent Tracer Dye (94-26-6)
- Refrigerant Oil Visible At Spring Lock Couplers (94-20-6)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- Air Conditioning Evaporator Core & Case Application (94-11-4)
- Water Drips From Floor Duct - Stratified Air Flow (93-21-4)
- Ignition System
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Manual Steering
- Steering Wheel Movement/Nibble Felt On Rough Roads (98-8-3)
- 4.6L - Squeal From FEAD At Temps Below -7 Degrees C (96-14-8)
- Growl Noise From Steering Column When Turning (96-12-2)
- Revised Torque Requirement For New Tie Rods (96-1-1)
- Hum Noise From Air Suspension Compressor (94-21-2)
- Steering Drift/Pull To Right: Vibration Above 45 Mph (94-4-2)
- Power Steering Noise: Purging Air From System (93-7-3)
- Steering Wheel Grunt Noise After Full Lock Position (93-22-3)
- Mechanical
- Engine - Straightedge Procedure For Checking Cylinder Head & Block Flatness (02-21-13)
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Fuel Economy - Customer Expectations (99-26-9)
- 4.6L - Squeal From FEAD At Temps Below -7 Degrees C (96-14-8)
- Excessive Noise From Timing Chain TENSIONER (95-13-3)
- Revised Ignition Control Module Connector Clip (95-10-2)
- 4.6L Metallic Rapping During Cold Engine Startup (95-7-3)
- Mechanical - Hydraulic
- Brakes - Elimination Of Sanding Rotors & Drums (98-5A-11)
- Brakes - Hub-Mount Brake Rotor Machining Equipment (98-5A-5)
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brake & Rotor Service Tips (97-19-4)
- Brakes - Roughness Concern During Brake Application (95-6-2)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Guidelines For Brake Vibration Repair & Replacement (99-19-4)
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Abrasion On Lower Body Side Paint &/Or Rocker Panel (96-5-2)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Smears On Door Glass When Rolled Up:New Weatherstrip (94-1-1)
- Fuel Spit-Back When Filling Tank: New Filler Pipe (93-26-7)
- Regular Production Option Paint Codes (93-24-4)
- Passive Restraints
- Rear Suspension
- Seats
- Leather Seat Cleaning Procedure - Service Tip (98-17-1)
- WINDNOISE Emanating From Moonroof (97-12-1)
- Front Seat - Increased Rearward Seat Travel (95-15-2)
- Front Seat Track Covers Come Off (94-20-1)
- Front Seat Loose/Clunks When Accelerating Or Braking (94-18-12)
- Driver's Seat Sensor Switch Causes Doors To Lock (94-10-2)
- Starter
- Steering Column
- Steering Gear
- Steering Wheel Movement/Nibble Felt On Rough Roads (98-8-3)
- Growl Noise From Steering Column When Turning (96-12-2)
- Revised Torque Requirement For New Tie Rods (96-1-1)
- Hum Noise From Air Suspension Compressor (94-21-2)
- Power Steering Noise: Purging Air From System (93-7-3)
- Steering Wheel Grunt Noise After Full Lock Position (93-22-3)
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- WINDNOISE Emanating From Moonroof (97-12-1)
- Doors Stick Or Difficult To Open (94-19-2)
- Front Seat Loose/Clunks When Accelerating Or Braking (94-18-12)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Smears On Door Glass When Rolled Up:New Weatherstrip (94-1-1)
- Fuel Spit-Back When Filling Tank: New Filler Pipe (93-26-7)
- Suspension Control Systems
- System
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- Fuel Economy - Customer Expectations (99-26-9)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Low Reserve Battery Capacity At Low Temperatures (95-16-7)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Accelerator Cable Diagnostic Procedure (95-1-2)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Fuel Pressure Specifications Revised - Manual Update (94-24B-1)
- Exhaust - Heated Oxygen Sensor Application Chart (94-16-9)
- Revised Ignition Control Module (ICM) Connector (94-7-8)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Transmission Control Systems
- Inadvertent Disabling Of Brake Shift Interlock (99-13-9)
- 4R70W - Delayed Or No 2-3 Upshift - FQR Trans. Only (99-9-6)
- AODE/4R70W - Shudder On Acceleration In 3RD/4TH Gear (98-8-7)
- AODE/4R70W - Shudder Under Light Acceleration (96-25-17)
- AODE/4R70W - Shift And/Or Engagement Concerns - DTC (95-3-13)
- AODE/4R7OW Shudder Or Vibration (95-23-4)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Alignment
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Growl Noise From Steering Column When Turning (96-12-2)
- Center Wheel Ornament Falls Off - Installation Tips (94-26-1)
- Hum Noise From Air Suspension Compressor (94-21-2)
- Steering Drift/Pull To Right: Vibration Above 45 Mph (94-4-2)
- Power Steering Noise: Purging Air From System (93-7-3)
- Steering Wheel Grunt Noise After Full Lock Position (93-22-3)
- Window Motors & Regulators
- WINDNOISE Emanating From Moonroof (97-12-1)
- Windshield And Interior Glass - Fog/Film (96-22-1)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Doors Stick Or Difficult To Open (94-19-2)
- Front Seat Loose/Clunks When Accelerating Or Braking (94-18-12)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Driver's Seat Sensor Switch Causes Doors To Lock (94-10-2)
- Smears On Door Glass When Rolled Up:New Weatherstrip (94-1-1)
- Fuel Spit-Back When Filling Tank: New Filler Pipe (93-26-7)
- "Iridescence" Or "Mottling" In Tempered Glass (93-21-1)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Fuel Gauge Does Not Read Full And/Or Empty (95-17-6)
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Revised Ignition Control Module Connector Clip (95-10-2)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- Revised Ignition Control Module (ICM) Connector (94-7-8)
- Inconsistent/Inaccurate Fuel Reading:New Card/Sender (93-26-10)