Technical Service Bulletins: Other Variant
WARNING: This page is about the Continental Executive, AX4S, which is a different variant/trim than selected.
- A/C Compressor
- Climate Control - A/C Service Tech Tips (02-20-8)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-134A Tracer Dye Installed In The A/C System - Tip (95-21-4)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- Release Of R-134A Fluorescent Tracer Dye (94-26-6)
- Refrigerant Oil Visible At Spring Lock Couplers (94-20-6)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- Inoperative Blower Motor:Cold Engine Lockout Switch (94-2-13)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Accessories Control Systems
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- New Transmission Cooler Flusher - Service Tips (03-14-8)
- Transmission Flush/Fill Tool Available From Rotunda (99-15-2)
- Ax4S/Ax4N - Correct Fluid Usage (98-3-8)
- Flushing Transmission Oil Cooler & Lines (98-13-12)
- Transmission Fluid Usage Chart (98-8-8)
- Ax4S/Ax4N - Harsh Engage/Shift - DTC 628/P0741/P1744 (97-6-13)
- Revised "GROB" Spline Drive Joint (96-5-11)
- Torque Converter Replacement - Cooling SYS. Cleaning (96-26-12)
- Torque Converter Leak Test Procedure - New Tool (96-24-9)
- Ax4S - ELASTOMERIC Gasket For Main Control & Pan (96-17-14)
- Ax4S/Ax4N Transaxle Noises/Driveline Noises (96-8-7)
- Ax4N - Bonded Main Control Separator Plate Gaskets (95-25-8)
- AXODE/Ax4S - Revised Clutch Clearances (95-17-7)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- Ax4N - Revised Torque Converter Identification Codes (95-15-7)
- Ax4S Front Turbine Shaft O-Ring Seal Change (95-14-8)
- Ax4S - Rear Sun Gear & Drum Bearing - Service Tip (95-5-16)
- Ax4S & Ax4N - Low Fluid Level Improperly Sets Codes (94-26-7)
- Ax4S Torque Converter Hub Splines Changed (94-4-8)
- Ax4S Transaxle Exchange Program - Expanded Coverage (94-24-6)
- AXOD/AXODE Engagement Probs - New Fwd Clutch Piston (94-24-7)
- Ax4S/AXOD Transmission New Lube Tubes Needed For Service (94-21-5)
- AXOD-E/Ax4S Revised Rear Lube Tube Retention Bracket (94-20-9)
- Rear Planetary Support RETIANING Ring Orientation (94-20-8)
- AXOD/AXODE/Ax4S Torque Converter Hub Seal Leak (94-6-7)
- Ax4S Transaxle "Do Not Service Tag":Instructions (94-1-7)
- Auxiliary Emission Control Systems
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Exhaust - Heated Oxygen Sensor Application Chart (94-16-9)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Blowers, Superchargers & Turbochargers
- Body Interior
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Air Conditioning - EATC Service Tips (97-8-8)
- Electrical Diode Identification And Replacements (96-24-6)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- Cold Engine Lockout/Thermal Blower Lockout Operation (94-11-5)
- EATC Blower Speed Control Enhancement And Changes (93-23-12)
- Brakes Control Systems
- Communication Devices
- Cooling System (Mechanical)
- Ford Motor Company Position On Engine Coolant Made From Propylene Glycol (96-16-4)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 3.8L - Overheating/Coolant Loss - Revised Head Bolts (98-4-9)
- Engine Cooling Fan - Module Component Service Info. (97-10-4)
- Use Of Recycled Engine Coolant - Service Tip (95-18-2)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- 3.8L Revised Intake Manifold Bolt Torque Specs (94-10-10)
- Cooling System - Radiator - New Manufacturing PROCES (95-2-4)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Hesitation/Stalling/No Start At High Altitudes/Temps (96-7-5)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Fuel Pressure Specifications Revised - Manual Update (94-24B-1)
- Fuel Starvation Due To Contamination Of Fuel Tank (94-16-3)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Hesitation/Stalling/No Start At High Altitudes/Temps (96-7-5)
- Accelerator Cable Diagnostic Procedure (95-1-2)
- Fuel Pressure Specifications Revised - Manual Update (94-24B-1)
- Fuel Starvation Due To Contamination Of Fuel Tank (94-16-3)
- Service Parts Return Of Obsolete Fuel Tanks (94-11-9)
- Obsolete Fuel Pressure RGULATOR: Part Return Info. (94-1-5)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Heated Glass/Defoggers
- HVAC Control Systems
- Climate Control - A/C Service Tech Tips (02-20-8)
- Climate Control - Repeat Heater Core Failure (01-15-6)
- A/C Musty & Mildew Type Odors - New A/C DISODORIZER (98-2-7)
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Identification Of Non-Ford Approved Refrigerants (99-19-6)
- 3.8L - Overheating/Coolant Loss - Revised Head Bolts (98-4-9)
- Blower Motor Chirp Or Squeak At Low Speeds (97-6-10)
- On-Vehicle Pressure Test Required For Warranty Claim (97-19-11)
- A/C Refrigerant Oil Refill Capacity Chart (97-15-5)
- Air Conditioning - O-Ring Availability/Applications (96-20-7)
- New Thicker O-Rings For Spring Lock Fittings (96-20-8)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C System Service - List Of Bulletins To Reference (96-15-6)
- R-134A Tracer Dye Installed In The A/C System - Tip (95-21-4)
- Ford Approved Flushing Procedures For A/C System (95-8-1)
- A/C Evaporator Core On-Vehicle Leak Test Procedure (95-13-1)
- Air Conditioning Adding Refrigerant Oil Service Tip (95-5-12)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- Release Of R-134A Fluorescent Tracer Dye (94-26-6)
- Refrigerant Oil Visible At Spring Lock Couplers (94-20-6)
- Air Conditioning FS-10 & FX-15 Compressors (94-15-6)
- Evaporator Core Replacement Procedure (94-8-8)
- Inoperative Blower Motor:Cold Engine Lockout Switch (94-2-13)
- Manifold & Tube Replacement (FX-15):Part Usage Chart (94-2-11)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Ignition Switch/Steering Lock
- Ignition System
- Interior/Exterior Trim
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Manual Steering
- Mechanical
- New Gasket Remover/Cleaner Service Tips For Aluminum Heads & Blocks (02-11-4)
- Machining Of Aluminum Cylinder Heads Or Blocks - Warranty Information (02-2-3)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- Engine Oil - Recommended Applications For Sae 5W-20 And Sae 5W-30 Motor Oils (02-1-9)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 3.8L - Overheating/Coolant Loss - Revised Head Bolts (98-4-9)
- Fuel Economy - Customer Expectations (99-26-9)
- 3.8L Low Pitched Squeak/Chirp/Knock From Rocker Arms (95-24-3)
- 3.8L Rocker Arm Low Pitched Squeak Chirp Or Knock (94-2-16)
- 3.8L Revised Intake Manifold Bolt Torque Specs (94-10-10)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- Mechanical - Hydraulic
- Brake Pedal Noise/Vibration Or Slip/Stick Condition (98-5A-7)
- Brakes - Elimination Of Sanding Rotors & Drums (98-5A-11)
- Brakes - Hub-Mount Brake Rotor Machining Equipment (98-5A-5)
- Silicone Brake Caliper Grease Requirement (98-5A-13)
- Squeal From Rear Disc Brakes (98-5A-20)
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brake & Rotor Service Tips (97-19-4)
- Brakes - Roughness Concern During Brake Application (95-6-2)
- On-Vehicle Caliper Mounted Brake Rotor Machining EQP (94-25-2)
- Front Disc Thumping/Clacking While Braking (94-23-5)
- Guidelines For Brake Vibration Repair & Replacement (99-19-4)
- Mirrors
- Various Vehicles - Rear-View Mirror Concern Analysis (23-7092)
- Exterior Mirror Glass And Motor Replacement (98-9-14)
- Rear View Mirror - Preferred Reattachment Method (97-17-2)
- DECKLID Power Pull-Down Inoperative - Bad Switch (96-5-1)
- Front Power Window Groan Noise After Glass Is Up (95-20-3)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Service Parts Return Of Obsolete Power Door Lock (94-15-7)
- Driver's Seat Sensor Switch Causes Doors To Lock (94-10-2)
- Overdrive Unit
- Paint & Coatings
- Passive Restraints
- Rear Suspension
- Seats
- Steering Column
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Whining/Buzzing - Comes Through Speakers Of Entertainment Or Two-Way Radio (02-16-4)
- Engine - Approved Head Gasket Replacement Service Procedures (02-1-4)
- Fuel Pump Whine/Buzz Noise In Radio Speakers (99-12-9)
- Volatility Related DRIVEABILITY Concerns Service Tip (98-26-2)
- Lean DRIVEABILITY Symptoms: MAF Sensor Contamination (98-23-10)
- Fuel Injector - Non Warranty Reimbursement Testing (98-9-9)
- Leaks Oil - New Silicone Gasket & Sealant (98-7-4)
- 3.8L - Overheating/Coolant Loss - Revised Head Bolts (98-4-9)
- Fuel Economy - Customer Expectations (99-26-9)
- Mass Air Flow Sensor Replacement As An Assembly (96-22-5)
- Hesitation/Stalling/No Start At High Altitudes/Temps (96-7-5)
- Accelerator Cable Diagnostic Procedure (95-1-2)
- Throttle Position Sensor Function & Diagnostic Tips (94-26-4)
- Fuel Pressure Specifications Revised - Manual Update (94-24B-1)
- Exhaust - Heated Oxygen Sensor Application Chart (94-16-9)
- Fuel Starvation Due To Contamination Of Fuel Tank (94-16-3)
- Service Parts Return Of Obsolete Fuel Tanks (94-11-9)
- Obsolete Fuel Pressure RGULATOR: Part Return Info. (94-1-5)
- Engine Hesitation/Stall/Low Eng Temp: Diagnosis (93-24-8)
- EXH Gas Oxygen Sensor Silicone Sealer Contamination (93-23-6)
- Exhaust System Noise - Loose Muffler/Catalyst Shield (98-6-4)
- Transmission Control Systems
- Inadvertent Disabling Of Brake Shift Interlock (99-13-9)
- Ax4S/Ax4N - Harsh Engage/Shift - DTC 628/P0741/P1744 (97-6-13)
- Ax4S/Ax4N Transaxle Noises/Driveline Noises (96-8-7)
- Turbine Shaft Speed Sensor Air Gap Measurements (95-3-12)
- Ax4S & Ax4N - Low Fluid Level Improperly Sets Codes (94-26-7)
- AXOD/AXODE Engagement Probs - New Fwd Clutch Piston (94-24-7)
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Alignment
- Wheels & Tire System
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Tire Company Phone Numbers For Customer Assistance (98-5-2)
- Grunt And/Or Groan From Power Steering System (95-19-1)
- Premature Rear Tire Inner Edge Wear: New Camber Kit (95-16-5)
- Hum Noise From Air Suspension Compressor (94-21-2)
- Power Steering Noise: Purging Air From System (93-7-3)
- Window Motors & Regulators
- Windshield And Interior Glass - Fog/Film (96-22-1)
- DECKLID Power Pull-Down Inoperative - Bad Switch (96-5-1)
- Front Power Window Groan Noise After Glass Is Up (95-20-3)
- Urethane Mounted Glass Material Usage Procedure (95-12-1)
- Front Seat Loose/Clunks When Accelerating Or Braking (94-18-12)
- Rear View Mirror Detaches From Windshield (94-17-2)
- Service Parts Return Of Obsolete Power Door Lock (94-15-7)
- Driver's Seat Sensor Switch Causes Doors To Lock (94-10-2)
- "Iridescence" Or "Mottling" In Tempered Glass (93-21-1)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring - Wire Harness Terminal Repair Kit (99-6-3)
- Electrical - New Terminal Grease For Service (98-24-6)
- Electrical Diode Identification And Replacements (96-24-6)
- Erratic Distance-To-Empty & Fuel Gauge Readings (95-2-3)
- 3.0L & 3.8L No Crank - Corrosion At Starter Solenoid (94-26-3)
- Ignition Switch Harness Connector Modification (94-19-7)
- Fuse #8 Blown - 14A488 Wiring Assembly Damaged (93-20-5)