LEMON Manuals: Even more car manuals for everyone
Home >> Kia >> 2008 >> Spectra SX, 2.0 2, Automatic >> Repair and Diagnosis (Single Page) >> Engine Mechanical >> Accessory Drive Belts >> Air Conditioning System >> Repair Procedures >> Refrigerant System Service Basics >> System Charging

System Charging

Use only service equipment that is U.L. listed and is certified to meet the requirements of SAE J2210 to remove HFC-134a (R-134a) from the air conditioning system.

CAUTION:
  • Air conditioning refrigerant or lubricant vapor can irritate your eyes, nose, or throat.
  • Be careful when connecting service equipment.
  • Do not breathe refrigerant or vapor.

If accidental system discharge occurs, ventilate work area before resuming service.

Additional health and safety information may be obtained from the refrigerant and lubricant manufacturers.

  1. Connect an R-134a refrigerant

    Recovery/Recycling/Charging System (A) to the high-pressure service port (B) as shown in illustration, following the equipment manufacturer's instructions.

    Fig 1: Identifying Charging System And High-Pressure Service Port
    G06401202Courtesy of KIA MOTORS AMERICA, INC.
  2. Add the same amount of new refrigerant oil to system that was removed during recovery. Use only specified refrigerant oil. Charge the system with 15.8 ± 0.88 oz. (450 ± 25g) of R-134a refrigerant. Do not overcharge the system the compressor will be damaged.
scientia non olet · About LEMON Manuals