|
|
- Excess play in steering system
|
|
| |
- Contamination of brake pads and discs
|
- Check and rectify the source of the contamination and install new brake pads and discs as required, refer to the new module/component installation note at the top of the symptom charts. Refer to: SYMPTOM CHARTS
|
| |
- Seized front brake caliper slide pins or piston
- Damaged brake discs
|
- Check and rectify sticking slide pins and install new calipers as required, refer to the new module/component installation note at the top of the symptom charts. Refer to: SYMPTOM CHARTS
- Check and install new brake discs as required, refer to the new module/component installation note at the top of the symptom charts. Refer to: SYMPTOM CHARTS
|
| |
- Incorrect geometry settings
|
NOTE:
Dealer hips must keep a copy of the BEFORE and AFTER geometry figures with job card for future reference
|
- Vehicle pulls to one side when driving on a level surface
|
- Uneven tire wear
- Incorrect tire pressure
|
|
| |
- Incorrect geometry settings
|
NOTE:
Dealerships must keep a copy of the BEFORE and AFTER geometry figures with job card for future reference
|
| |
- Vehicle is unevenly loaded or overloaded
|
- Notify the customer of incorrect vehicle loading
|
| |
- Excess play in steering system
|
|
| |
- Loose, damaged or worn front suspension components
|
- Check/tighten and install new front suspension components as required. Refer to: SPECIFICATIONS
|
| |
- Loose, damaged or worn rear suspension components
|
- Check/tighten and install new rear suspension components as required. Refer to: SPECIFICATIONS
|
| |
- Incorrect brake operation
|
|
| |
- Incorrect underbody alignment
|
|
- Wheel fight (kick back) - condition where roughness is felt in the steering wheel by the driver when the vehicle is driven over rough surfaces
|
- Loose or worn steering components/bushings
|
CAUTION:
DO NOT attempt to adjust the steering gear yoke. Failure to follow this instruction will invalidate the steering gear warranty.
|
| |
- Loose or worn suspension components/bushings
|
- Tighten and install new suspension components/bushings as required
|
- Nibble (shimmy) - condition where oscillation of the steering wheel occurs (not vertical which is shake). This is driven by road wheel imbalance
- Shake - condition where vertical vibration of the steering wheel/column occurs (not oscillation which is nibble)
|
- Road wheel incorrect balance/radial force variation/forcing
|
|