Charging System
CHARGING SYSTEM TROUBLESHOOTING CHART
| Symptom | Suspect area | Remedy |
|---|---|---|
| Charging warning indicator does not light with ignition switch "ON" and engine off. | Fuse blown Light burned out Wiring connection loose Electronic voltage regulator |
Check fuses Replace light Tighten loose connection Replace voltage regulator |
| Charging warning indicator does not go out with engine running (Battery requires frequent recharging) | Drive belt loose or worn Battery cable loose, corroded or worn Electronic voltage regulator or alternator Wiring |
Adjust belt tension or replace belt Inspect cable connection, repair or replace cable Replace voltage regulator or alternator Repair or replace wiring |
| Overcharge | Electronic voltage regulator Voltage sensing wire |
Replace voltage regulator Repair or replace wiring |
| Discharge | Drive belt loose or worn Wiring connection loose or short circuit Electronic voltage regulator or alternator Poor grounding Worn battery |
Adjust belt tension or replace belt Inspect wiring connection, repair or replace wiring Replace voltage regulator or alternator Inspect ground or repair Replace battery |