Steering Knuckle: Installation

HINT.

• Use the same procedures for the RH side and LH side.
• The procedures listed below are for the LH side
• A bolt without a torque specification is shown in the standard bolt chart (see SPECIFIED TORQUE FOR STANDARD BOLTS ).

1. INSTALL FRONT AXLE HUB SUB-ASSEMBLY LH 
   1. Install the front axle hub to the steering knuckle with the 4 bolts

      Torque: 65 N*m (663 kgf*cm, 48 ft.*lbf) 

      Fig 1: Locating Front Axle Hub Bolts

      Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
2. INSTALL STEERING KNUCKLE SUB-ASSEMBLY LH 
   1. Install the steering knuckle to the front lower ball joint with the 3 bolts.

      Torque: 113 N*m (1152 kgf*cm, 83 ft.*lbf) 

      Fig 2: Locating Steering Knuckle Bolts

      Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
3. CONNECT FRONT NO. 1 SUSPENSION UPPER ARM ASSEMBLY LH  (See INSTALLATION  )
4. CONNECT FRONT NO. 2 SUSPENSION UPPER ARM ASSEMBLY LH  (See INSTALLATION  )
5. CONNECT TIE ROD ASSEMBLY LH  (See INSTALLATION  )
6. INSTALL FRONT SPEED SENSOR LH  (See INSTALLATION  )
7. CONNECT SKID CONTROL SENSOR WIRE  (See INSTALLATION  )
8. INSTALL FRONT DISC BRAKE DUST COVER LH  (See INSTALLATION  )
9. INSTALL FRONT DISC  (See INSTALLATION )
10. CONNECT FRONT DISC BRAKE CALIPER ASSEMBLY LH  (See INSTALLATION  )
11. INSTALL FRONT AXLE SHAFT NUT LH  (See INSTALLATION )
12. DISCONNECT FRONT DISC BRAKE CALIPER ASSEMBLY LH  (See REMOVAL  )
13. REMOVE FRONT DISC  (See REMOVAL )
14. INSPECT FRONT AXLE HUB BEARING LOOSENESS  (See ON-VEHICLE INSPECTION  )
15. INSPECT FRONT AXLE HUB RUNOUT  (See ON-VEHICLE INSPECTION  )
16. INSTALL FRONT DISC  (See INSTALLATION )
17. CONNECT FRONT DISC BRAKE CALIPER ASSEMBLY LH  (See INSTALLATION  )
18. STAKE FRONT AXLE SHAFT NUT LH  (See INSTALLATION )
19. INSTALL FRONT WHEEL  (See INSTALLATION  )
20. INSPECT AND ADJUST FRONT WHEEL ALIGNMENT 
    1. Inspect and adjust the front wheel alignment (see FRONT WHEEL ALIGNMENT )
21. CHECK ABS SPEED SENSOR SIGNAL 
    1. Check the speed sensor signal (see TEST MODE PROCEDURE ).
22. ADJUST VEHICLE HEIGHT 
    1. Adjust the vehicle height (see ADJUSTMENT ).
23. ADJUST HEADLIGHT ASSEMBLY 
    1. Adjust the headlight for LED headlight (see ADJUSTMENT ).
    2. Adjust the headlight for HID headlight (see ADJUSTMENT ).
24. ADJUST OBJECT RECOGNITION CAMERA 
    1. Adjust object recognition camera (see ADJUSTMENT )