Technical Service Bulletins

A/C Compressor
- A/C System Additives (24-003-03)
- A/C System Leak Detection (24-009-02)
- A/C Evaporator Freeze Up (24-13-99)
Accessories Control Systems
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
Air Bag, SRS
- Airbag On-Off Switches (08-37-99)
- Driver Airbag Trim Cover Service (19-009-01)
- Airbag/Clock Spring Service (08-010-01)
- Non-Deployed Airbag Handling Procedures (08-27-00)
- Erratic I/P Operation Intermittent Air Bag Light On (08-15-99)
Anti-Theft Systems
- Powertrain Control Module Initialization (08-030-06 REV.A)
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
- Vehicle Start & Stall Or Vehicle No-Start (08-14-99)
- Water Leak Diagnostic/Repair Procedure (23-49-96)
Automatic Trans
- Automatic Transmission Diagnostic Tear Down Procedure (21-021-08)
- Automatic Transmission Fluid Usage ATF+4 (Type Ms9602) (21-014-07)
- Automatic Transmission Diagnostic TEARDOWN Procedure (21-009-03)
- Automatic Transmission Fluid Usage ATF+4 (Type 9602) (21-16-99)
- Common Diagnostic Trouble Codes Caused By Open Fuse (18-09-99)
- Buzz/Whine/Moan From Cold Trans. When In Reverse (21-08-99)
- Erroneous Mil Illumination With DTC $A8 (P1763) (21-04-00)
- In Transit Protective Film - Removal/Cleaning (23-45-98)
Auxiliary Emission Control Systems
- Evaporative Systems Service (25-001-04)
- Flash Programming Failure Recovery (18-32-98)
- Additional Diagnostics For DTC'S Caused By An Evaporative System Leak (25-004-01)
- Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
- Misdiagnosed Leak Detection Pump System (18-01-00)
- Engine Miss While Performing Diagnostics With DRBIII (18-25-99)
- DRB III Leak Detection Pump (LDP) Monitor Test (18-17-97)
- Common Diagnostic Trouble Codes Caused By Open Fuse (18-09-99)
- Erroneous Mil Illumination With DTC $A8 (P1763) (21-04-00)
- 4.0L - Engine Sag When A/C Compressor Cycles (18-43-98)
- 4.0L - Idle Undershoot/Dies When Shifting Auto Trans (18-46-98)
- Addition Of Clear Flood Feature (18-37-98)
- Erroneous Mil Illumination/DTC $12 (P0443) (18-35-98)
- High Idle Rpm On DECEL With Engine Temps Over 217F (18-40-98)
- Idle Speed Overshoot/Undershoot In Low Range 4WD (18-41-98)
- Start & Stall/Idle Undershoot - Lost IAC Steps (18-36-98)
- Non Turbo Gas Engine I/M OBDII "Carb" Readiness (25-02-98)
- Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
Body Interior
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Flash Programming Failure Recovery (18-32-98)
- A/C Evaporator Freeze Up (24-13-99)
- Heating & A/C Will Not Switch To I/P Outlet Mode (24-12-99)
Brakes Control Systems
- Common Diagnostic Trouble Codes Caused By Open Fuse (18-09-99)
Differentials & Drive Axles
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
- In Transit Protective Film - Removal/Cleaning (23-45-98)
Electronic Steering
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Electronic Suspension
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Engine Control Systems
- Powertrain Control Module Initialization (08-030-06 REV.A)
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Powertrain Control Module Initialization (08-015-05)
- 4.0L Multiple Cylinder Misfire (09-003-03)
- Flash Programming Failure Recovery (18-32-98)
- Generic Scan Tool (GST) (18-012-01)
- Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
- Engine Miss While Performing Diagnostics With DRBIII (18-25-99)
- Common Diagnostic Trouble Codes Caused By Open Fuse (18-09-99)
- Erroneous Mil Illumination With DTC $A8 (P1763) (21-04-00)
- 4.0L - Engine Sag When A/C Compressor Cycles (18-43-98)
- 4.0L - Idle Undershoot/Dies When Shifting Auto Trans (18-46-98)
- Addition Of Clear Flood Feature (18-37-98)
- Erroneous Mil Illumination/DTC $12 (P0443) (18-35-98)
- High Idle Rpm On DECEL With Engine Temps Over 217F (18-40-98)
- Idle Speed Overshoot/Undershoot In Low Range 4WD (18-41-98)
- Start & Stall/Idle Undershoot - Lost IAC Steps (18-36-98)
- Non Turbo Gas Engine I/M OBDII "Carb" Readiness (25-02-98)
- Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
Entertainment Systems
- Recordable Compact Disc Used In Automotive Cd Player (08-11-00)
- Radio Service - Additional Support Bracket (08-02-99)
Exhaust
- 2.5L - Outer Exhaust Manifold Studs Breaking (11-07-98 REV. A)
Exterior Body Panels
- Scan Tool Support Before And After Collision Repair (31-002-16)
- Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Welded Sheet Metal Repairs And Replacements (31-007-12)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Windshield - Cowl Water Leaks (23-007-01)
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
Frames, Subframes & Crossmembers
- Windshield - Cowl Water Leaks (23-007-01)
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
Front Suspension
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Fuses & Circuit Breakers
- Wire Splice Repairs (08-06-00)
- Power Distribution Center Service (08-07-99)
- Ignition Off Draw Fuse Location (08-42-98)
Gauges & Instrument Panels
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
- Erratic I/P Operation Intermittent Air Bag Light On (08-15-99)
HVAC Control Systems
- A/C Cooling Coil Odor (24-013-05)
- HVAC Drain Water Leaks Inside Vehicle And Under Passenger Side Front Carpet (24-012-01)
- A/C System Additives (24-003-03)
- A/C System Leak Detection (24-009-02)
- Wet Carpet/Floor - Water Drips From Evaporator Drain (24-21-99)
- A/C Evaporator Freeze Up (24-13-99)
- Heating & A/C Will Not Switch To I/P Outlet Mode (24-12-99)
Interior/Exterior Trim
- HVAC Drain Water Leaks Inside Vehicle And Under Passenger Side Front Carpet (24-012-01)
- Driver Airbag Trim Cover Service (19-009-01)
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
- Water Leak Diagnostic/Repair Procedure (23-49-96)
Lubrication System
- In Transit Protective Film - Removal/Cleaning (23-45-98)
Manual Steering
- Power Steering Fluid Usage (19-007-01)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- 4.0L Multiple Cylinder Misfire (09-003-03)
- 2.5L - Outer Exhaust Manifold Studs Breaking (11-07-98 REV. A)
Mechanical - Hydraulic
- In Transit Protective Film - Removal/Cleaning (23-45-98)
- Disc Brake Rotor Pulsation (05-03-98 REV. A)
Paint & Coatings
- Do Not Apply Corrosion Protection On Sheet Molding Compound (SMC) Plastic Panels (31-005-12)
- Blending CLEARCOAT During The Refinish Process (31-002-13)
- OVERSPRAY Removal (31-001-13)
- Front Fascia Repair When License Plate Bracket Has Been Removed (31-004-12)
- Improved Door Weather Strip (23-41-99)
- In Transit Protective Film - Removal/Cleaning (23-45-98)
Passive Restraints
- Child Seat Tether Anchor Installation (23-35-99 REV.A)
Rear Suspension
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Restraints Control Systems
- Airbag On-Off Switches (08-37-99)
- Erratic I/P Operation Intermittent Air Bag Light On (08-15-99)
Seats
- Child Seat Tether Anchor Installation (23-35-99 REV.A)
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
Steering Column
- Steering Wheel Not Centered (02-002-15)
- Steering Shimmy (19-003-06)
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Steering Control Systems
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
Steering Linkage
- A Self-Sustaining Vibration (Shimmy) Of The Vehicle And Steering Wheel While Driving At Speeds Typically Above 50 Mph (80 KMH) (19-002-12)
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Sun Roof/T-Top/Convertible Top
- Soft Top Zipper Cleaner And Lubricant - For Difficult To Operate Window Zippers (23-025-01)
- Hardtop Roof Sag (23-18-00)
- Improved Door Weather Strip (23-41-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
Suspension Control Systems
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
System
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- 4.0L Multiple Cylinder Misfire (09-003-03)
- Flash Programming Failure Recovery (18-32-98)
- Generic Scan Tool (GST) (18-012-01)
- Additional Diagnostics For DTC'S Caused By An Evaporative System Leak (25-004-01)
- Leak Detection Pump (LDP) Operation And Diagnosis (PUB. NO. 81-170-00006)
- Misdiagnosed Leak Detection Pump System (18-01-00)
- Engine Miss While Performing Diagnostics With DRBIII (18-25-99)
- DRB III Leak Detection Pump (LDP) Monitor Test (18-17-97)
- Common Diagnostic Trouble Codes Caused By Open Fuse (18-09-99)
- Erroneous Mil Illumination With DTC $A8 (P1763) (21-04-00)
- 4.0L - Engine Sag When A/C Compressor Cycles (18-43-98)
- 4.0L - Idle Undershoot/Dies When Shifting Auto Trans (18-46-98)
- Addition Of Clear Flood Feature (18-37-98)
- Erroneous Mil Illumination/DTC $12 (P0443) (18-35-98)
- High Idle Rpm On DECEL With Engine Temps Over 217F (18-40-98)
- Idle Speed Overshoot/Undershoot In Low Range 4WD (18-41-98)
- Start & Stall/Idle Undershoot - Lost IAC Steps (18-36-98)
- Non Turbo Gas Engine I/M OBDII "Carb" Readiness (25-02-98)
- Use Of Two Digit Calendar Year Codes In Computers (08-36-98)
Transfer Case
- Transfer Case Shifter Noise (21-09-98)
Transmission Control Systems
- Co-Pilot Support And Correct Cable Usage (18-029-05)
- Flash Programming Failure Recovery (18-32-98)
- Common Diagnostic Trouble Codes Caused By Open Fuse (18-09-99)
Wheel Alignment
- Steering Wheel Not Centered (02-002-15)
- Vehicle Pulls Or Leads Right Or Left (02-003-15)
- Front End Alignment - Adjustable/Offset Ball Joints (02-12-99)
Wheel Hubs
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Wheels & Tire System
- Wheel Bearing And Hub Replacement/Inspection Guidelines During Collision Repairs (31-001-12)
Window Motors & Regulators
- Rear Window Lift Glass Seal/Carrier Replacement (23-022-04)
- Soft Top Zipper Cleaner And Lubricant - For Difficult To Operate Window Zippers (23-025-01)
- Windshield - Cowl Water Leaks (23-007-01)
- Improved Door Weather Strip (23-41-99)
- Soft Top Windows Appear Foggy Or Hazy (23-39-99)
- Tailgate Rattle - Revised Tailgate Latch (23-29-99)
- Water Leak Diagnostic/Repair Procedure (23-49-96)
Wiper/Washer Systems
- Windshield Wiper Blade/Element Maintenance (23-037-15)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wire Splice Repairs (08-06-00)
- Common Diagnostic Trouble Codes Caused By Open Fuse (18-09-99)