Technical Service Bulletins
- A/C Compressor
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- A/C Clutch Cycling Pressure Switch Diagnosis (87-6-4)
- WARNER A/C Compressor Clutch Assembly R & R (85-4-3)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- A/C Compressor Clutch Assembly I.D. (85-23-3)
- Accessories Control Systems
- Anti-Lock Brakes
- Anti-Theft Systems
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- TFI Anti-Theft Installation - Ignition Coil Caution (85-13-9)
- Anti-Theft INOP - Contaminated Mating Connector (83-18-6)
- Reprogramming Keyless Entry Auto Door Lock Function (83-17-4)
- Automatic Trans
- MERCON ATF Is Being Replaced By MERCON V ATF As A Service Fluid (06-14-4)
- E4OD/4R100 - Fluid In-Line Filter Kit (00-3-8)
- New Rotunda Fluid Changer - Service Tip (95-16-10)
- AOD Transmission No 3-4 Upshift Or Slipping 4TH Gear (93-23-18)
- AOD Thrust Bearing Noise/Crank Wear - Flywheel Bolts (92-18-6)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- AOD Trans 1-2 Slip/3-2 Bump - Clutch Friction Plates (88-7-12)
- New ATF Applications Chart (87-18-14)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- New Synthetic Trans Fluid Information/Application (86-11-17)
- AOD Trans Revised TV Control Pressure Specifications (86-2-16)
- C-5 And AOD A/T Case Bolt R & R - Sealant Application (84-2-7)
- AOD Trans Harsh Downshift - Torsion Return Spring (83-13-9)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Auxiliary Emission Control Systems
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Throttle Position Sensor Screw Removal (89-14-7)
- 5.0L Low Oil Pressure - Oil Screen/Cover/PCV Valve (88-5-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- 5.0L Eng Low Oil Press Light - Oil Pick-Up Tube Clog (88-5-10)
- 5.0L Eng PCV Valve Replacement Interval (87-14-11)
- 5.0L Eng Stall At Idle/Erg Valve Stuck - Carbon Trap (87-1-15)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 5.0L Idle Stall/EGR Valve Stuck - Diagnosis/Repair (86-2-22)
- EFI & CFI Engines - No Start - New TPS (85-14-17)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- Rough Idle/Intermittent Stall - New EVP Sensor (84-21-14-S1)
- 5.0/5.8L Eng Poor Idle/Power/Mpg - THERMACTOR Hoses (84-20-7S)
- 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
- CFI Injection - Stumble - Diode Jumper Harness (82-24-12)
- 5.0L Eng Intermittent Stall/No Start (83-14-15)
- All Models Proper Idle Emissions Testing Procedure (83-6-14)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Interior
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Brakes Control Systems
- Charging Systems
- Clutch
- Cooling System (Mechanical)
- Use Of Recycled Engine Coolant - Service Tip (95-18-2)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- Valve Stem Seal Installation - Nylon Seals Soaking (84-8-11)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Suspension
- Engine Control Systems
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Throttle Position Sensor Screw Removal (89-14-7)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- 5.0L Eng Stall At Idle/Erg Valve Stuck - Carbon Trap (87-1-15)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- EFI & CFI Engines - No Start - New TPS (85-14-17)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- Rough Idle/Intermittent Stall - New EVP Sensor (84-21-14-S1)
- 5.0/5.8L Eng Poor Idle/Power/Mpg - THERMACTOR Hoses (84-20-7S)
- CFI Injection - Stumble - Diode Jumper Harness (82-24-12)
- 5.0L Eng Intermittent Stall/No Start (83-14-15)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- WINDNOISE Diagnosis/Repair (87-20-6)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Body Boom & Vibration - Body Mount Installed Wrong (85-24-15)
- "Fuel Spit-Back" Overfill Of Fuel Tank (84-2-9)
- Inoperative Electric Fuel Pump - Pound Tank W/Mallet (82-3-7-S)
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Filter R & R Caution - Use New Clamps/Hoses (85-6-10)
- Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Temp. Gauge Reads Low - Obsolete Temperature Sender (95-13-2)
- Inaccurate Speedo Readings - Mechanical & Electronic (89-2-7)
- 5.0L Eng Low Oil Press Light - Oil Pick-Up Tube Clog (88-5-10)
- False Lamp Out Warnings - Trailer Lighting Install. (88-2-6)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- New Fuel Gauge Test (83-20-6)
- New In Car Fuel Sender Test Procedure (86-15-5)
- Hazardous Waste Material
- Headlights
- Heated Glass/Defoggers
- HVAC Control Systems
- Filtering Refrigerant After Compressor Replacement (98-12-5)
- Use Of R-12 Refrigerant Substitutes (96-17-10)
- A/C "O" Ring Removal From Spring Lock Coupling (95-2-2)
- R-12 Refrigerant Substitutes - Service Tip (94-14-3)
- Service Parts Return Of Obsolete A/C Discharge Hoses (94-13-9)
- Service Parts Return Of Obsolete A/C Filter Kits (93-22-6)
- Use Of Correct Fluorescent Tracer Dye - Service Tip (93-20-6)
- A/C SLC Refrigerant Fittings Cleaning/New O-Ring Kit (93-6-5)
- Air Conditioning Odor Treatment - Service Procedure (89-25B-1)
- Poor A/C - Clutch Pressure Cycling Switch Diagnosis (89-14-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- A/C Automatic Temp Control Erratic - Diverter Valve (85-9-3)
- Diagnostic Tips For Heater Core Leaks (85-5-2)
- A/C Clutch Pressure Cycling Switch Diagnostic (89-7T-19)
- Excess Air Velocity On Driver - Fabricate Diverter (83-18-7)
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Revised DURA Spark Ignition Module (89-10T-3)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- New Distributor Drive Gear Removal Tool (87-2-18)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- TFI Anti-Theft Installation - Ignition Coil Caution (85-13-9)
- Distributor Stator Assembly R & R (85-4-21)
- 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
- Stalls/Stumbling - Spark Plug Cable Routing (84-4-21)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 2150 Carb - Rough Idle/Flooding - Plugged Air Bleeds (84-3-16-S)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- 5.0L CFI Overheat/High Idle - Caution/Curb Idle SPD (83-25-12)
- Ignition Rotor Alignment (83-3-9)
- 3.8/5.0L Eng Poor PERFORMNCE - Low Fuel Pressure Fix (85-14-11)
- Distributor Centrifugal Advance Not Serviceable (83-10-15)
- Interior/Exterior Trim
- Interior/Illumination Lights
- Lubrication System
- Adhesives & Sealants - Availability & Usage (89-12-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Using Oil-Leak-BLACKLITE (85-5-13)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- Valve Stem Seal Installation - Nylon Seals Soaking (84-8-11)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Manual Steering
- Manual Trans
- Mechanical
- AOD Thrust Bearing Noise/Crank Wear - Flywheel Bolts (92-18-6)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- 5.0L Eng Low Oil Press Light - Oil Pick-Up Tube Clog (88-5-10)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Using Oil-Leak-BLACKLITE (85-5-13)
- Fuel Odor - Liquid/Vapor Leak Diagnosis (85-1-16)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 2150 Carb - Rough Idle/Flooding - Plugged Air Bleeds (84-3-16-S)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- Valve Stem Seal Installation - Nylon Seals Soaking (84-8-11)
- 5.0L CFI Overheat/High Idle - Caution/Curb Idle SPD (83-25-12)
- Carb Eng Poor Cold DRIVEABILITY - Check Air Intake (83-21-4)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- Oil Dipstick Level Markings (83-13-7)
- 3.8/5.0L Eng Poor PERFORMNCE - Low Fuel Pressure Fix (85-14-11)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Mechanical - Hydraulic
- Wheels - Proper Lug Torque Procedures - Service Tip (98-5A-4)
- Brakes - Roughness Concern During Brake Application (95-6-2)
- Engine Oil Health Warning: Skin Contact (86-15-7)
- Brake Rotors Updated Diagnosis/Service (85-9-8)
- Park Brake Won't Stay Applied - New Release Spring (84-14-8)
- Brake Fluid Discoloration Diagnosis (84-12-8)
- Asbestos Brake & Clutch Warnings (83-22-1)
- Mirrors
- Paint & Coatings
- Paint Iron Particle Removal/Acid Rain Neutralization (95-6-1)
- Primed Sheet Metal Prep Procedure & MSDS Information (94-23-4)
- Treating Cosmetic Paint Damage From AIRBORN Material (89-13-3)
- WINDNOISE Diagnosis/Repair (87-20-6)
- Aluminum Wheels W/Coating Service Wear Information (86-9-9)
- Super Seal Compound & Equipment - Concern Diagnosis (83-3-4)
- Passive Restraints
- Rear Suspension
- Schedule
- Seats
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Safety Belt Tongue Cover Parts Availability (88-25-2)
- Safety Belt - Replacement Procedure After Accident (88-15-3)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Seat/Shoulder Belt General Service Information (85-2-4)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Sleeper
- Starter
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- Battery Test Procedure Using Rotunda Battery Tester (83-8-2)
- Steering Column
- Steering Column Switches
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- CALIFORNIA Reformulated Gasoline - Service Tip (96-10-7)
- No Start/Low Battery/Fuel Pump Noise - Pump Relay (90-18-3)
- Hard Start - Revised DURASPARK II Ignition Module (90-1-5)
- Revised DURA Spark Ignition Module (89-10T-3)
- Throttle Position Sensor Screw Removal (89-14-7)
- Adhesives & Sealants - Availability & Usage (89-12-2)
- 5.0L Low Oil Pressure - Oil Screen/Cover/PCV Valve (88-5-10)
- Electronic Modules - Damage From Static Electricity (88-13-3)
- 5.0L Eng Low Oil Press Light - Oil Pick-Up Tube Clog (88-5-10)
- TFI Module/Pip Sensor New EEC-IV Testing (87-21-10)
- 2.0/2.3/2.5/3.0/3.8/5.0/5.8L Eng Short IGN Coil (87-20-18)
- CFI Fuel Injector Contamination - Replace Injector (87-17-5)
- 5.0L Eng PCV Valve Replacement Interval (87-14-11)
- New Distributor Drive Gear Removal Tool (87-2-18)
- 5.0L Eng Stall At Idle/Erg Valve Stuck - Carbon Trap (87-1-15)
- Aftermarket Theft Device - EEC Warnings (86-3-9)
- Fuel Stabilizer During Extended Vehicle Storage (86-13-20)
- Poor Performance - Vacuum System Diagnosis (86-9-11)
- 5.0L Idle Stall/EGR Valve Stuck - Diagnosis/Repair (86-2-22)
- Miss/Stall/Ignition Radio Noise - Ignition Coil (86-2-8)
- TFI Ignition System Resistance Test - Tips/Caution (86-2-19)
- TFI Ignition System Weak/No Spark - Diagnostic Tips (86-2-20)
- EFI & CFI Engines - No Start - New TPS (85-14-17)
- EGR Solenoid/Vacuum Harness Contamination Caution (85-13-5)
- TFI Anti-Theft Installation - Ignition Coil Caution (85-13-9)
- EEC IV - Invalid, Erratic Service Codes (85-12-12)
- Distributor Stator Assembly R & R (85-4-21)
- Rough Idle/Intermittent Stall - New EVP Sensor (84-21-14-S1)
- 4/6/8 CYL No Start/Runs Rough - New Distributor Cap (84-22-3-S)
- Stalls/Stumbling - Spark Plug Cable Routing (84-4-21)
- 5.0/5.8L Eng Poor Idle/Power/Mpg - THERMACTOR Hoses (84-20-7S)
- 5.0L CANADA Models Rough Idle/Poor Mpg - Modify Carb (84-16-21)
- CFI/EFI Eng Fuel Injector O-Ring Part Numbers (84-15-12)
- 2150 Carb - Rough Idle/Flooding - Plugged Air Bleeds (84-3-16-S)
- CFI/EFI Nylon Fuel Tube/Push Connect Fitting Service (84-11-8)
- Valve Stem Seal Installation - Nylon Seals Soaking (84-8-11)
- 5.0L CFI Overheat/High Idle - Caution/Curb Idle SPD (83-25-12)
- Leaks Oil - Current Seals For Rocker Cover & Oil Pan (83-5-7)
- Ignition Rotor Alignment (83-3-9)
- CFI Injection - Stumble - Diode Jumper Harness (82-24-12)
- 3.8/5.0L Eng Poor PERFORMNCE - Low Fuel Pressure Fix (85-14-11)
- 5.0L Eng Intermittent Stall/No Start (83-14-15)
- All Models Proper Idle Emissions Testing Procedure (83-6-14)
- Approved Adhesives & Sealants For Eng/Trans/Steering (89-6T-7)
- Distributor Centrifugal Advance Not Serviceable (83-10-15)
- Throttle Position Sensor POZIDRIVE Mount Screw Info (89-7T-9)
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheels & Tire System
- Window Motors & Regulators
- Power Window Regulator Counterbalance Spring R & R (91-19-5)
- Window Won't Go Down Fully - Regulator DOWNSTOP (88-13-1)
- Power Door Locks Inoperative - Rod Retainer Clip (88-7-1)
- WINDNOISE Diagnosis/Repair (87-20-6)
- Door & Vent Windows - Excessive Efforts To Open (85-4-2)
- Battery Drain - Electrical Component Diagnosis (84-15-9)
- Glass - Mottling In Tempered Glass (83-16-4)
- Front Door Glass Regulator Binds/Groaning Noise (89-11-1)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)