LEMON Manuals: Even more car manuals for everyone
Home >> Lexus >> 2007 >> IS 250 RWD, Standard >> Repair and Diagnosis >> Electrical >> Gauges >> Meter >> Meter / Gauge System >> Data List / Active Test

Data List / Active Test

  1. DATA LIST 

    HINT:

    Using the intelligent tester to read the DATA LIST allows the values or states of switches, sensors, actuators, and other items to be read without removing any parts. This non intrusive inspection can be very useful as intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the DATA LIST information early in troubleshooting is one way to save diagnostic time.

    1. Warm up the engine.
    2. Engine switch off.
    3. Connect the intelligent tester to the DLC3.
    4. Engine switch on (IG) position.
    5. Turn the tester ON.
    6. Enter following menus: DIAGNOSIS / OBD/MOBD / METER / DATA LIST
    7. Check the values by referring to the table below.
      Fig 1: Connecting Intelligent Tester To DLC3
      G05320793Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002

      METER: 

      METER

      Tester Display Measurement Item/Range Normal Condition Diagnostic Note
      SPEED METER Vehicle speed/Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph) Almost same as actual vehicle speed (When driving) -
      TACHO METER Engine speed/Min.: 0 rpm, Max.: 12,750 rpm Almost same as actual engine speed (When engine is running) -
      FUEL GAUGE Fuel input signal Min.: 0, Max.: 255 Fuel gauge indicates (F): 35
      Fuel gauge indicates (3/4): 85
      Fuel gauge indicates (1/2): 145
      Fuel gauge indicates (1/4): 186
      Fuel gauge indicates (E): 205      		 -
      LIGHT RHEOSTAT Light Control Rheostat/Min.: 0, Max.: 255 Light control rheostat switch is Dark (0) → Bright (255) -
      ODO/TRIP SW ODO/TRIP switch is ON/OFF ON: Switch is pushed
      OFF: Switch is released      		 -
      TAIL CANCEL SW TAIL CANCEL switch is ON/OFF ON: Light control rheostat turns fully clockwise
      OFF: Light control rheostat does not turn fully clockwise      		 -

      HINT:

      The tail cancel switch is used to cancel the link between taillight operation and dimming of the combination meter.

      ABS/TRAC/VSC: 

      ABS/TRAC/VSC

      Tester Display Measurement Item/Range Normal Condition Diagnostic Note
      FR/FL/RR/RL WHEEL SPD Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost same as actual vehicle speed (When driving) -
      VEHICLE SPD Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph) Almost same as actual vehicle speed (When driving) -
      LEVER POSITION ATT shift position P/R/N/D Same as actual shift position -
      PARKING BRAKE SW Parking brake switch is ON/OFF ON: Parking brake is on
      OFF: Parking brake is released      		 -

      ENGINE: 

      ENGINE

      Tester Display Measurement Item/Range Normal Condition Diagnostic Note
      VEHICLE SPD Vehicle speed/Min.: -256 km/h (-159 mph), Max.: 254 km/h (158 mph) Almost same as actual vehicle speed (When driving) -
      COOLANT TEMP Coolant temperature/Min.: -40°C (-40°F), Max.: 140°C (284°F) After warming up: 80 to 95°C (176 to 203°F) If the value is "-40°C (-40°F)" or "140°C (284°F)", sensor circuits are open or shorted.
  2. ACTIVE TEST 

    HINT:

    Performing the ACTIVE TEST using the intelligent tester allows the meters, indicators and so on to operate without parts removal. Performing the ACTIVE TEST as the first step of troubleshooting is one way to shorten diagnosis time.

    It is possible to display the DATA LIST on the intelligent tester during the ACTIVE TEST.

    1. Connect the intelligent tester to the DLC3.
    2. Engine switch on (IG).
    3. Turn the tester ON.
    4. Enter following menus: DIAGNOSIS / OBD/MOBD / METER/ACTIVE TEST
    5. From the display on tester, perform "ACTIVE TEST".
      Fig 2: Identifying Intelligent Tester To DLC3
      G05320793Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002

      METER: 

      METER

      Tester Display Test Part Control Range
      SPEED METER 0, 40 (24), 80 (48), 120 (72), 160 (96), 200 (120) km/h (mph) -
      TACHO METER 0, 1,000, 2,000, 3,000, 4,000, 5,000, 6,000, 7,000 (rpm) -
      FUEL GAUGE EMPTY, 1/2, FULL -
      COOLANT TEMP LOW, NORMAL, HIGH -
      SHIFT INDIC P/R/N/D/S ((1)) A/T shift indicator light P/R/N/D/S (OFF/ON) Confirm that the vehicle is stopped with the idling
      BRAKE WARN BRAKE warning light (OFF/ON) Confirm that the vehicle is stopped with the idling
      DISCHARGE WARN CHARGE warning light (OFF/ON) Confirm that the vehicle is stopped with the idling
      D-BELT REMIND D-SEAT BELT indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      P-BELT REMIND P-SEAT BELT indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      OPEN DOOR WARN DOOR warning light (OFF/ON) Confirm that the vehicle is stopped with the idling
      LOW FUEL WARN FUEL warning light (OFF/ON) Confirm that the vehicle is stopped with the idling
      ECT PWR INDIC ((1)) ECT PWR indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      ECT SNOW INDIC ((1)) ECT SNOW indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      CRUISE INDIC CRUISE indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      HEADLIGHT INDIC ((2)) HEAD indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      TAILLIGHT INDIC ((3)) TAIL indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      HIGH BEAM INDIC BEAM indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      SRS WARN AIRBAG indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      SLIP INDIC SLIP indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      ABS WARN ABS indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      ODO/TRIP DISP All the dot in the multi-information display (OFF/ON) Confirm that the vehicle is stopped with the idling
      TIRE PRESS WARN ((4)) TIRE PRESS warning light (OFF/ON) Confirm that the vehicle is stopped with the idling
      KEY REMND BUZZR Key reminder buzzer (OFF/ON) Confirm that the vehicle is stopped with the idling
      SEAT BELT BUZZR Seat belt buzzer (OFF/ON) Confirm that the vehicle is stopped with the idling
      S SHFT RJCT BUZ Sports shift reject buzzer (OFF/ON) Confirm that the vehicle is stopped with the idling
      WARNING BUZZER Warning buzzer (OFF/ON) Confirm that the vehicle is stopped with the idling
      CLEARANCE SONAR ((5)) CLEARANCE SONAR indicator light (OFF/ ON) Confirm that the vehicle is stopped with the idling
      A/T SHFT LCD ((1)) All the dot in the multi-information display (OFF/ON) Confirm that the vehicle is stopped with the idling
      AFS INDICATOR ((6)) AFS OFF indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      EMPS INDIC EPS indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      MST WARN INDIC MASTER warning light (OFF/ON) Confirm that the vehicle is stopped with the idling
      MULTI-DISP All the dot in the multi-information display (OFF/ON) Confirm that the vehicle is stopped with the idling
      PRECRASH INDIC ((7)) PRECRASH indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      VSC OFF INDIC VSC OFF indicator light (OFF/ON) Confirm that the vehicle is stopped with the idling
      (1) for Automatic Transmission
      (2) for U.S.A.
      (3) for Canada
      (4) with Tire Pressure Warning System
      (5) with Clearance Sonar System
      (6) with Intelligent AFS
      (7) with Pre-collision System

      MAIN BODY: 

      MAIN BODY

      Tester Display Test Part Control Range
      DIMMER SIG Auto dimmer signal is (OFF/ON) Confirm that the vehicle is stopped with the idling
scientia non olet · About LEMON Manuals