Technical Service Bulletins: Other Variant

WARNING: This page is about the Wrangler SE, 2.4 1, Automatic, which is a different variant/trim than selected.

A/C Compressor
- Fluid Flushing Requirements (26-003-07)
Accessories Control Systems
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
Accessory Drive Belts
- 2.4L Engine - Chirp-Like Sound From Accessory Drive Belt (07-003-05)
Air Bag, SRS
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
Anti-Theft Systems
- Powertrain Control Module Initialization (08-030-06 REV.A)
Automatic Trans
- Fluid Flushing Requirements (26-004-12)
- Fluid Flushing Requirements (26-003-07)
- Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
- Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
- Automatic Transmission Diagnostic TEARDOWN Procedure (21-009-03)
Auxiliary Emission Control Systems
- Evaporative Systems Service (25-001-04)
Body Interior
- Scan Tool Support Before And After Collision Repair (31-002-16)
Brakes Control Systems
- Flash: Intermittent 4WD Lamp Or DTC P0573 - Brake Switch #1 Circuit High (08-029-05)
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
Communication Devices
- Radio Communication Equipment Installation Recommendations (08-024-05)
Cooling System (Mechanical)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
Cruise Control Systems
- Flash: DRIVEABILITY Improvements Or Mil Illumination With Diagnostic Trouble Codes P2074 (18-042-04)
Differentials & Drive Axles
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
- Flash: Off-ROADING In 4WD Low Range - Axle Lockers May Unlock When Ignition Key Is Cycled (03-001-05)
Engine Control Systems
- Generic Powertrain Control Module (Pcm) Procedure (18-042-14)
- I/M Readiness Check Continues To Indicate OBD System Is Not Ready For I/M Testing (X51 LIFTETIME Warranty Extension) (25-005-13 REV. A)
- Flash: 42RLE - Improved Hill Climb Capability In Reverse Or DTC'S P1713/P1776 (21-017-05)
- Flash: Mil Illumination Due To Diagnostic Trouble Code P0340 Or P0344 (18-015-09)
- Powertrain Control Module Initialization (08-030-06 REV.A)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Powertrain Control Module Initialization (08-015-05)
- Flash: DRIVEABILITY Improvements Or Mil Illumination With Diagnostic Trouble Codes P2074 (18-042-04)
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
Entertainment Systems
- Buzz Or Rattle-Like Sound From Sound Bar Radio Speaker Housing And/Or Harness (08-040-05)
Exhaust
- Flash: DTC P0420 / P0430 - Catalyst Efficiency (18-046-07)
Exterior Body Panels
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Welded Sheet Metal Repairs And Replacements (31-007-12)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Repair Parts Used For Structural Repairs (31-002-11)
- Use Of Heat To Straighten Damaged Components (31-001-11)
- Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
Exterior Lights
- Exterior Lamp Condensation And Fogging (08-091-14)
Frames, Subframes & Crossmembers
- Repair Parts Used For Structural Repairs (31-002-11)
Front Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
- Special Offset Ball Joint - Allows Adjustment To Caster And Camber Angles (02-006-04)
Fuel System
- Hard To Fill With Fuel Or Fuel Nozzle Shuts Off Repeatedly (14-001-09 REV. A)
Gauges & Instrument Panels
- I/M Readiness Check Continues To Indicate OBD System Is Not Ready For I/M Testing (25-001-07)
Headlights
- Exterior Lamp Condensation And Fogging (08-091-14)
HVAC Control Systems
- A/C Cooling Coil Odor (24-013-05)
Identification
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
Interior/Exterior Trim
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
Locking Hubs
- Flash: Off-ROADING In 4WD Low Range - Axle Lockers May Unlock When Ignition Key Is Cycled (03-001-05)
Lubrication System
- Fluid Flushing Requirements (26-004-12)
- Fluid Flushing Requirements (26-003-07)
- Gasoline Engine Oil Quality And Viscosity Grades (09-013-04)
Manual Steering
- Fluid Flushing Requirements (26-004-12)
- Power Steering Fluid Contamination (19-010-04)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Fluid Flushing Requirements (26-003-07)
- Cylinder Head Bolt Re-Torque Procedure (09-001-05)
Mechanical - Hydraulic
- Fluid Flushing Requirements (26-004-12)
- Fluid Flushing Requirements (26-003-07)
Paint & Coatings
- Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
Passive Restraints
- Safety Systems - Vehicle Modifications/Repair (08-027-04)
Rear Suspension
- Shock Strut Weeping Condition Identification (02-001-15)
Restraints Control Systems
- Salvaged Airbags Or Other Salvaged Restraint System Component Usage (31-003-11)
Schedule
- Fluid Flushing Requirements (26-004-12)
Seats
- Replacement Seat Covers And Seat Cover Repairs (31-004-11)
Steering Column
- Steering Wheel Not Centered (02-002-15)
- Steering Shimmy (19-003-06)
Steering Control Systems
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
Steering Linkage
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Sun Roof/T-Top/Convertible Top
- Soft Top - Seam Sealer Tape Repair (23-008-05)
- Seam Sealing Tape May Not Have Fully Fused To Soft Top (23-041-04)
System
- Generic Powertrain Control Module (Pcm) Procedure (18-042-14)
- I/M Readiness Check Continues To Indicate OBD System Is Not Ready For I/M Testing (X51 LIFTETIME Warranty Extension) (25-005-13 REV. A)
- Flash: 42RLE - Improved Hill Climb Capability In Reverse Or DTC'S P1713/P1776 (21-017-05)
- Flash: Mil Illumination Due To Diagnostic Trouble Code P0340 Or P0344 (18-015-09)
- Flash: DTC P2074 - 2.4L - Map/TPS Correlation (18-007-08)
- Flash: DTC P0420 / P0430 - Catalyst Efficiency (18-046-07)
- I/M Readiness Check Continues To Indicate OBD System Is Not Ready For I/M Testing (25-001-07)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Flash: Intermittent 4WD Lamp Or DTC P0573 - Brake Switch #1 Circuit High (08-029-05)
- Flash: Mil Illumination With Diagnostic Trouble Code P0339 (18-035-04 REV. A)
- Flash: DRIVEABILITY Improvements Or Mil Illumination With Diagnostic Trouble Codes P2074 (18-042-04)
Transmission Control Systems
- Generic Powertrain Control Module (Pcm) Procedure (18-042-14)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Flash: Intermittent 4WD Lamp Or DTC P0573 - Brake Switch #1 Circuit High (08-029-05)
- MIL ILLUMINATION FOR DTC's P0750, P0755, P0760, P0765, P0846, P0871 OR P0841 (21-009-05)
Wheel Alignment
- Steering Wheel Not Centered (02-002-15)
- Vehicle Pulls Or Leads Right Or Left (02-003-15)
- Special Offset Ball Joint - Allows Adjustment To Caster And Camber Angles (02-006-04)
Wheel Hubs
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Wheels & Tire System
- Safety Certification And Tire Pressure Label Replacement Guidelines (31-002-18)
- Steering Wheel Vibration Diagnostic Procedure (22-001-14 REV. A)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Reconditioned Wheel Usage (31-005-11)
Window Motors & Regulators
- Circular/Ring Marks On Glass (23-035-05)
- Rear Window Lift Glass Seal/Carrier Replacement (23-022-04)
Wiper/Washer Systems
- Windshield Wiper Blade/Element Maintenance (23-037-15)
- Hard Top Rear Wiper Blade - Contacts CHMSL Housing (23-026-05)