LEMON Manuals: Even more car manuals for everyone
Home >> Lexus >> 2008 >> SC 430 >> Repair and Diagnosis >> External Pages >> Different car >> Section 29 (Instrument Panel) >> Instrument Panel Safety Pad >> Disassembly

Instrument Panel Safety Pad: Disassembly

WARNING: This page is about a different car, the 2007 Lexus SC 430. However, it is still accessible from the selected car via links, so may be relevant.
  1. REMOVE AUTOMATIC LIGHT CONTROL SENSOR 
    1. Disconnect the connector.
    2. Remove the sensor.
      NOTE: Do not pry the cooler thermistor off from the upper position.
      Fig 1: Removing Automatic Light Control Sensor
      G05293644Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  2. REMOVE STEERING COLUMN ASSEMBLY 
    1. Remove the 2 nuts, 2 bolts and steering column.
  3. REMOVE INSTRUMENT PANEL FINISH PLATE 
  4. REMOVE NO. 1 INSTRUMENT PANEL PIN 
    1. Remove the 3 screws and 3 instrument panel pins.
  5. REMOVE NO. 1 DEFROSTER NOZZLE GARNISH 
    1. Detach the 12 claws and remove the nozzle garnish.
  6. REMOVE SIDE NO. 1 DEFROSTER NOZZLE DUCT 
    1. Remove the 2 screws and nozzle duct.
      Fig 2: Identifying Steering Column Bolts And Nuts
      G05293645Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  7. REMOVE SIDE NO. 2 DEFROSTER NOZZLE DUCT 
    1. Remove the 3 screws and nozzle duct.
  8. REMOVE FRONT DEFROSTER NOZZLE 
    1. Remove the 4 screws and nozzle.
  9. REMOVE NO. 1 HEATER TO REGISTER DUCT 
    1. Remove the clip, 2 screws and duct.
  10. REMOVE NO. 3 HEATER TO REGISTER DUCT 
    1. Remove the 2 screws and duct.
  11. REMOVE NO. 2 HEATER TO REGISTER DUCT 
    1. Remove the 3 screws and duct.
  12. DISCONNECT PASSENGER AIRBAG CONNECTOR 
  13. REMOVE INSTRUMENT PANEL REINFORCEMENT 
    1. Disconnect all connectors.
    2. Remove the 4 bolts, screw and reinforcement with wire harness.
  14. REMOVE NO. 1 INSTRUMENT PANEL REGISTER ASSEMBLY 
    1. Remove the 2 screws and register.
  15. REMOVE NO. 2 INSTRUMENT PANEL REGISTER ASSEMBLY 
    1. Remove the 2 screws and register.
  16. REMOVE GLOVE COMPARTMENT DOOR LOCK STRIKER PLATE ASSEMBLY 
    1. Remove the 4 screws and striker plate.
  17. REMOVE NAVIGATION ANTENNA ASSEMBLY (w/ LEXUS Navigation System) 
  18. REMOVE CENTER JUNCTION BLOCK 
  19. REMOVE NETWORK GATEWAY ECU 
  20. REMOVE LIGHT CONTROL RHEOSTAT 
  21. REMOVE NO. 1 METER HOOD RETAINER 
    1. Remove the screw and retainer.
  22. REMOVE FRONT PASSENGER AIRBAG ASSEMBLY 
scientia non olet · About LEMON Manuals