LEMON Manuals: Even more car manuals for everyone
Home >> Kia >> 2007 >> Rio LX, Automatic >> Repair and Diagnosis >> External Pages >> Different car >> Section 1 (Engine Mechanical) >> Engine Block >> Inspection >> Connecting Rods

Connecting Rods

WARNING: This page is about a different car, the 2007 Kia Sedona and 2006 Kia Sedona. However, it is still accessible from the selected car via links, so may be relevant.
  1. When reinstalling, make sure that cylinder numbers put on the connecting rod and cap at disassembly match. When a new connecting rod is installed, make sure that the notches for holding the bearing in place are on the same side.
  2. Replace the connecting rod if it is damaged on the thrust faces at either end. Also if step wear or a severely rough surface of the inside diameter of the small end is apparent, the rod must be replaced as well.
  3. Using a connecting rod aligning tool, check the rod for bend and twist. If the measured value is close to the repair limit, correct the rod by a press. Any connecting rod that has been severely bent or distorted should be replaced.

Allowable bend of connecting rod :

0.05 mm / 100 mm (0.0020 in./3.94 in.) or less

Allowable twist of connecting rod :

0.1 mm / 100 mm (0.0039 in./3.94 in.) or less